“This site contains affiliate links for which OEMDTC may be compensated” |
August 5, 2019 NHTSA CAMPAIGN NUMBER: 19V574000
Replacement Rear Reflectors Missing from Kit
Without the rear red reflectors, the motorcycle has reduced visibility to other drivers, increasing the risk of a crash.
NHTSA Campaign Number: 19V574
Manufacturer Harley-Davidson Motor Company
Components VISIBILITY
Potential Number of Units Affected 12,733
Summary
Harley-Davidson Motor Company (Harley-Davidson) is recalling certain Touring and CVO Touring motorcycles, including 2017-2019 FLHTCU, FLHTCUL, FLHTK ANV, FLHTKL, FLTRU, FLHTK, and 2016-2019 FLHTKSE, FLHTKSE ANV, and FLTRUSE models equipped with a Harley-Davidson Detachable Tour-Pak Luggage Conversion Kit (Part numbers 53000291, 53000291A, and 53000567). The kit did not include replacement rear red reflectors for the ones that are eliminated by installing this kit. As such, these motorcycles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, “Lamps, Reflective Devices, and Associated Equipment.”
Remedy
Harley-Davidson has notified owners, and dealers will install the replacement reflectors, free of charge. The recall began August 19, 2019. Owners may contact Harley-Davidson customer service at 1-800-258-2464. Harley-Davidson’s number for this recall is 0629.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
Check for Harley-Davidson Recalls
M1497
2019-08-13
M1497: RECALL 0629 – DETACHABLE TOUR-PAK CONVERSION KIT REFLECTORS
Purpose for Service Bulletin
This bulletin informs dealers that the P&A Harley-Davidson Detachables Tour-Pak Luggage Conversion Kits (Part No. 53000291, 53000291A and 53000567) were not equipped with reflectors to replace the factory-installed rear reflector, which may have been removed when installing this kit. Installation of these kits may cause the vehicle to fail to meet federal regulations that require motorcycles to be equipped with a red reflex reflector on the rear of the motorcycle. The absence of these reflectors could reduce the rear conspicuity of the vehicle, possibly increasing the risk of a crash.
Part No. of the conversion kits have been changed to reflect the addition of the reflectors to the kits. Refer to Detachables Tour-Pak Luggage Conversion Kits.
Click to review Dealer Communications letter:
Dealer Communications for M1497
Motorcycles Affected
2016 – 2019 Touring, CVO Touring and Touring Police.
Part Numbers
See Figure 1.
Figure 1. Reflector Kit – 91500105
Markets Affected
All markets (except Japan) are affected.
Detachables Tour-Pak Luggage Conversion Kits
Table 1. Conversion Kit Part Numbers
Early Kit Part No. | Current Kit Part No. |
53000291 | 53000291B |
53000291A | |
53000567 | 53000567A |
Kit Ordering Information
U.S. Market
Use electronic ordering system. Refer to:
M1483: Electronic Recall Ordering System
Canada Market
Use recall order form. Refer to:
Asia Pacific Market
Contact the Service and Customization Consultant.
Europe Market
Contact the Service and Customization Consultant.
India Market
Contact the Service and Customization Consultant.
Mexico Market
Contact the local service area representative at Harley-Davidson Mexico.
Dealer Inventory Instruction
- Locate all early Detachables Tour-Pak Luggage Conversion Kits. Refer to Detachables Tour-Pak Luggage Conversion
Kits.
- Remove kits from inventory.
- Order a reflector kit (Part No. 91500105) for each conversion kit.
- Remove early I-Sheet (J05807) from conversion kit and discard.
- Print and install updated I-Sheet into conversion kit. Refer to:
- Insert reflector kit into each conversion kit.
- Change early part no. to current part no. Refer to Detachables Tour-Pak Luggage Conversion Kits.
- Add back into inventory using current part no.
Required Dealer Action
NOTE
Login to SIP (Service information portal) through Google Chrometoview.
- Retrieve and print recall notice poster from SIP. Click link.
- Verify that all early conversion kits have been addressed as per this service bulletin. Refer to Dealer Inventory Instruction.
NOTE
- Apply reflectors in ambient temperatures between 21–38 °C (70–100 °F).
- Reflectors cannot be repositioned after initial installation. Do not remove protective film from adhesive until ready to apply.
- Allow at least 24 h after application before exposing the area to vigorous washing, strong water spray or extreme weather.
- The adhesive bond will increase to maximum strength after about 72 h at normal room temperature.
- See Figure 2. Mark reflector location.
- Clean the reflector mounting surface with a 50:50 mixture of isopropyl alcohol and water. Allow to dry completely.
- See Figure 2. Place reflector (2) on rear of saddlebag centered and Distance: 13 mm (0.5 in) below auxiliary tail lamp (1).
- Mark location with a grease pencil.
NOTE
Once applied, do not shift reflectors.
- Install reflector.
-
- Remove the adhesive backing from reflector.
- Place reflector in marked location.
- After placing reflector, apply even pressure across entire surface for 15 s.
- Wait 20 min before touching reflectors.
1. Auxiliary tail lamp
2. Reflector
A. Distance: 13 mm (0.5 in)
Figure 2. Reflector Placement
Credit Procedure
Credit procedure: H-Dnet and Talon Warranty Claim System Users
For each vehicle involved in this recall (involvement of the VIN (Vehicle identification number) has been verified on H-Dnet.com ), submit a recall claim per Table 2.
Table 2.
ITEM | DATA |
Claim Type | SRC |
Problem Part Number | 53000291A |
Quantity | Leave blank |
Labor Code(1) | 2747 |
Labor Hours | 0.2 h |
Customer Concern Code | 0629 |
Condition Code | 9981 |
Replacement Part Number | 91500105 |
Quantity | 1 |
(1) Download may be required
Submit a warranty claim per Table 3 for all kits in dealer stock or kits that have been retailed to a customer but are not registered to the SWR.
NOTE
Do not enter a VIN in the claim.
Table 3.
ITEM | DATA |
Claim Type | SNV |
Problem Part Number | 53000291A |
Quantity | Leave blank |
Primary Labor Code | Leave blank |
Detail Labor Code | 8888 |
Time | 0.2 h |
Customer Concern Code | 0629 |
Condition Code | 9982 |
Replacement Part Number | 91500105 |
Quantity | 1 |
Credit Procedure: GDP/SAP System Users
For each vehicle involved in this recall (involvement of the VIN has been verified on H-Dnet.com ), submit a recall claim per Table 4.
Table 4.
ITEM | DATA |
Claim Type | Recall Claim |
Fix ID-Found in Recall Number | C |
Problem Part Number | 53000291A |
Customer Concern Code | 0629 |
Condition Code | 9981 |
Submit a warranty claim per Table 5 for all kits in dealer stock or kits that have been retailed to a customer but are not registered to the SWR.
NOTE
VIN is not involved in the recall per H-Dnet.com.
Table 5.
ITEM | DATA |
Claim Type | PAM – sold or PAM – stock |
Problem Part Number | 53000291A |
Customer Concern Code | 0629 |
Condition Code | 9982 |
Labor Code | 8888 |
Time | 0.2 h |
Replacement Part Number | 91500105 |
Quantity | 1 |
IMPORTANT SAFETY RECALL
This notice applies to your vehicle, VIN #
August 20, 2019
Harley-Davidson Recall No. 0629
NHTSA Recall No. 19V-574
Dear Harley-Davidson Motorcycle Owner:
This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act.
Harley-Davidson Motor Company, Inc. has decided that certain MY16 and later Touring and CVO Touring motorcycles fail to conform to Federal Motor Vehicle Safety Standard No. 108, “Lamps, reflective devices, and associated equipment,” when equipped with H-D Detachables Tour-Pak Luggage Conversion Kits (part numbers 53000291, 53000291A and 53000567). Our records indicate that you have purchased one of these accessory kits. If you own one of these kits AND if your kit is installed on one of the motorcycles listed at the end of this letter, your vehicle may be subject to recall. Please review this letter for important information.
What is the Issue?
The P&A H-D Detachables Tour-Pak Luggage Conversion Kits (part numbers 53000291, 53000291A and 53000567) were not equipped with reflectors to replace the factory-installed rear reflector, which is removed when installing this kit. Installation of these kits on the vehicle models listed below may cause the vehicle to fail to meet federal regulations that require motorcycles to be equipped with a red reflex reflector on the rear of the motorcycle. Missing reflectors could reduce the rear visibility of the motorcycle to drivers, increasing the risk of a crash.
What Should You Do?
Please contact your authorized Harley-Davidson motorcycle dealer and arrange an appointment to have reflectors installed. Your dealer will confirm that your motorcycle is covered by this recall. If covered, the dealer will perform the recall work at no cost to you. The installation of the reflectors will take less than a half hour to perform. However, due to scheduling, the dealer may require your motorcycle for a longer period of time.
If you have sold your motorcycle and have an address for the current owner, it is important that you forward this notice to the new owner. Alternatively, you may contact us at the Harley-Davidson phone number listed below and provide us with the new contact information so that we may notify the new owner of this recall.
What If You Have Additional Questions or Concerns?
For more information or if you take your motorcycle to your dealer on a mutually agreed upon date and they are unable to perform the required service to your satisfaction, please contact Harley-Davidson Motor Company, Inc. at 1-800-258-2464 in the U.S. or 1-414-343-4056 worldwide.
If you have previously paid to have this repair performed, you may be eligible for reimbursement. For more information, please contact us at the number above.
If you are still having difficulty getting your vehicle serviced in a reasonable time, you may write the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Avenue, SE, Washington, DC 20590; or call the toll-free Auto Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153); or go to https://www.safercar.gov.
We regret any inconvenience this may cause you, but we are initiating this action in the interest of your personal safety and satisfaction with our products. Thank you for your cooperation.
Sincerely,
Harley-Davidson Motor Company, Inc.
Recall 0629
Harley-Davidson Motorcycles (U.S. and Canada configs) covered by this recall:
Model | Model Years |
FLHTCU | 2017 & Later |
FLHTCUL | 2017 & Later |
FLHTK | 2017 & Later |
FLHTK ANV | 2017 & Later |
FLHTKL | 2017 & Later |
FLTRU | 2017 & Later |
FLHTKSE | 2016 & Later |
FLHTKSE ANV | 2016 & Later |
FLTRUSE | 2016 & Later |
IMPORTANT RECALL INFORMATION
Safety Recall Campaign 0629 – Touring and CVO Touring Motorcycles with H-D DetachablesTM Tour-Pak Luggage Conversion Kit
HIGHLIGHTS
KEY DATES
CONTACT
|
August 13, 2019
Dear Dealer:
Harley-Davidson® has learned that certain MY15 and later Touring and CVO Touring motorcycles may fail to conform to regulatory standards when equipped with H-D DetachablesTM Tour-Pak Luggage Conversion Kits (part numbers 53000291, 53000291A and 53000567). Installation of these kits on the vehicle models listed in Table 1 at the end of this notice may cause the vehicle to fail to meet regulations that require motorcycles to be equipped with a red reflex reflector on the rear of the motorcycle. The absence of these reflectors could reduce the rear conspicuity of the vehicle, possibly increasing the risk of a crash.
The remedy is to first confirm that the motorcycles are covered by this recall if the H-D DetachablesTM Tour-Pak Luggage Conversion Kit is installed. If covered, perform the recommended service per Service Bulletin M1497 using the recall kit (Part No. 91500105).
Recall kits may be ordered as needed by following the instructions in the Service Bulletin. Service Bulletin M1497 will be posted the week of August 12.
In the interest of the safety of our mutual customers and as required by federal law, you may sell but NOT DELIVER any motorcycles listed in Table 1 below equipped with the affected H-D DetachablesTM Tour-Pak Luggage Conversion Kits or deliver any over the counter H-D DetachablesTM Tour-Pak Luggage Conversion Kits until the remedy is completed per the service bulletin.
In accordance with federal regulations administered by NHTSA and other appropriate market specific government agencies, Harley-Davidson Motor Company, Inc. or authorized Harley-Davidson dealers will provide notice to all owners of record of affected products with direction to arrange for the recall service.
Sincerely,
Harley-Davidson Motor Company, Inc.
0629
For: Dealer Operator, General Manager, All P&A Roles, All Service Roles, Vehicle Sales Manager
Sent to: All Dealers (Worldwide, except Japan)
U.S and Canada | All other markets | |
Model | Model Years | Model Years |
FLHTCU | 2017 & Later | 2015 & Later |
FLHTCUL | 2017 & Later | 2015 & Later |
FLHTK | 2017 & Later | 2015 & Later |
FLHTK ANV | 2017 & Later | 2015 & Later |
FLHTKL | 2017 & Later | 2015 & Later |
FLTRU | 2017 & Later | 2015 & Later |
FLHTKSE | 2016 & Later | 2016 & Later |
FLHTKSE ANV | 2016 & Later | 2016 & Later |
FLTRUSE | 2016 & Later | 2016 & Later |
Table 1: Affected Vehicles in Each Market.
30 Affected Products
Vehicles
MAKE | MODEL | YEAR |
HARLEY-DAVIDSON | FLHTCU | 2017-2019 |
HARLEY-DAVIDSON | FLHTCUL | 2017-2019 |
HARLEY-DAVIDSON | FLHTK | 2017-2019 |
HARLEY-DAVIDSON | FLHTK ANV | 2017-2019 |
HARLEY-DAVIDSON | FLHTKL | 2017-2019 |
HARLEY-DAVIDSON | FLHTKSE | 2016-2019 |
HARLEY-DAVIDSON | FLHTKSE ANV | 2016-2019 |
HARLEY-DAVIDSON | FLTRU | 2017-2019 |
HARLEY-DAVIDSON | FLTRUSE | 2016-2019 |
9 Associated Documents
Recall Quarterly Report #1, 2019-3
RCLQRT-19V574-7401.PDF 211.144KB
Recall Quarterly Report #3, 2020-1
RCLQRT-19V574-5292.PDF 211.331KB
Recall Quarterly Report #2, 2019-4
RCLQRT-19V574-7677.PDF 211.247KB
Non-Compliance Notice 573 Report
RCLRPT-19V574-9143.PDF 214.403KB
Recall Acknowledgement
RCAK-19V574-7722.pdf 287.828KB
ISSUED Owner Notification Letter(Part 577)
RCONL-19V574-2887.pdf 608.922KB
Manufacturer Notices(to Dealers, etc.) – TM Tour-Pak Luggage Conversion Kit on certain Touring and CVO Touring motorcycles may fail to meet regulations requiring it be equipped with a red reflex reflector on the rear of the motorcycle.
Remedy Instructions and TSB
RCRIT-19V574-0248.pdf 147.193KB
Recall Quarterly Report #4, 2020-2
RCLQRT-19V574-6101.PDF 211.441KB
Latest Recalls Documents
For the Latest and Most Recent Recalls Information Visit the link below…
https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=19V574&docType=RCL
“This site contains affiliate links for which OEMDTC may be compensated” |
- ★Good Quality Front Fork Leg Reflectors For Har-ley Lower Legs Slider.
- ★Installation Very Easy. You Just Need To Stick It On Your Fork With Glue.
- ★Reflects Headlights For d Visibility,Great For Night Visibility.
- ★Fitment: Har-ley All Lower Legs Slider.
- ★Included: 1 Pair Fork Reflector.
- 【Safety Reflector】Other drivers keep their distance. Even at night or in a dark environment, these high-visibility reflective stickers stand out on the road and can visibly make vehicles noticeable, thus ensuring driving safety.
- 【Easy to Install】Round Reflector set is come with compatible nuts for install, just need to twist tightly, it would not easy to fall off, convenient for your use and suitable for most motorcycles, bicycles.
- 【Universal Round Reflectors】Universal round reflectors is suitable for most brand of motorcycle, bike, dirt bike etc. Diameter: about 5.5cm / 2.16 inch.
- 【Premium Material】The reflector made of premium PP material. Durable for your motorcycle, can work for long time.Due to the angle difference, the item's color may be slightly different from the pictures. Please check the picture detail and make sure it suitable for you before ordering.
- 【Function】The round reflector is used to warning the other drivers to keep a safe distance from your motorcycle. Package Includes: 2 Pairs Round Reflectors(1 pair Red and 1 pair Yellow)
- 【Versatile Applications】Suitable for friends who need to install motorcycle license plates. They can also be applied in other scenarios, including road traffic, outdoor activities, buildings, construction sites, and even on the sides of mailboxes. They can be installed on vehicles such as bicycles, cars, as well as on buildings, road barriers, and obstacles to alert others to their presence.
- 【Improved Visibility and Safety】 By reflecting light, objects become more easily noticeable by others, including vehicles and pedestrians. This helps reduce the risk of accidents and enhances the safety of pedestrians, cyclists, and drivers.
- 【High-Quality Materials】Made of high-quality organic glass PMMA sheets and high-strength ABS, these reflectors are durable and lightweight. They possess excellent transparency and optical properties, providing high refractivity and reflectivity to enable the reflectors to effectively reflect light.
- 【Easy Installation:】Equipped with flat washers, they can be easily mounted in the desired locations. Ensure that the reflectors are securely fastened in the desired positions. Please note not to overtighten the screws to avoid damaging the reflectors or the mounting surface.
- 【Package Contents】The package includes six mini circular reflectors available in red, amber yellow, and silver colors for your selection.25mm diameter, 9mm thickness, 5mm screw holes.
- Red Reflectors, with spring & butterfly nut
- 4 in a pack
- Made with rust proof material
- Made in the U.S.A.
- Available in Amber, Red, Blue & Green
- [Size] Thread Size: M6x1.0, Dimension: 8x56mm / 0.31"x2.20"(T*D). Note: Please check the picture details and measurements before ordering to make sure it fits you.
- [Function] Motorcycle warning reflectors increase the attention of other drivers at night by reflecting light, effectively preventing traffic accidents. It is used to warn other drivers to keep a safe distance from their motorcycles.
- [Easy Installation] The motorcycle reflective stickers come with a compatible mounting nut, just twist it tightly, threaded mounting, not easy to fall off, easy to use, and suitable for most motorcycles and bikes.
- [Material] Motorcycle reflectors are made of durable plastic with fade resistance, hot summer and cold winter are no problem.
- [Package Include] 4 x Motorcycle Reflector, 4 x Nut. Note: The product will be reflective in the dark night when met lights are irradiated! Not self-luminous.
- The reflector made of material of plastic. Durable for your motorcycle, can work for long time.Due to the angle difference, the item's color may be slightly different from the pictures. Please check the picture detail and make sure it suitable for you before ordering.
- Good Reflection: It is used to warning the other drivers to keep a safe distance from your motorcycle. Thread Size: M6x1.0.
- Easy to install: come with compatible nuts for install, just need to twist tightly, it would not easy to fall off, convenient for your use and suitable for most motorcycles, bicycles.
- Good accessory for your motorcycle. Note: Please check the size measurement carefully before ordering.
- Package Include: 1 Pair Motorcycle Reflector, 2 x Nuts
- Excellent Quality - We provide the highest quality for sticker have more performance, including wear-resisting, scratch resistant. Even in the low temperature, it still won’t fall off.
- Feel Safer - When you or your family ride their bikes or drive the vehicles in the dark, it will keep you more safer. Reflectors make them very noticeable to drivers at dusk and night. Be safe and be seen!
- Easy To Install - Place adhesive backing onto surface for quick installation. When you install, you should press it carefully to avoid breaking it. Just stick the reflectors on the place you want to put on!
- Multi-purpose-- Reflectors have many purposes on different vehicles. It not only can put on the car full body, also can use it on the vessel body. Buying more of these to light up other portions on your gates and road.It is great for reflecting headlight on your rural property lane and gates
- Perfect Size -- Fits almost anywhere on multiple types of transportation methods. The dimension:4*0.7*0.6 Inch
- 【Compatibility】Multi-purpose. Small size is convenient for carrying and stock. Motorcycle side reflectors can use on different vehicles, such as trailer, bicycle, bike, trucks, cars and boat, such compatible with Honda Kawasaki, Suzuki, Yamaha, BMW motorcycles.
- 【Safety Red Reflectors】Remind the other drivers to keep their distance. Even at night or in a dark environment, these high visibility reflective stickers stand out on the road, can noticeable and effectively make the rear vehicles notice your vehicle, which ensures driving safety.
- 【High Reflective Effect】Motorcycle reflector made of high quality ABS plastic, anti-scratch, fade-proof and waterproof, durable and reliable, not easy to break or crack, with high reflective red lens cover, not easy to fade and has a long service life.
- 【5 Minutes Required to Install】Come with a strong double side adhesive tape for fixing and padding reflectors, will not fall off even at low temperatures. You just need to take off your stock reflector and push the new replacement back to its place.
- 【Buy with Confidence】You will get 1Pair red reflectors stick on. You are backed by 3-Month warranty since the order purchase date. Please feel free to contact us if you have any other problems.
- Quality Material : 2pcs reflectors are made of durable ABS plastic with fade resistant feature, it is shockproof and corrosion resistant, great for all weather conditions.
- Fitment : These reflectors are compatible with Harley Davidson Softail Standard/ Street Bob/ Fat Boy/ Breakout/ Heritage Classic. More compatible models in the product description below.
- The reflective light from sticker can increase other drivers attention at night, effectively prevent traffic collision.
- Various Applications: In addition to motorcycle front lower fork reflectors sticker, you can also stick on any flat objects, such as metal decal, car body side decal, luggage stickers, mailbox decal, laptop decals, refrigerator decals, etc. Decorate your world.
- Easy to Use : 2pcs Universal Front Fork Reflector Sticker. Easy install, with two sides adhesive, simple peel and stick. Just peel off the back and stick on. Holds tight at any speed!
Last update on 2024-04-19 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.