22E042 – Swing Up Table Could Drop Unexpectedly – Red Rock

SEOCONTENT-START

Red Rock LLC
IMPORTANT SAFETY RECALL
This notice applies to your vehicle
NHTSA Recall No. 22E042
June 1, 2022
Dear Owner,
This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act.
Red Rock LLC has decided that a defect, which relates to motor vehicle safety, exists in certain Swing Up Table Base (P/N 141018-04).
WHY DOES MY VEHICLE NEED REPAIRS?
The affected units may have incomplete welds that do not hold the weight rating required for this unit. The table could potentially drop down in the upright or closed position. Which can allow the table to drop unexpectedly, increasing the risk of injury.
WHAT WILL YOUR DEALER DO?
Replace the Swing Up Table base. This repair will take approximately .30 hours. The repair will be done free of charge to the consumer.
WHAT SHOULD YOU DO?
Contact the Recreational Vehicle Manufacturer to have the component replaced.
WHO SHOULD YOU CONTACT WITH FURTHER QUESTIONS OR CONCERNS?
If you have questions or concerns about this recall, please contact Red Rock customer service at (574) 5350192 your Recreational Vehicle Manufacturer via phone or email.
If your Red Rock or your dealer fails or is unable to remedy this defect without charge, or within a reasonable amount of time, you may submit a written complaint to:
Administrator
National Highway Traffic Safety Administration
1200 New Jersey AVE SE
Washington, DC 20590
You may also call the toll-free Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153); or go to http://www.safercar.gov.
WHAT IF YOU ARE A LESSOR?
Federal law requires that you forward a copy of this safety recall notice to the lessee within 10 days.
WHAT IF YOU HAVE ALREADY PAID FOR THIS REPAIR?
You may be eligible to receive a reimbursement for the cost of repairs made prior to receiving this notice. You may submit your receipts along with the attached Reimbursement Request Form by mail Red Rock LLC 1845 Hemlock Ct. Goshen, IN 46528.
We apologize for any inconvenience and thank you for your attention to this safety matter.
Sincerely,
Red Rock LLC

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-042
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Red Rock LLC
Submission Date : MAY 23, 2022
NHTSA Recall No. : 22E-042
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Red Rock LLC
Address : 1845 Hemlock Ct.
Goshen IN 46528
Company phone : 535-0192
Population :
Number of potentially involved : 944
Estimated percentage with defect : 20 %
Equipment Information :
Brand / Trade 1 : Red Rock
Model : Swing Up Table Base
Part No. : 141018-04
Size : NR
Function : NR
Descriptive Information : The recall is based on the possibility of welds breaking on a certain population of
Table Bases between the dates of January 24, 2022 and May 9, 2022. The total
number effected is 944 table bases.
Production Dates : JAN 24, 2022 – MAY 09, 2022
Description of Defect :
Description of the Defect : The affected units may have incomplete welds that do not hold the weight
rating required for this unit.
FMVSS 1 : NR
FMVSS 2 : NR
Description of the Safety Risk : The table could potentially drop down in the upright or closed position
Description of the Cause : NR
Identification of Any Warning
that can Occur :
NR
Involved Components :
Part 573 Safety Recall Report 22E-042 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
Component Name : Swing Up Table Base
Component Description : Adjustable Dinette/Sofa Table
Component Part Number : 141018-04
Supplier Identification :
Component Manufacturer
Name : Changshu Rongteng Technology
Address : NO. 246 Mocheng Avenue Mocheng St.
Changshu Foreign States
Country : China
Chronology :
On May 9, 2022, Red Rock LLC (“Red Rock Supply”) was advised by its U.S. based customer that it had been
made aware of reports that some welds holding the pieces to the dinette table base were breaking and not
holding to the proper weight rating. Red Rock Supply worked with its customers to quarantine the product and
Red Rock commenced a product review to better understand these reports. On May 13, 2022, Red Rock
identified certain batch of swing up table bases where the welds were not fully completed. On May 17, 2022,
Red Rock decided that a safety-related defect exists in certain swing up table bases.
Description of Remedy :
Description of Remedy Program : Replace the Swing Up Table Base
How Remedy Component Differs
from Recalled Component :
The remedy component has complete welds
Identify How/When Recall Condition
was Corrected in Production :
Red Rock LLC ceased distribution of this product on May 9, 2022 when it
was made aware of the possibility of incomplete welds.
Recall Schedule :
Description of Recall Schedule : Contact the Recreational Vehicle Manufacturer to have the component
replaced.
Planned Dealer Notification Date : JUN 01, 2022 – DEC 01, 2022
Planned Owner Notification Date : JUN 01, 2022 – DEC 01, 2022
Part 573 Safety Recall Report 22E-042 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : NR
Address : NR
NR
Country : NR
Company Phone : NR
* NR – Not Reported

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-042
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Red Rock LLC
Submission Date : SEP 20, 2022
NHTSA Recall No. : 22E-042
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Red Rock LLC
Address : 1845 Hemlock Ct.
Goshen IN 46528
Company phone : 535-0192
Population :
Number of potentially involved : 944
Estimated percentage with defect : 20 %
Equipment Information :
Brand / Trade 1 : Red Rock
Model : Swing Up Table Base
Part No. : 141018-04
Size : NR
Function : NR
Descriptive Information : The recall is based on the possibility of welds breaking on a certain population of
Table Bases between the dates of January 24, 2022 and May 9, 2022. The total
number effected is 944 table bases.
Production Dates : JAN 24, 2022 – MAY 09, 2022
Description of Defect :
Description of the Defect : The affected units may have incomplete welds that do not hold the weight
rating required for this unit. This could increase the risk for injury.
FMVSS 1 : NR
FMVSS 2 : NR
Description of the Safety Risk : The table could potentially drop down in the upright or closed position
increasing the risk of injury.
Description of the Cause : NR
Identification of Any Warning
that can Occur :
NR
Involved Components :
Part 573 Safety Recall Report 22E-042 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
Component Name : Swing Up Table Base
Component Description : Adjustable Dinette/Sofa Table
Component Part Number : 141018-04
Supplier Identification :
Component Manufacturer
Name : Changshu Rongteng Technology
Address : NO. 246 Mocheng Avenue Mocheng St.
Changshu Foreign States
Country : China
Chronology :
On May 9, 2022, Red Rock LLC (“Red Rock Supply”) was advised by its U.S. based customer that it had been
made aware of reports that some welds holding the pieces to the dinette table base were breaking and not
holding to the proper weight rating. Red Rock Supply worked with its customers to quarantine the product and
Red Rock commenced a product review to better understand these reports. On May 13, 2022, Red Rock
identified certain batch of swing up table bases where the welds were not fully completed. On May 17, 2022,
Red Rock decided that a safety-related defect exists in certain swing up table bases. There were no injuries
before the recall was submitted. Also, there have been no injuries reported to date.
Description of Remedy :
Description of Remedy Program : Replace the Swing Up Table Base
How Remedy Component Differs
from Recalled Component :
The remedy component has complete welds
Identify How/When Recall Condition
was Corrected in Production :
Red Rock LLC ceased distribution of this product on May 9, 2022 when it
was made aware of the possibility of incomplete welds.
Recall Schedule :
Description of Recall Schedule : Contact the Recreational Vehicle Manufacturer to have the component
replaced.
Planned Dealer Notification Date : JUN 01, 2022 – DEC 01, 2022
Planned Owner Notification Date : JUN 01, 2022 – DEC 01, 2022
Part 573 Safety Recall Report 22E-042 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : Keystone RV Company
Address : 2642 Hackberry Drive
Goshen IN 46526
Country : US
Company Phone : 5745352100
Name : Forest River
Address : 55470 County Road 1
Elkhart IN 46514
Country : US
Company Phone : 5748256242
Name : Alliance RV
Address : 301 Benchmark Dr.
Elkhart IN 46516
Country : US
Company Phone : 2602292621
* NR – Not Reported

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-042
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Red Rock LLC
Submission Date : MAY 23, 2022
NHTSA Recall No. : 22E-042
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Red Rock LLC
Address : 1845 Hemlock Ct.
Goshen IN 46528
Company phone : 535-0192
Population :
Number of potentially involved : 944
Estimated percentage with defect : 20 %
Equipment Information :
Brand / Trade 1 : Red Rock
Model : Swing Up Table Base
Part No. : 141018-04
Size : NR
Function : NR
Descriptive Information : The recall is based on the possibility of welds breaking on a certain population of
Table Bases between the dates of January 24, 2022 and May 9, 2022. The total
number effected is 944 table bases.
Production Dates : JAN 24, 2022 – MAY 09, 2022
Description of Defect :
Description of the Defect : The affected units may have incomplete welds that do not hold the weight
rating required for this unit.
FMVSS 1 : NR
FMVSS 2 : NR
Description of the Safety Risk : The table could potentially drop down in the upright or closed position
Description of the Cause : NR
Identification of Any Warning
that can Occur :
NR
Involved Components :
Part 573 Safety Recall Report 22E-042 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
Component Name : Swing Up Table Base
Component Description : Adjustable Dinette/Sofa Table
Component Part Number : 141018-04
Supplier Identification :
Component Manufacturer
Name : Changshu Rongteng Technology
Address : NO. 246 Mocheng Avenue Mocheng St.
Changshu Foreign States
Country : China
Chronology :
On May 9, 2022, Red Rock LLC (“Red Rock Supply”) was advised by its U.S. based customer that it had been
made aware of reports that some welds holding the pieces to the dinette table base were breaking and not
holding to the proper weight rating. Red Rock Supply worked with its customers to quarantine the product and
Red Rock commenced a product review to better understand these reports. On May 13, 2022, Red Rock
identified certain batch of swing up table bases where the welds were not fully completed. On May 17, 2022,
Red Rock decided that a safety-related defect exists in certain swing up table bases.
Description of Remedy :
Description of Remedy Program : Replace the Swing Up Table Base
How Remedy Component Differs
from Recalled Component :
The remedy component has complete welds
Identify How/When Recall Condition
was Corrected in Production :
Red Rock LLC ceased distribution of this product on May 9, 2022 when it
was made aware of the possibility of incomplete welds.
Recall Schedule :
Description of Recall Schedule : Contact the Recreational Vehicle Manufacturer to have the component
replaced.
Planned Dealer Notification Date : JUN 01, 2022 – DEC 01, 2022
Planned Owner Notification Date : JUN 01, 2022 – DEC 01, 2022
Part 573 Safety Recall Report 22E-042 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : NR
Address : NR
NR
Country : NR
Company Phone : NR
* NR – Not Reported

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-042
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Red Rock LLC
Submission Date : SEP 19, 2022
NHTSA Recall No. : 22E-042
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Red Rock LLC
Address : 1845 Hemlock Ct.
Goshen IN 46528
Company phone : 535-0192
Population :
Number of potentially involved : 944
Estimated percentage with defect : 20 %
Equipment Information :
Brand / Trade 1 : Red Rock
Model : Swing Up Table Base
Part No. : 141018-04
Size : NR
Function : NR
Descriptive Information : The recall is based on the possibility of welds breaking on a certain population of
Table Bases between the dates of January 24, 2022 and May 9, 2022. The total
number effected is 944 table bases.
Production Dates : JAN 24, 2022 – MAY 09, 2022
Description of Defect :
Description of the Defect : The affected units may have incomplete welds that do not hold the weight
rating required for this unit. This could increase the risk for injury.
FMVSS 1 : NR
FMVSS 2 : NR
Description of the Safety Risk : The table could potentially drop down in the upright or closed position
increasing the risk of injury.
Description of the Cause : NR
Identification of Any Warning
that can Occur :
NR
Involved Components :
Part 573 Safety Recall Report 22E-042 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
Component Name : Swing Up Table Base
Component Description : Adjustable Dinette/Sofa Table
Component Part Number : 141018-04
Supplier Identification :
Component Manufacturer
Name : Changshu Rongteng Technology
Address : NO. 246 Mocheng Avenue Mocheng St.
Changshu Foreign States
Country : China
Chronology :
On May 9, 2022, Red Rock LLC (“Red Rock Supply”) was advised by its U.S. based customer that it had been
made aware of reports that some welds holding the pieces to the dinette table base were breaking and not
holding to the proper weight rating. Red Rock Supply worked with its customers to quarantine the product and
Red Rock commenced a product review to better understand these reports. On May 13, 2022, Red Rock
identified certain batch of swing up table bases where the welds were not fully completed. On May 17, 2022,
Red Rock decided that a safety-related defect exists in certain swing up table bases.
Description of Remedy :
Description of Remedy Program : Replace the Swing Up Table Base
How Remedy Component Differs
from Recalled Component :
The remedy component has complete welds
Identify How/When Recall Condition
was Corrected in Production :
Red Rock LLC ceased distribution of this product on May 9, 2022 when it
was made aware of the possibility of incomplete welds.
Recall Schedule :
Description of Recall Schedule : Contact the Recreational Vehicle Manufacturer to have the component
replaced.
Planned Dealer Notification Date : JUN 01, 2022 – DEC 01, 2022
Planned Owner Notification Date : JUN 01, 2022 – DEC 01, 2022
Part 573 Safety Recall Report 22E-042 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : NR
Address : NR
NR
Country : NR
Company Phone : NR
* NR – Not Reported

SEOCONTENT-END