| “This site contains affiliate links for which OEMDTC may be compensated” |
June 24, 2020 NHTSA CAMPAIGN NUMBER: 20V370000
Loose Wiring Connector May Short and Cause Fire
If the CCP1 electrical connection short circuits, there would be an increased risk of a fire.
NHTSA Campaign Number: 20V370
Manufacturer Triple E Recreational Vehicles
Components ELECTRICAL SYSTEM
Potential Number of Units Affected 10
Summary
Triple E Recreational Vehicles (Triple E) is recalling certain 2020 Wonder W24RTB, W24MB, and W24FTB motorhomes built on a Ford transit chassis. The CCP1 electrical connection located on the driver’s seat base was not tightened to the correct specification and may short circuit.
Remedy
Triple E has notified owners, and dealers will tighten the electrical connection to specification, free of charge. This recall began June 26, 2020. Owners may contact Triple E customer service at 1-877-992-9906. Triple E’s number for this recall is CA#9711-1.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
SOP02673
RECREATIONAL VEHICLES
QAAR 9711 Ensure Correct Torque Applied to CCPl Electrical Connection
Department: 32
People Required: 1
Time to Complete: 2 min
Date Created: June 24, 220
Date Revised: Rev#:
Created by Initial: GK Verified: DP
1
Make sure all power is off in the coach:
1. Shore Power Unplugged
2. Battery Disconnect OFF
3. Keys not in ignition
2
Open the driver’s door and look at the base of the chair pedestal behind the rear of the cab door pillar for the CCP1 connection point.
3
Remove the cover by gently pulling on the top tab away from the seat.
4
Using a 10mm (13/32″) socket, back off the M5 nut until it spins freely.
5
Use a torque wrench to apply 35in/lbs to the nut.
6
Snap cover back over connection point, make sure it clicks
IMPORTANT SAFETY RECALL
June 25, 2020
«Owner Name»
«Address 1 »
«Address2»
«Address3 », «Prov» «Postal Code»
“This notice applies to your vehicle,
«Unit»
VIN #«VIN»
Coach Serial #«Serial»
Triple E Recreational Vehicles Recall CA#9711-1
20V370
This notice is sent to you in accordance with the requirements of the National Traffic & Motor Vehicle Safety Act. Triple E Recreational Vehicles has decided that certain 2020 Wonder motorhomes manufactured between May 4, 2020 & May 28, 2020 fail to conform to Federal Motor Vehicle Safety Standard
Description of Safety Defect:
The CCP I connection, located on the driver seat base, has not been torqued to the specified torque requirement. There is a possibility that the nut on this connection may come loose causing a short in the electrical, which could cause a fire and bodily injury.
To Have This Modification Performed:
We request your assistance to have this Safety issue corrected. Please follow the enclosed SOP02673 (Standard Operating Procedures) to perfmm the Recall. If you choose to have your selling dealer or a RV service center perform the recall it will be performed at no charge to you. The time needed to perform the recall is approximately 6 minutes. If you choose to have this Recall performed by a service center other than your dealer, prior authorization is required.
If you had this repair performed before you received this letter, you may be eligible to receive reimbursement for the cost of obtaining a prenotification remedy of the problem associated with this recall.
For more information contact Triple ERV/Leisure Travel Vans at 1-877-992-9906 Customer Service/ Warranty department or by e-mail recalls@tripleerv.com in the subject line “Recall CA#9711-1”.
For U.S. Residents
If Triple E Recreational Vehicles fails or is unable to remedy this potential defect without charge, you may submit a written complaint to the Administrator, National Highway Traffic Safety Administration, 1200 New
Jersey Ave. SE, Washington, DC 20590 or call the toll free Vehicle Safety Hotline at 1-888-327-4236; (TTY: 1-800-424-9153) or go to https://www.safercar.gov
We regret the inconvenience this Recall may cause you but want you to have complete satisfaction with your Leisure Travel Vans product. Thank you for your anticipated assistance and please do not hesitate to contact us should you require additional information.
Sincerely,
Brad Wall
Customer Service/ Warranty Manager
BW/wcw
Enclosure
1 SOP02673 (Standard Operating Procedures)
IMPORTANT SAFETY RECALL
June 25, 2020
«First Name»
«Address Line 1 »
«City», «State» «ZIP Code»
“This notice applies to this vehicle,
«ProductLine»
VIN #«Vin»
Coach #«UNIT CoachID»
Triple E Recreational Vehicles Recall CA#9711-1
20V370
This notice is sent to you in accordance with the requirements of the National Traffic & Motor Vehicle Safety Act. Triple E Recreational Vehicles has decided that certain 2020 Wonder motorhomes manufactured between May 4, 2020 & May 28, 2020 fail to conform to Federal Motor Vehicle Safety Standard
Description of Safety Defect:
The CCP 1 connection, located on the driver seat base, has not been torqued to the specified torque requirement. There is a possibility that the nut on this connection may come loose causing a short in the electrical, which could cause a fire and bodily injury.
To Have This Modification Performed:
We request your assistance to have this Safety issue corrected. Please follow the included SOP02673 (Standard Operating Procedure) to perform the recall. For reimbursement submit a warranty application form.
Labour to perform this Recall: 0.1 hrs/ unit
For more information contact Triple ERV/Leisure Travel Vans at 1-877-992-9906 Customer Service/ Warranty department or by e-mail recalls@tripleerv.com in the subject line “Recall CA#9711-1”.
Thank you for your anticipated assistance and please do not hesitate to contact us should you require additional information.
Sincerely,
Brad Wall
Customer Service/ Wananty Manager
BW/wcw
Enclosure
1 SOP02673 (Standard Operating Procedure)
3 Affected Products
Vehicles
| MAKE | MODEL | YEAR |
| WONDER | W24FTB | 2020 |
| WONDER | W24MB | 2020 |
| WONDER | W24RTB | 2020 |
10 Associated Documents
Recall Quarterly Report #1, 2020-2
RCLQRT-20V370-2534.PDF 211.147KB
Loading...
Reload document 
Open in new tab
Miscellaneous Document- Return Form
RMISC-20V370-4919.pdf 31.664KB
Loading...
Miscellaneous Document
RMISC-20V370-3933.pdf 1042.218KB
Loading...
Manufacturer Notices(to Dealers,etc)
RCMN-20V370-1456.pdf 245.671KB
Loading...
ISSUED Owner Notification Letter(Part 577)
RCONL-20V370-3489.pdf 401.656KB
Loading...
Recall Acknowledgement
RCAK-20V370-3990.pdf 244.683KB
Loading...
Defect Notice 573 Report
RCLRPT-20V370-6907.PDF 213.961KB
Loading...
Recall Quarterly Report #3, 2020-4
RCLQRT-20V370-6155.PDF 211.33KB
Loading...
Recall Quarterly Report #4, 2021-1
RCLQRT-20V370-8287.PDF 211.435KB
Loading...
Recall Quarterly Report #2, 2020-3
RCLQRT-20V370-4330.PDF 211.238KB
Loading...
Latest Recalls Documents
https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=20V370&docType=RCL
| “This site contains affiliate links for which OEMDTC may be compensated” |
- 【More Powerful Booster】: With a 1500A peak current, the Q10S car jump starter can start the 12V vehicles up to 7.0L Gas/5.5L Diesel engines . The battery starter is equipped with a high-performance force start function that helps you start depleted car batteries. even in extreme temperatures, The powerful lithium battery booster - up to 20 jump starts on a single charge . Suitable for car, truck, motorcycle, boat, RV or tractor and so on.
- 【Upgraded Protections】: Safe and easy-to-use jump starter battery pack without the worry of incorrect connections or sparks. Particularly spark-proof, reverse polarity protection, low-temperature protection, high-temperature protection, over-load protection. Safely connect to any 12-volt automotive car battery. The car battery jump box/jump cable indicator notifies you of incorrect use with an audible buzz and flashing lights.
- 【A Backup Power Pack】: Q10S Car Starter designed with 2 USB outputs (5V/3A)and (5V/2.1A), the quick charge 3.0 USB port can fully charge your cellphones, tablets, and other mobile devices at the fastest (up to 75% faster than a standard charger). And can power your other car accessories by using a 12V-16V/10A DC port. like tire inflators, inverters, and more.
- 【LED Flashlight 】: The battery starter has 3 LED lights modes: Flash Light, Strobe Light, and SOS Light. This multi-purpose flashlight and which comes in handy in case of an emergency and outdoor adventures.
- 【What You Get】: Portable Lithium Car Battery Jump Starter x1, Smart Jump Cable x1, USB Type-C Charging Cable x1, User Manual x1. 2-Years Technical Support. If you have any questions, please contact us.
- Start Dead Batteries - Safely jump start a dead battery in seconds with this compact, yet powerful, 1000-amp lithium battery jump starter - up to 20 jump starts on a single charge - and rated for gasoline engines up to 6.0-liters and diesel engines up to 3.0-liters.
- UltraSafe - Safe and easy-to-use car jumper starter and jump pack without worrying about incorrect connections or sparks. Safely connect to any 12-volt vehicle with our mistake-proof design featuring spark-proof technology and reverse polarity protection.
- Multi-Function - It's a car jump starter, portable power bank, and LED flashlight. Recharge smartphones, tablets, and other USB devices. It's easily rechargeable from any powered USB port in 3-hours at 2.1-amps. Plus, an integrated 100-lumen LED flashlight with seven light modes, including emergency strobe and SOS.
- Advanced Design - Our most advanced car battery charger jump starter ever. Featuring high-discharge lithium technology for safe operation in any climate. A rugged and water-resistant enclosure rated at IP65. A rubberized over-molded casing to prevent scratching or marring of surfaces. And an ultra-compact and lightweight design weighing just 2.4 pounds.
- In The Box - GB40 UltraSafe Portable Car Jump Starter, Heavy Duty Booster Clamps, 12-Volt Car Charger, Micro USB Charging Cable, Microfiber Storage Bag, User Guide, 1-Year Warranty, and Designed in the USA.
- Powerful Car Jumper Starter - The Scatach 011 jump starter with 3000A peak, safely start the 12V vehicles in seconds with this booster(up to 9.0L gasoline/7.0L diesel engines), up to 50 jump starts on a single charge. It is suitable for cars, trucks, motorcycles, boats, rvs, tractors, lawnmowers, snowmobiles, etc.
- Advanced Safety Features - Easy to opearte, and Safely connect to any 12-volt vehicle with intelligent protection systems design, with multiple protection including spark-proof, reverse polarity protection, low-temperature protection, high-temperature protection, over-load protection, jump pack without worrying about incorrect connections or sparks even if you're a novice.
- Portable Design - This portable car battery charger very compact design, size is only the size of an ordinary power bank (Size: 8.7"*4.6"*4" , Weight: 1.9lbs). It is very convenient to carry, won't take up much space when you go on a long drive or travel.
- Respond to Emergencies - Portable power bank with led flashlight. It can provide emergency charging for your powered-off mobile devices through the usb interface. The unique led flashlight has 3 modes, including flash light, strobe light and sos light, which will help you in time when you encounter an emergency situation outdoors.
- What will you Get ? - Scatach 011 Car Starter Jumper Power Bank X1, Smart Jump Cable X1, Usb Type-C Charging Cable X1, User Manual X1, Storage Case x1, 2 - years technical support. If you need any help, please contact us in time.
- 🚗【3000A Car battery jump starter】: With Povasee 3000A jump starter can jump start 10L GAS/8.0L DIESEL engines within seconds. About 60 quick jump starts on a single charge. Suitable for 12V passenger cars, trucks, motorcycles, boats,tractor etc.
- ✅【More than car jump starter】: The A30 jump starter battery pack can also be used as 74 Wh power bank with 2 usb outports to charge your smartphone, or other USB devices at the same time.The 400 lumen built-in LED light with 3 modes: Flashlight, Strobe, and SOS, which is helpful in t dark or in emergency.
- ✅【QC3.0 Fast Charging】: The portable jump starter has dual USB ports for charging（5V/2.4A）&（5V/3A 9V/2A 12V/1.5A）, and with QC3.0 output 2 (5-12V) (75% faster than standard chargers)This jump box can power your phones, cameras, tablets etc.
- ✅【10 Intelligent Secure Protection& Stable Operation】: Our car jump starter have 10 protection systems (reverse polarity, reverse charge, over discharge, reverse connection, short circuit, over charge, over current, over heat, spark resistance), A30 jump pack for car battery ensure your safety during using and the jump pack can work in -22°F ~ 140°F, even in any extreme weather
- ✅【2.2pounds portable jump starter】: This Upgrade battery jump starter weighs only 2.2 pounds and measures 6.61 x 3.37 x 1.7 inches, about the size of a pack of paper. You can easily put it in your bag, or anywhere in your car, without taking up any space. And with a protective case to avoid being worn and damaged.
- Powerful Battery Starter - The AVAPOW A68 car jump starter provides up to 6000A peak current and high capacity. The 2023 upgraded jumper cable can safely start all gas engines and diesel engines, including drained batteries. It is suitable for all (12-volt) cars, trucks, motorcycles, boats, RVs, tractors, ATVs, UTVs, lawnmowers, snowmobiles, etc. Meanwhile, it is ultra-lightweight and portable.
- Smart Safty Protection - The battery jump starter works with intelligent jumper clamps which provide 8 safty protections to ensure it's safe to use.Also the jumper clamps indicator light will notify you of any common incorrect operating.
- Portable Car Power Pack - This car jumper is also a car power pack that is equipped with 2 USB output ports, including one quick-charging port (5V/3A 9V/2A 12V/1.5A). It can save you 50% of the time when charging your cellphones, tablets, Kindles, or digital cameras.
- Ultra-Bright LED Light - The car battery charger jump starter is equipped with 3 modes of LED light (Lighting/Flash/SOS), and you can easily convert between lighting modes by switching the power button. The ultra-bright light can help you start your car more conveniently at night, and the strobe and SOS modes can act as a lifeguard in emergency situations.
- What's In The Jump Starter Battery Pack - 1 AVAPOW A68 car jump starter,1 smart jumper cables,1 storage case,1 USB Type-C Charging Cable,1 cigarette lighter socket adapter,1 User manual and professional & 24-hour online after-sales team for your any issue.(PS:AC adapter is not included in package)
- 1,700 Peak Amps; 425 Cranking Amps
- Clore PROFORMER Battery Technology
- 68" 2 AWG Welding Cable Leads
- Heavy Duty Powerjaw Clamps
- Built-in 3A Automatic Charger
- Start Dead Batteries - Safely jump start a dead battery in seconds with this compact, yet powerful, 2000-amp lithium battery jump starter - up to 40 jump starts on a single charge - and rated for gasoline engines up to 8.0-liters and diesel engines up to 6.0-liters.
- UltraSafe - Safe and easy-to-use car jumper starter and jump pack without worrying about incorrect connections or sparks. Safely connect to any 12-volt vehicle with our mistake-proof design featuring spark-proof technology and reverse polarity protection.
- Multi-Function - It's a car jump starter, portable power bank, and LED flashlight. Recharge smartphones, tablets, and other USB devices. It's easily rechargeable from any powered USB port in 6-hours at 2.1-amps. An integrated 400-lumen LED flashlight with seven light modes, including emergency strobe and SOS. Plus, a 12-volt, 15-amp outport port for powering any 12VDC devices, like tire inflators, inverters and more.
- Advanced Design - Our most advanced car battery charger jump starter ever. Featuring high-discharge lithium technology for safe operation in any climate. A rugged and water-resistant enclosure rated at IP65. A rubberized over-molded casing to prevent scratching or marring of surfaces. And an ultra-compact and lightweight design weighing just 5.0 pounds.
- In The Box - GB70 UltraSafe Portable Car Jump Starter, Heavy Duty Booster Clamps, XGC Male and Female Connectors, XGC Cable, Micro USB Charging Cable, Microfiber Storage Bag, User Guide, 1-Year Warranty, and Designed in the USA.
- POWERFUL LIFESAVER: This NEXPOW car jump starter has enough power (2500A peak current) to jump-start most 12 volt vehicles on the road! (up to 8.0L gas or 8L diesel engines) This NEXPOW car jump starter works with cars, motorcycles, watercraft, ATVs, UTVs, SUVs, lawnmowers, yachts, boats, pickup, snowmobiles, etc.
- SAFETY PROTECTION & LOW MAINTENANCE: The jump starter comes with UL2743 standard certification and the intelligent clamp of safety protection technologies, namely high temperature, reverse connection, low temperature, overload, low voltage, over charge, over discharge, short circuit. Also, the jump starter gets fully charged in about 6 hours.When not in use, just turn off the main switch and the device can hold the charge for more than 3 months.
- 4 LED MODES: Not just a car battery jump starter, the NEXPOW jump starter comes equipped with a very bright LED functioning as an emergency flashlight. The blue-red alternate light can function as a traffic hazard warning signal in the event of an accident. 4 modes (Spotlight/Strobe/SOS) & Red Blue Warning.
- EMERGENCY CHARGING 3.0: With the new generation dual USB 5V/3A, 9V/2A, 15V/1.5A output, which is fit for almost all USB charging devices, including phones and tablets, can quickly charge with our quick charge port, which is 1.8X faster than the standard port.
- UPGRADED TECHNOLOGY: With the same battery capacity, especially in extremely cold weather, our new Quick Discharge Start Power Jump Starter has 3-5 times enhanced current compare to the old 2nd generation.
- X for Extreme - An all-new design with extreme jump starting power for powerful engines starts. Rated at 4250-amps, this portable lithium car battery jump starter releases maximum energy at every start. This isn't an upgrade. It's a whole new series - the Extreme Series.
- Turbo Chargeable - Boost X is equipped with USB-C technology that, combined with power delivery, gives you lightning-fast recharges. Completely recharges in just 2.7-hours, or go from 0% to jump starting in just 5-minutes of charge.
- Charge Everything - With USB-C Power Delivery, you have the power to charge almost everything. Its internal power bank provides 60-watts of power - both in and out - to effortlessly power your favorite USB-C devices, like phones, tablets, laptops, wearables, and more.
- UltraSafe 2.0 - We took our UltraSafe technology and made it better. It's still our simple, mistake-free design featuring spark-proof technology and reverse polarity protection, but with enhanced thermal efficiency and power management to provide better performance and longer battery life.
- Maximum Versatility - Boost X is one of the most versatile lithium jump starters ever. Jump start all vehicle types, including cars, motorcycles, trucks, ATVs, boats, RVs, vans, SUVs, tractors, and more for up to 10.0-liter gasoline and 8.0-liter diesel engines.
Last update on 2024-06-11 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.