22E008 – Programmable Relay Power Center Module Failure – Intermotive (PRPC)

SEOCONTENT-START

Page 1 of 1
RECALL 22E008 REMEDY INSTRUCTIONS
Make(s): Intermotive
Model(s): PRPC S-M1521-xx
Concern:Programmable Relay Power
Center (“PRC”) modules may fail, causing a
thermal event.
Allotted Time: .30 HRS.
Allotted Time: .10 HRS.
Photo(s) Required: YES, BEFORE/AFTER
Prior Authorization Required: NO
Part(s) Kit Number: 840-00203
Part(s) Return: NO
Disconnect the vehicles’ battery Positive and Negative, disconnect any House battery(s) Positive and Negative, if equipped with a generator ensure it is off and lastly, ensure the vehicle is disconnected from shore power. Block any tires/wheels to prevent the vehicle from rolling. Failure to do so may result in electrocution, fire or other personal injury, property damage and/or death.
INSPECTION/REMEDY INSTRUCTIONS ARE LOCATED at Intermotive’s Website Intermotive.net
STEP 1: PLEASE FOLLOW THE INSPECTION, AND, IF REQUIRED, THE REMEDY INSTRUCTIONS FROM INTERMOTIVE VEHICLE CONTROLS REGARDING THE PROGRAMMABLE RELAY POWER CENTER (“PRC”).
NOTICE: PHOTOS ARE REQUIRED OF THE PRC.
– IF THE INSPECTION REVEALS THE PRC HAS A DATE CODE OTHER THAN 0919; TAKE A PHOTO OF THE PRC THAT SHOWS THE DATE CODE AND THE LABELS APPLIED TO THE PRC DIRECTLY AND FILE THE PHOTOS AND INVOICE INTERMOTIVE FOR THE INSPECTION. THIS WILL BE COORDINATED THROUGH INTERMOTIVE WARRANTY REPAIR @ 530-823-1048-XT103
– IF THE INSPECTION REVEALS THE PRC HAS A DATE CODE OF 0919; TAKE A PHOTO OF THE PRC THAT SHOWS THE DATE CODE AND THE LABELS APPLIED TO THE PRC DIRECTLY.
o REFERENCE THE INTERMOTIVE REMEDY INSTRUCTIONS LOCATED ON THE INTERMOTIVE WEBSITE ON HOW TO INSTALL THE JUMPER HARNESS;
o THE JUMPER HARNESS WILL NEED TO BE ORDERED FROM INTERMOTIVE.
– ONCE THE REMEDY IS COMPLETE, ANOTHER PHOTO OF THE JUMPER HARNESS INSTALLED AND AN ADDITIONAL PHOTO SHALL ACCOMPANY THE INSPECTION PHOTO SHOWING THE INSTALLATION OF THE HARNESS AND PRC WITH THE DATE CODE OF 0919.
o CLAIM THE REIMBURSEMENT THROUGH INTERMOTIVE WARRANTY DEPARTMENT.
Intermotive Warranty Department
530-823-1048 xt 103

**************************************************************************************************************

PRC DataLink Stub Harness Installation Instructions
1. CONFIRM DATE CODE: You should have already inspected the PRC modules in your buses and confirmed they have a date code of “0919” and requested and received DataLink Stub harnesses for your affected buses.
• The PRC module is usually installed in the electrical box behind a panel above the drivers head.
• It may be necessary to lift up the red “Do Not Drop”
label on the module to reveal the date code.
• Only modules with this date code are affected. You do NOT need to install this DataLink Stub harness on PRC modules with other date codes.
2.INSTALLATION: Locate the White 6-pin connector on the PRC module and unplug it by pinching the connector tab and pulling down.
• Install the DataLink Stub harness between the existing harness you just unplugged and the PRC module.
3. TEST: Make sure the PRC module functions with the DataLink Stub harness installed. Power up the vehicle and turn on accessories which are controlled by the PRC, such as Interior lights, and ensure they are functional. If not working, check that the DataLink Stub harness connections are fully seated and the inline fuse is not blown. Call InterMotive Technical Support if you need assistance:
Bill Dahl 530-823-1048 ext. 159
Steve Morsy 530-823-1048 ext. 162
InterMotive Vehicle Controls | 12840 Earhart Ave. Auburn, CA 95602 | 530-823-1048 | products@intermotive.net | www.InterMotive.net

**************************************************************************************************************

12840 Earhart Ave. | Auburn, CA 95602
P 530-823-1048 | F 530-823-1516
www.InterMotive.net
IMPORTANT SAFETY RECALL
NHTSA Recall No. 22E-008
January 11, 2022
Dear Valued Customer:
This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act.
Intermotive has decided that a defect may exist in certain Programmable Relay Power Center (PRPC) modules, part number S-M1521-XX.
Issue:
These Programmable Relay Power Center (PRPC) modules may have exposed copper which can cause the module to short circuit, increasing the risk of a fire. Our engineering department has identified the modules as having the date code of 0919.
Solution:
We have designed a jumper harness that can be quickly installed to protect the circuit on these modules. This remedy will take approximately 0.3 hours and will be free of charge.
Identification / Action Required:
Buses received between June 1, 2021 and February 28, 2022 may have a PRC module with the suspect date code. If you have received buses within this time frame, please examine the PRC modules to see if they are marked with the 0919 date code. This can be easily identified by looking under the red “Do Not Drop” label on the module. See attached pictures.
If you have any PRC modules with the 0919 date codes, please contact our Warranty department (Jesse Jennings at JJennings@Intermotive.net or at 530-823-1048 x103) between the hours of 7 am and 4 pm PT, M-F. We will send you a free jumper harness and installation instructions for any affected modules you identify.
What If You Have Already Paid For This Repair:
You are eligible to receive a reimbursement for the cost of repairs made prior to receiving this notice. Please submit your receipts along with pictures to Intermotive Warranty at JJennings@Intermotive.net or by mail to 12840 Earhart Blvd, Auburn, CA 95602. After verification, you will be promptly reimbursed.
If Intermotive fails or is unable to remedy this defect without charge, or within a reasonable amount of time, you may submit a written complaint to:
Administrator
National Highway Traffic Safety Administration
1200 New Jersey AVE SE
Washington, DC 20590
12840 Earhart Ave. | Auburn, CA 95602
P 530-823-1048 | F 530-823-1516
www.InterMotive.net
“Do Not Drop” Label
0919 Date Code
You may also call the toll-free Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153); or go to http://www.safercar.gov.
We apologize for any inconvenience. We believe that by taking an abundance of caution in this situation, it will limit damage to a 0919 PRC module should it have this specific issue.
PRPC DATE CODE IDENTIFICATION

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-008
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Intermotive
Submission Date : FEB 23, 2022
NHTSA Recall No. : 22E-008
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Intermotive
Address : 12840 Earhart Ave
Auburn CA 95602
Company phone : 8231048
Population :
Number of potentially involved : 453
Estimated percentage with defect : 1 %
Equipment Information :
Brand / Trade 1 : Intermotive
Model : PRPC
Part No. : S-M1521-xx
Size : NR
Function : Power Managemen
Descriptive Information : The time frame of the four failures reported by Forest River were modules that
were installed from 6/14/2021 – 8/30/2021. After analysis by Intermotive
Engineering, it was determined that if two specific conditions occur ( mask misregistration
and contamination are present) dendritic growth could occur and
short the power and ground plains. Both Forest River and Intermotive removed
all assemblies with the suspect date code (0919) by 12/31/2021. The four
defects were found prior to any busses being put in service and are considered
infant mortality. Forest River Identified 1762 buses built in the time frame from
06/01/2021-01/18/2022 . While zero defects have occurred from PRPC’s
shipped to other customers, it was decided that we recall the PRPC’s shipped in
this time frame and provide the solution to prevent the defect from occurring.
Intermotive has identified 453 units shipped within this time frame and could
potentially have the suspect PCB date code
Production Dates : JUN 01, 2021 – JAN 18, 2022
Description of Defect :
Description of the Defect : Intermotive has determined that a small percentage of date code 0919 pcbs
used for the PRPC had mask mis-registration causing exposed copper. Lab
analysis showed the evidence of dendritic growth which caused the short
between the power and ground planes. The failure happened after installation
and prior to the busses being put into service. All four were infant mortality.
FMVSS 1 : NR
Part 573 Safety Recall Report 22E-008 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
FMVSS 2 : NR
Description of the Safety Risk : The power to ground short causes excessive heating and the potential for
combustion. All components are appropriately spec’d to UL 94v0
flammability rating so the chance for combustion prior to the short opening
up is extremely small.
Description of the Cause : Dendritic growth occurred between the power and ground planes causing
thermal destruction of the module.
Identification of Any Warning
that can Occur :
NR
Involved Components :
Component Name : PRPC
Component Description : Programable Relay Power Center
Component Part Number : S-M1521-xx
Supplier Identification :
Component Manufacturer
Name : Intermotive
Address : 12840 Earhart Ave
Auburn California 956002
Country : United States
Chronology :
Forest River notified Intermotive of the first failures on 10/27/2021, 11/23/2021, 11/30/221 and 127/2021.
Description of Remedy :
Description of Remedy Program : Intermotive will provide all parts and labor free of charge to customers
who identify assemblies with date code 0919. Customers can contact
Intermotive Warranty at 530-823-1048 xt 103. Warranty will immediately
send out a replacement harness for the repair and offer the necessary
technical support during installation
Part 573 Safety Recall Report 22E-008 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
How Remedy Component Differs
from Recalled Component :
The remedy is adding a fused data link harness that will prevent the
thermal event from occurring.
Identify How/When Recall Condition
was Corrected in Production :
All remaining assemblies with date code 0919 have been removed from
the supply chain. Additional high magnification inspection requirements
are now in place for pcb’s to identify any exposed copper from the PCB
vendors
Recall Schedule :
Description of Recall Schedule : Intermotive has the utmost urgency to resolve this recall quickly and
efficiently. Intermotive will send a suspected serial number list to our
customers once a formal NHTSA id is provided.
Planned Dealer Notification Date : MAR 07, 2022 – MAR 07, 2022
Planned Owner Notification Date : MAR 07, 2022 – MAR 07, 2022
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : A&J Mobility
Address : 1330 Midvalley
Valders WI 54245
Country : US
Company Phone : NR
Name : American Transportation
Address : 3133 E South St Long Beach
Long Beach CA 90805
Country : US
Company Phone : NR
Name : Advanced Automotive
Address : 7528 Burnet Rd
Austin TX 78757
Country : US
Company Phone : NR
Name : Atlantic Bus Sales
Address : 1200 S. Dixie HWY
Pompano Beach CA 22060
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 4
The information contained in this report was submitted pursuant to 49 CFR §573
Name : A-Z Bus – Colton
Address : 1900 South Riverside Ave
Colton CA 92324
Country : US
Company Phone : NR
Name : A-Z Bus – Sacramento
Address : 3418 52nd Ave
Sacramento CA 95823
Country : US
Company Phone : NR
Name : Badger Bus
Address : 5501 Femrite Drive
Madison WI 53718
Country : US
Company Phone : NR
Name : Butler Automotive Service Center
Address : 14720 Southlawn Ln
Rockville MD 20850
Country : US
Company Phone : NR
Name : Chris Mobility
Address : 18386 Ostego Dr
Fort Myers FL 33967
Country : US
Company Phone : NR
Name : City of Sioux City
Address : 1821 18th street
Sioux City IA 51105
Country : US
Company Phone : NR
Name : Coach and Equipment Mfg.
Address : 130 Horizon Park
Pen Yan NY 14527
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 5
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Creative Mobility Wayne, MI
Address : 33073 Michigan Ave
Wayne MI 48184
Country : US
Company Phone : NR
Name : Driverge Vehicle Innovations
Address : 1090 West Wilbeth Road
Akron OH 44314
Country : US
Company Phone : NR
Name : G&M Service Center, Inc
Address : 7901-5 Hill Park Court
Lorton VA
Country : US
Company Phone : NR
Name : Lafayette Limo
Address : 2525 Komdike Road
West Lafayette IN 47906
Country : US
Company Phone : NR
Name : Baehrs Automotive
Address : 1224 Montlimar dr.
Mobile AL 36609
Country : US
Company Phone : 251-34-9157
Name : Brickell Complete Auto
Address : 795 SW 6th St
Miami FL 33130
Country : US
Company Phone : NR
Name : Bus Service
Address : 3153 Lamb Ave
Columbus OH 43219
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 6
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Buses at Loganville
Address : 5314 Holley Brooke Lane
Loganville GA 30052
Country : US
Company Phone : NR
Name : Camco Wheel & Axle
Address : 1105 W, Furguson St
Pharr TX 78577
Country : US
Company Phone : 956-781-4800
Name : Carpenter Bus Sales, Inc.
Address : 132 Royal Oaks
Franklin TN 37067
Country : US
Company Phone : NR
Name : Challenger Transportation
Address : 8210 Beechcraft Ave
Gaithersburg MD 20879
Country : US
Company Phone : 301 990-6000
Name : Checkered Flag Auto Bus Inc
Address : 236 Seaman Ct
Westbury NY 11590
Country : US
Company Phone : NR
Name : City of Lompoc
Address : 1300 West Laurel Ave
Lompoc CA 93436
Country : US
Company Phone : NR
Name : Colonial Bus
Address : 5171 Intercoastal Court
Monrovia MD 21770
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 7
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Continental RV
Address : 39 Allen Blvd Ste C
Farmingdale NY 11735
Country : US
Company Phone : NR
Name : Creative Bus Sales
Address : 14740 Ramona Ave
Chino CA 91710
Country : US
Company Phone : NR
Name : Creative Bus Sales (Carlstadt)
Address : 51 Kero Rd
Carlstadt NJ 07072
Country : US
Company Phone : (800) 272-6521
Name : Creative Bus Sales (Jacksonvil
Address : 8600 Atlantic Blvd
Jacksonville FL 32211
Country : US
Company Phone : 909-993-5040
Name : Delacy Ford
Address : 3061 Transit Rd
Elma NY 14059
Country : US
Company Phone : NR
Name : Driverge Vehicle Innovations
Address : 1090 West Wilbeth Road
Akron OH 44314
Country : US
Company Phone : NR
Name : Driverge Vehicle Innovations
Address : 1090 West Wilbeth Road
Akron OH 44314
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 8
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Empire Transportation, INC.
Address : 340 Mountain Ave
Perris CA 92570
Country : US
Company Phone : NR
Name : Fast Serv Medical
Address : 1329 Driftwood Dr
Bossier LA 71111
Country : US
Company Phone : NR
Name : Hoglund Bus
Address : 116 E Oakwood Drive
Monticello MN 55362
Country : US
Company Phone : NR
Name : Leader Emergency Vehicles
Address : 10941 Weaver Ave South
El Monte CA 91733
Country : US
Company Phone : NR
Name : Masters Transportation
Address : 800 Quik Trip Way
Belton MO 64012
Country : US
Company Phone : NR
Name : Mid Atlantic Mobility
Address : 19708 Old York Rd
White Hall MD 21161
Country : US
Company Phone : NR
Name : Mid-South Bus Center
Address : 3512 Bill Smith Dr
Murfreesboror TN 37129
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 9
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Mike Fraser Auto Repair
Address : 1204 7th st
Cordele GA 31015
Country : US
Company Phone : (229) 273-0652
Name : Mobility Works
Address : 810 Moe Dr
Akron OH 44310
Country : US
Company Phone : NR
Name : NAPA Store #245
Address : 11857 Metro Parkway
Fort Myers FL 33966
Country : US
Company Phone : NR
Name : New England Wheels
Address : 33 Manning Rd
Brillrica MA 01821
Country : US
Company Phone : NR
Name : Northwest Bus Sales
Address : 33207 Pacific Hwy South
Federal Way WA 98003
Country : US
Company Phone : NR
Name : On Site Fleet Service
Address : 36 Edgeboro Rd
East Brunswick NJ 08816
Country : US
Company Phone : NR
Name : Optimal EV
Address : 29449 Old US Hwy 33 , IN 46516
Elkhart IN 46516
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 10
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Quality Van Sales, Inc.
Address : 49 Old Colony Road
Norton MA 02766
Country : US
Company Phone : NR
Name : Rohrer Bus Sales
Address : PO BOX 100
Routes 11&15 Duncannon PA 17020
Country : US
Company Phone : NR
Name : Ruben Fleet
Address : 4730 Leopard St
Corpus Christi TX 78408
Country : US
Company Phone : NR
Name : Sunset Empire Transportation District
Address : 465 NE Skipanon Dr
Warrenton OR 97146
Country : US
Company Phone : NR
Name : TESCO
Address : PO Box 167230
Oregon OH 43616
Country : US
Company Phone : NR
Name : The Bus Center Acworth
Address : 110 HOLT INDUSTRIAL CIRCLE
ACWORTH GA 30101
Country : US
Company Phone : NR
Name : Three Guys Garage
Address : 4904 Augusta Rd
Garden City GA
Country : US
Company Phone : 9129649222
Part 573 Safety Recall Report 22E-008 Page 11
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Walker Auto and Truck TAX
Address : 600 NC Hwy 86 North
Hillsborough NC 27278
Country : US
Company Phone : NR
Name : Lewis Bus Group
Address : 1009 Recreation Way North
Salt Lake City UT 84054
Country : US
Company Phone : NR
Name : Mobility Medical
Address : 748 N, Harbor City Blvd
Melbourne FL 32935
Country : US
Company Phone : NR
Name : Maricopa Ambulance
Address : 10243 N. 19th Ave
Phoenix AZ 85021
Country : US
Company Phone : NR
Name : Medford Truck And Auto
Address : 11 Hall St
Medford MA 02155
Country : US
Company Phone : NR
Name : Mobility Systems
Address : 2857 Oak Grove Rd
Hattiesburg MS 39402
Country : US
Company Phone : NR
Name : Overland Custom Coach (2007) Inc.
Address : 21051 Nissouri Road Thorndale
Ontario 00 n0m2p0
Country : CA
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 12
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Penske Truck Leasing Vernon
Address : 2727 S. Santa Fe Ave
Vernon CA 90058
Country : US
Company Phone : NR
Name : Regency Taxi
Address : 8201 Shouffer School Road
Gathersburg MD 20879
Country : US
Company Phone : NR
Name : Siddons-Martin Emergency Group
Address : 3500 Shelby ln
Denton TX 76207
Country : US
Company Phone : NR
Name : Sioux City Transit
Address : 509 Nebraska st
Sioux City IA 51101
Country : US
Company Phone : 7122796405
Name : Sonny Merryman, Inc.
Address : PO Box 495
Rustburg 24588
Country : US
Company Phone : NR
Name : Southern Bus & Mobility
Address : PO Box 37 Breese
Breese IL 62230
Country : US
Company Phone : NR
Name : The Bus Center of Atlanta LLC
Address : 1400 McCain Parkway
Pelham PA 35124
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 13
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Verizon Fleet
Address : PO Box 152134
Irving TX 75015
Country : US
Company Phone : NR
Name : Wolfington Body Company, Inc,
Address : PO Box 218
Exton PA 19341
Country : US
Company Phone : NR
* NR – Not Reported

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-008
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Intermotive
Submission Date : MAY 16, 2022
NHTSA Recall No. : 22E-008
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Intermotive
Address : 12840 Earhart Ave
Auburn CA 95602
Company phone : 8231048
Population :
Number of potentially involved : 514
Estimated percentage with defect : 1 %
Equipment Information :
Brand / Trade 1 : Intermotive
Model : PRPC
Part No. : S-M1521-xx
Size : NR
Function : Power Managemen
Descriptive Information : The time frame of the four failures reported by Forest River were modules that
were installed from 6/14/2021 – 8/30/2021. After analysis by Intermotive
Engineering, it was determined that if two specific conditions occur ( mask misregistration
and contamination are present) dendritic growth could occur and
short the power and ground plains. Both Forest River and Intermotive removed
all assemblies with the suspect date code (0919) by 12/31/2021. The four
defects were found prior to any busses being put in service and are considered
infant mortality. Forest River Identified 1762 buses built in the time frame from
06/01/2021-01/18/2022 . While zero defects have occurred from PRPC’s
shipped to other customers, it was decided that we recall the PRPC’s shipped in
this time frame and provide the solution to prevent the defect from occurring.
Intermotive has identified 514 units shipped within this time frame and could
potentially have the suspect PCB date code
Production Dates : JUN 01, 2021 – JAN 18, 2022
Description of Defect :
Description of the Defect : Intermotive has determined that a small percentage of date code 0919 pcbs
used for the PRPC had mask mis-registration causing exposed copper. Lab
analysis showed the evidence of dendritic growth which caused the short
between the power and ground planes. The failure happened after installation
and prior to the busses being put into service. All four were infant mortality.
FMVSS 1 : NR
Part 573 Safety Recall Report 22E-008 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
FMVSS 2 : NR
Description of the Safety Risk : The power to ground short causes excessive heating and the potential for
combustion. All components are appropriately spec’d to UL 94v0
flammability rating so the chance for combustion prior to the short opening
up is extremely small.
Description of the Cause : Dendritic growth occurred between the power and ground planes causing
thermal destruction of the module.
Identification of Any Warning
that can Occur :
NR
Involved Components :
Component Name : PRPC
Component Description : Programable Relay Power Center
Component Part Number : S-M1521-xx
Supplier Identification :
Component Manufacturer
Name : Intermotive
Address : 12840 Earhart Ave
Auburn California 956002
Country : United States
Chronology :
Forest River notified Intermotive of the first failures on 10/27/2021, 11/23/2021, 11/30/221 and 127/2021.
Description of Remedy :
Description of Remedy Program : Intermotive will provide all parts and labor free of charge to customers
who identify assemblies with date code 0919. Customers can contact
Intermotive Warranty at 530-823-1048 xt 103. Warranty will immediately
send out a replacement harness for the repair and offer the necessary
technical support during installation
Part 573 Safety Recall Report 22E-008 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
How Remedy Component Differs
from Recalled Component :
The remedy is adding a fused data link harness that will prevent the
thermal event from occurring.
Identify How/When Recall Condition
was Corrected in Production :
All remaining assemblies with date code 0919 have been removed from
the supply chain. Additional high magnification inspection requirements
are now in place for pcb’s to identify any exposed copper from the PCB
vendors
Recall Schedule :
Description of Recall Schedule : Intermotive has the utmost urgency to resolve this recall quickly and
efficiently. Intermotive will send a suspected serial number list to our
customers once a formal NHTSA id is provided.
Planned Dealer Notification Date : MAR 07, 2022 – MAR 07, 2022
Planned Owner Notification Date : MAR 07, 2022 – MAR 07, 2022
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : A&J Mobility
Address : 1330 Midvalley
Valders WI 54245
Country : US
Company Phone : NR
Name : American Transportation
Address : 3133 E South St Long Beach
Long Beach CA 90805
Country : US
Company Phone : NR
Name : Advanced Automotive
Address : 7528 Burnet Rd
Austin TX 78757
Country : US
Company Phone : NR
Name : Atlantic Bus Sales
Address : 1200 S. Dixie HWY
Pompano Beach CA 22060
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 4
The information contained in this report was submitted pursuant to 49 CFR §573
Name : A-Z Bus – Colton
Address : 1900 South Riverside Ave
Colton CA 92324
Country : US
Company Phone : NR
Name : A-Z Bus – Sacramento
Address : 3418 52nd Ave
Sacramento CA 95823
Country : US
Company Phone : NR
Name : Badger Bus
Address : 5501 Femrite Drive
Madison WI 53718
Country : US
Company Phone : NR
Name : Baehrs Automotive
Address : 1224 Montlimar dr.
Mobile AL 36609
Country : US
Company Phone : 251-34-9157
Name : Brickell Complete Auto
Address : 795 SW 6th St
Miami FL 33130
Country : US
Company Phone : NR
Name : Bus Service
Address : 3153 Lamb Ave
Columbus OH 43219
Country : US
Company Phone : NR
Name : Buses at Loganville
Address : 5314 Holley Brooke Lane
Loganville GA 30052
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 5
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Butler Automotive Service Center
Address : 14720 Southlawn Ln
Rockville MD 20850
Country : US
Company Phone : NR
Name : Camco Wheel & Axle
Address : 1105 W, Furguson St
Pharr TX 78577
Country : US
Company Phone : 956-781-4800
Name : Carpenter Bus Sales, Inc.
Address : 132 Royal Oaks
Franklin TN 37067
Country : US
Company Phone : NR
Name : Challenger Transportation
Address : 8210 Beechcraft Ave
Gaithersburg MD 20879
Country : US
Company Phone : 301 990-6000
Name : Checkered Flag Auto Bus Inc
Address : 236 Seaman Ct
Westbury NY 11590
Country : US
Company Phone : NR
Name : Chris Mobility
Address : 18386 Ostego Dr
Fort Myers FL 33967
Country : US
Company Phone : NR
Name : City of Lompoc
Address : 1300 West Laurel Ave
Lompoc CA 93436
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 6
The information contained in this report was submitted pursuant to 49 CFR §573
Name : City of Sioux City
Address : 1821 18th street
Sioux City IA 51105
Country : US
Company Phone : NR
Name : Coach and Equipment Mfg.
Address : 130 Horizon Park
Pen Yan NY 14527
Country : US
Company Phone : NR
Name : Colonial Bus
Address : 5171 Intercoastal Court
Monrovia MD 21770
Country : US
Company Phone : NR
Name : Continental RV
Address : 39 Allen Blvd Ste C
Farmingdale NY 11735
Country : US
Company Phone : NR
Name : Creative Bus Sales
Address : 14740 Ramona Ave
Chino CA 91710
Country : US
Company Phone : NR
Name : Creative Bus Sales (Carlstadt)
Address : 51 Kero Rd
Carlstadt NJ 07072
Country : US
Company Phone : (800) 272-6521
Name : Creative Bus Sales (Jacksonvil
Address : 8600 Atlantic Blvd
Jacksonville FL 32211
Country : US
Company Phone : 909-993-5040
Part 573 Safety Recall Report 22E-008 Page 7
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Creative Mobility Wayne, MI
Address : 33073 Michigan Ave
Wayne MI 48184
Country : US
Company Phone : NR
Name : Delacy Ford
Address : 3061 Transit Rd
Elma NY 14059
Country : US
Company Phone : NR
Name : Driverge Vehicle Innovations
Address : 1090 West Wilbeth Road
Akron OH 44314
Country : US
Company Phone : NR
Name : Driverge Vehicle Innovations
Address : 1090 West Wilbeth Road
Akron OH 44314
Country : US
Company Phone : NR
Name : Driverge Vehicle Innovations
Address : 1090 West Wilbeth Road
Akron OH 44314
Country : US
Company Phone : NR
Name : Empire Transportation, INC.
Address : 340 Mountain Ave
Perris CA 92570
Country : US
Company Phone : NR
Name : Fast Serv Medical
Address : 1329 Driftwood Dr
Bossier LA 71111
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 8
The information contained in this report was submitted pursuant to 49 CFR §573
Name : G&M Service Center, Inc
Address : 7901-5 Hill Park Court
Lorton VA
Country : US
Company Phone : NR
Name : Hoglund Bus
Address : 116 E Oakwood Drive
Monticello MN 55362
Country : US
Company Phone : NR
Name : Lafayette Limo
Address : 2525 Komdike Road
West Lafayette IN 47906
Country : US
Company Phone : NR
Name : Leader Emergency Vehicles
Address : 10941 Weaver Ave South
El Monte CA 91733
Country : US
Company Phone : NR
Name : Lewis Bus Group
Address : 1009 Recreation Way North
Salt Lake City UT 84054
Country : US
Company Phone : NR
Name : Mobility Medical
Address : 748 N, Harbor City Blvd
Melbourne FL 32935
Country : US
Company Phone : NR
Name : Maricopa Ambulance
Address : 10243 N. 19th Ave
Phoenix AZ 85021
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 9
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Masters Transportation
Address : 800 Quik Trip Way
Belton MO 64012
Country : US
Company Phone : NR
Name : Medford Truck And Auto
Address : 11 Hall St
Medford MA 02155
Country : US
Company Phone : NR
Name : Mid Atlantic Mobility
Address : 19708 Old York Rd
White Hall MD 21161
Country : US
Company Phone : NR
Name : Mid-South Bus Center
Address : 3512 Bill Smith Dr
Murfreesboror TN 37129
Country : US
Company Phone : NR
Name : Mike Fraser Auto Repair
Address : 1204 7th st
Cordele GA 31015
Country : US
Company Phone : (229) 273-0652
Name : Mobility Systems
Address : 2857 Oak Grove Rd
Hattiesburg MS 39402
Country : US
Company Phone : NR
Name : Mobility Works
Address : 810 Moe Dr
Akron OH 44310
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 10
The information contained in this report was submitted pursuant to 49 CFR §573
Name : NAPA Store #245
Address : 11857 Metro Parkway
Fort Myers FL 33966
Country : US
Company Phone : NR
Name : New England Wheels
Address : 33 Manning Rd
Brillrica MA 01821
Country : US
Company Phone : NR
Name : Northwest Bus Sales
Address : 33207 Pacific Hwy South
Federal Way WA 98003
Country : US
Company Phone : NR
Name : On Site Fleet Service
Address : 36 Edgeboro Rd
East Brunswick NJ 08816
Country : US
Company Phone : NR
Name : Optimal EV
Address : 29449 Old US Hwy 33 , IN 46516
Elkhart IN 46516
Country : US
Company Phone : NR
Name : Overland Custom Coach (2007) Inc.
Address : 21051 Nissouri Road Thorndale
Ontario 00 n0m2p0
Country : CA
Company Phone : NR
Name : Penske Truck Leasing Vernon
Address : 2727 S. Santa Fe Ave
Vernon CA 90058
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 11
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Quality Van Sales, Inc.
Address : 49 Old Colony Road
Norton MA 02766
Country : US
Company Phone : NR
Name : Regency Taxi
Address : 8201 Shouffer School Road
Gathersburg MD 20879
Country : US
Company Phone : NR
Name : Rohrer Bus Sales
Address : PO BOX 100
Routes 11&15 Duncannon PA 17020
Country : US
Company Phone : NR
Name : Ruben Fleet
Address : 4730 Leopard St
Corpus Christi TX 78408
Country : US
Company Phone : NR
Name : Siddons-Martin Emergency Group
Address : 3500 Shelby ln
Denton TX 76207
Country : US
Company Phone : NR
Name : Sioux City Transit
Address : 509 Nebraska st
Sioux City IA 51101
Country : US
Company Phone : 7122796405
Name : Sonny Merryman, Inc.
Address : PO Box 495
Rustburg 24588
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 12
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Southern Bus & Mobility
Address : PO Box 37 Breese
Breese IL 62230
Country : US
Company Phone : NR
Name : Sunset Empire Transportation District
Address : 465 NE Skipanon Dr
Warrenton OR 97146
Country : US
Company Phone : NR
Name : TESCO
Address : PO Box 167230
Oregon OH 43616
Country : US
Company Phone : NR
Name : The Bus Center Acworth
Address : 110 HOLT INDUSTRIAL CIRCLE
ACWORTH GA 30101
Country : US
Company Phone : NR
Name : The Bus Center of Atlanta LLC
Address : 1400 McCain Parkway
Pelham PA 35124
Country : US
Company Phone : NR
Name : Three Guys Garage
Address : 4904 Augusta Rd
Garden City GA
Country : US
Company Phone : 9129649222
Name : Verizon Fleet
Address : PO Box 152134
Irving TX 75015
Country : US
Company Phone : NR
Part 573 Safety Recall Report 22E-008 Page 13
The information contained in this report was submitted pursuant to 49 CFR §573
Name : Walker Auto and Truck TAX
Address : 600 NC Hwy 86 North
Hillsborough NC 27278
Country : US
Company Phone : NR
Name : Wolfington Body Company, Inc,
Address : PO Box 218
Exton PA 19341
Country : US
Company Phone : NR
Name : Forest River
Address : 900 County Rd 1
Elkhart IN 46514
Country : US
Company Phone : 5748258530
* NR – Not Reported

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-008
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Intermotive
Submission Date : FEB 14, 2022
NHTSA Recall No. : 22E-008
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Intermotive
Address : 12840 Earhart Ave
Auburn CA 95602
Company phone : 8231048
Population :
Number of potentially involved : 453
Estimated percentage with defect : NR
Equipment Information :
Brand / Trade 1 : Intermotive
Model : PRPC
Part No. : S-M1521-xx
Size : NR
Function : Power Managemen
Descriptive Information : The time frame of the four failures reported by Forest River were modules that
were installed from 6/14/2021 – 8/30/2021. After analysis by Intermotive
Engineering, it was determined that if two specific conditions occur ( mask misregistration
and contamination are present) dendritic growth could occur and
short the power and ground plains. Both Forest River and Intermotive removed
all assemblies with the suspect date code (0919) by 12/31/2021. The four
defects were found prior to any busses being put in service and are considered
infant mortality. Forest River Identified 1762 buses built in the time frame from
06/01/2021-01/18/2022 . While zero defects have occurred from PRPC’s
shipped to other customers, it was decided that we recall the PRPC’s shipped in
this time frame and provide the solution to prevent the defect from occurring.
Intermotive has identified 453 units shipped within this time frame and could
potentially have the suspect PCB date code
Production Dates : JUN 01, 2021 – JAN 18, 2022
Description of Defect :
Description of the Defect : Intermotive has determined that a small percentage of date code 0919 pcbs
used for the PRPC had mask mis-registration causing exposed copper. Lab
analysis showed the evidence of dendritic growth which caused the short
between the power and ground planes. The failure happened after installation
and prior to the busses being put into service. All four were infant mortality.
FMVSS 1 : NR
Part 573 Safety Recall Report 22E-008 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
FMVSS 2 : NR
Description of the Safety Risk : The power to ground short causes excessive heating and the potential for
combustion. All components are appropriately spec’d to UL 94v0
flammability rating so the chance for combustion prior to the short opening
up is extremely small.
Description of the Cause : Dendritic growth occurred between the power and ground planes causing
thermal destruction of the module.
Identification of Any Warning
that can Occur :
NR
Involved Components :
Component Name : PRPC
Component Description : Programable Relay Power Center
Component Part Number : S-M1521-xx
Supplier Identification :
Component Manufacturer
Name : Intermotive
Address : 12840 Earhart Ave
Auburn California 95602
Country : United States
Chronology :
Forest River notified Intermotive of the first failures on 10/27/2021, 11/23/2021, 11/30/221 and 127/2021.
Description of Remedy :
Description of Remedy Program : Intermotive will provide all parts and labor free of charge to customers
who identify assemblies with date code 0919. Customers can contact
Intermotive Warranty at 530-823-1048 xt 103. Warranty will immediately
send out a replacement harness for the repair and offer the necessary
technical support during installation
Part 573 Safety Recall Report 22E-008 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
How Remedy Component Differs
from Recalled Component :
The remedy is adding a fused data link harness that will prevent the
thermal event from occurring.
Identify How/When Recall Condition
was Corrected in Production :
All remaining assemblies with date code 0919 have been removed from
the supply chain. Additional high magnification inspection requirements
are now in place for pcb’s to identify any exposed copper from the PCB
vendors
Recall Schedule :
Description of Recall Schedule : Intermotive has the utmost urgency to resolve this recall quickly and
efficiently. Intermotive will send a suspected serial number list to our
customers once a formal NHTSA id is provided.
Planned Dealer Notification Date : MAR 07, 2022 – MAR 07, 2022
Planned Owner Notification Date : MAR 07, 2022 – MAR 07, 2022
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : NR
Address : NR
NR
Country : NR
Company Phone : NR
* NR – Not Reported

**************************************************************************************************************

OMB Control No.: 2127-0004
Part 573 Safety Recall Report 22E-008
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Intermotive
Submission Date : FEB 14, 2022
NHTSA Recall No. : 22E-008
Manufacturer Recall No. : NR
Manufacturer Information :
Manufacturer Name : Intermotive
Address : 12840 Earhart Ave
Auburn CA 95602
Company phone : 8231048
Population :
Number of potentially involved : 502
Estimated percentage with defect : NR
Equipment Information :
Brand / Trade 1 : Intermotive
Model : PRPC
Part No. : S-M1521-xx
Size : NR
Function : Power Managemen
Descriptive Information : The time frame of the four failures reported by Forest River were modules that
were installed from 6/14/2021 – 8/30/2021. After analysis by Intermotive
Engineering, it was determined that if two specific conditions occur ( mask misregistration
and contamination are present) dendritic growth could occur and
short the power and ground plains. Both Forest River and Intermotive removed
all assemblies with the suspect date code (0919) by 12/31/2021. The four
defects were found prior to any busses being put in service and are considered
infant mortality. Forest River Identified 1762 buses built in the time frame from
06/01/2021-01/18/2022 . While zero defects have occurred from PRPC’s
shipped to other customers, it was decided that we recall the PRPC’s shipped in
this time frame and provide the solution to prevent the defect from occurring.
Intermotive has identified 453 units shipped within this time frame and could
potentially have the suspect PCB date code
Production Dates : JUN 01, 2021 – JAN 18, 2022
Description of Defect :
Description of the Defect : Intermotive has determined that a small percentage of date code 0919 pcbs
used for the PRPC had mask mis-registration causing exposed copper. Lab
analysis showed the evidence of dendritic growth which caused the short
between the power and ground planes. The failure happened after installation
and prior to the busses being put into service. All four were infant mortality.
FMVSS 1 : NR
Part 573 Safety Recall Report 22E-008 Page 2
The information contained in this report was submitted pursuant to 49 CFR §573
FMVSS 2 : NR
Description of the Safety Risk : The power to ground short causes excessive heating and the potential for
combustion. All components are appropriately spec’d to UL 94v0
flammability rating so the chance for combustion prior to the short opening
up is extremely small.
Description of the Cause : Dendritic growth occurred between the power and ground planes causing
thermal destruction of the module.
Identification of Any Warning
that can Occur :
NR
Involved Components :
Component Name : PRPC
Component Description : Programable Relay Power Center
Component Part Number : S-M1521-xx
Supplier Identification :
Component Manufacturer
Name : Intermotive
Address : 12840 Earhart Ave
Auburn California 95602
Country : United States
Chronology :
Forest River notified Intermotive of the first failures on 10/27/2021, 11/23/2021, 11/30/221 and 127/2021.
Description of Remedy :
Description of Remedy Program : Intermotive will provide all parts and labor free of charge to customers
who identify assemblies with date code 0919. Customers can contact
Intermotive Warranty at 530-823-1048 xt 103. Warranty will immediately
send out a replacement harness for the repair and offer the necessary
technical support during installation
Part 573 Safety Recall Report 22E-008 Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
How Remedy Component Differs
from Recalled Component :
The remedy is adding a fused data link harness that will prevent the
thermal event from occurring.
Identify How/When Recall Condition
was Corrected in Production :
All remaining assemblies with date code 0919 have been removed from
the supply chain. Additional high magnification inspection requirements
are now in place for pcb’s to identify any exposed copper from the PCB
vendors
Recall Schedule :
Description of Recall Schedule : Intermotive has the utmost urgency to resolve this recall quickly and
efficiently. Intermotive will send a suspected serial number list to our
customers once a formal NHTSA id is provided.
Planned Dealer Notification Date : MAR 07, 2022 – MAR 07, 2022
Planned Owner Notification Date : MAR 07, 2022 – MAR 07, 2022
Purchaser Information :
The following manufacturers purchased this defective/noncompliant equipment for possible use or
installation in new motor vehicles or new items of motor vehicle equipment:
Name : NR
Address : NR
NR
Country : NR
Company Phone : NR
* NR – Not Reported

SEOCONTENT-END