“This site contains affiliate links for which OEMDTC may be compensated” |
January 15, 2020 NHTSA CAMPAIGN NUMBER: 20V019000
Heat Coil May Not Disengage with A/C
If the heat coil does not disengage with the air conditioner, heat can increase inside the unit, increasing the risk of a fire.
NHTSA Campaign Number: 20V019
Manufacturer Winnebago Industries, Inc
Components ELECTRICAL SYSTEM
Potential Number of Units Affected 212
Summary
Winnebago Industries, Inc (Winnebago) is recalling certain 2020 Adventurer motorhomes. When using 30 AMP service, the heat coil may not disengage when the Power Control System (PCS) calls to stop the air conditioner power.
Remedy
Winnebago will notify owners, and dealers will install a blocking diode at the air conditioner unit, free of charge. The recall began February 6, 2020. Owners may contact Winnebago customer service at 1-641-585-6939 or 1-800-537-1885. Winnebago’s number for this recall is 161.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
INSTRUCTIONS TO PERFORM RECALL CAMPAIGN 161
Models Affected
2020 Winnebago Adventurer
Tools and Parts Required
Screw Gun
#2 Philips bit
Recall Repair Kit # RC7646-20-761
NOTE: Only use the parts supplied in the recall kit to complete this repair.
Before proceeding
Verify all power sources have been disabled.
- Shore power
- Coach Battery
- Chassis Battery
Component Removal
Locate the air conditioner inside the coach.
Remove the return air grill. Retain for later use.
Remove the return air filter. Retain for later use.
Locate and remove six (6) screws holding the shroud to the air conditioner unit. Retain for later use.
Behind the shroud, locate the terminal block.
Locate the Y terminal and disconnect.
The circuit should be:
Front Air conditioner: XP
Rear Air conditioner: DD
Connect the disconnected circuit to the male end of the jumper.
Connect the female end of the jumper to the Y terminal.
Component Reinstall
Place the wires back into the opening.
**Ensure the wires are not touching the Reinstall the return air filter. heat coil, or any sharp edges.**
Reinstall the air conditioner shroud using the six (6) screws retained earlier.
Reinstall the return air grill.
Test
After all components have been reinstalled, test functions of the air conditioner, heater coil, and Power Control System (PCS).
The coach will have one of the following two control panels.
– Familiarize yourself with the controls and menus for the test outlined below.
Connect the coach to 30 AMP service.
Turn on both air conditioners and engage the heater coils by setting the thermostat to heat and increasing the temperature above ambient. Begin with the front unit, then proceed to the rear unit.
Set the PCS to 20 AMP.
The PCS should shed the rear A/C within a few seconds. Verify the PCS amperage has dropped and the heater coils have properly shed with the air conditioner.
With the front air conditioner unit still running, continue the test by placing a cup of water in the microwave and operate the microwave on high set for 15 seconds.
Once the microwave has started, the PCS should shed the front air conditioner unit.
Verify the PCS amperage has dropped and the heater coils have properly shed with the air conditioners.
If the heating coil is not shed by the PCS
Turn off the A/C and review installation of blocking diode.
If you have any questions regarding this recall remedy, please contact:
Technical Assistance
1-866-653-4329
1 Affected Product
Vehicle
MAKE | MODEL | YEAR |
WINNEBAGO | ADVENTURER | 2020 |
8 Associated Documents
Recall Quarterly Report #1, 2020-1
RCLQRT-20V019-6147.PDF 211.135KB
Manufacturer Notices(to Dealers,etc)
RCMN-20V019-5229.pdf 1328.856KB
Recall Acknowledgement
RCAK-20V019-1082.pdf 245.289KB
Defect Notice 573 Report
RCLRPT-20V019-9628.PDF 212.796KB
Recall Quarterly Report #2, 2020-2
RCLQRT-20V019-5166.PDF 211.235KB
Remedy Instructions and TSB
RCRIT-20V019-2344.pdf 1328.856KB
Recall Quarterly Report #3, 2020-3
RCLQRT-20V019-1560.PDF 211.318KB
Recall Quarterly Report #4, 2020-4
RCLQRT-20V019-1101.PDF 211.43KB
Latest Recalls Documents
For the Latest and Most Recent Recalls Information Visit the link below…
https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=20V019&docType=RCL
“This site contains affiliate links for which OEMDTC may be compensated” |
- ALLECIN Diodes Assortment Kit Contain Rectifier Fast Recovery Schottky Switching Diode - Reliable quality & Stable performance.
- 1N4001 / IN4001 (1A 50V) ; 1N4002 / IN4002 (1A 100V) ; 1N4003 / IN4003 (1A 200V) ; 1N4004 / IN4004 (1A 400V) ; 1N4005 / IN4005 (1A 600V) ; 1N4006 / IN4006 (1A 800V) ; 1N4007 / IN4007 (1A 1000V) ; 1N4148 / IN4148 (200mA 100V) ;
- 1N5404 / IN5404 (3A 400V) ; 1N5406 / IN5406 (3A 600V) ; 1N5408 / IN5408 (3A 1000V) ; 1N5817 / IN5817 (1A 20V) ; 1N5819 / IN5819 (1A 40V) ; 1N5822 / IN5822 (3A 40V) ; RL207 (2A 1000V) ; UF4007 (1A 1000V) ; FR107 (1A 1000V) ; FR207 (2A 1000V) ; 15SQ045 (15A 45V) ; 10A10 (10A 1000V).
- Features & Advantages : Stable performance, circuit protection, strong corrosion resistance, good high temperature resistance.
- Humanized packaging for easy storage and use. # Please confirm the model, amp and volt before purchasing.
- 20 Pcs 15SQ045 / Forward Current : 15 A / Maxixum Repetitive Peak Reverse Voltage : 45 V
- Meterial:Si;High surge current capability.
- Low leakage and forward voltage drop;Low power loss, high efficiency.
- Maximum Average Forward Current: 15 A MP.Forward Current (at DC10A): 0.55V.
- All products are tested for stability, consistency and reliability. Ensure product excellence.
- BOJACK 10 values 300 pcs Rectifier Diode Assorted kit with different current and voltage.
- Rectifier Diodes : IN4001 (1A 50V),IN4002 (1A 100V),IN4003 (1A 200V),IN4004 (1A 400V),IN4005 (1A 600V),IN4006 (1A 800V),IN4007 (1A 1000V).Schottky Diodes : IN5817 (1A 20V), IN5817 (1A 30V),IN5819 (1A 40V) .
- The diode assorted product is easy to store ,Use an anti-static bag with a clear mark for packaging,not easy to damage.
- Lead-Free / RoHS Compliant Electronics Component.
- This product is widely used in product development, student experiments, maintenance, production, etc.
- 100 Pcs 1N4001
- Forward Current : 1 A / Maximum Repetitive Peak Reverse Voltage : 50 V
- Low Reverse Leakage / High Forward Surge Current Capability / High Temperature Soldering
- Product Type: RECTIFIER DIODE
- Product Type:Zener Diode
- P/N: 1N5349B
- V(z): 12V
- Power: 5W
- Package Quantity: 30PCS
- Designed, engineered, tested, and warranted for GM vehicles.Fit Type: Vehicle Specific
- Precise fit for ease of installation
- For proper installation, locate your nearest GM dealer, independent service center, or body shop
- Forward Current : 10 A / Maxixum Repetitive Peak Reverse Voltage : 1000 V
- Lead-Free / RoHS Compliant Electronics Component / Molded Plastic Case / Plated Axial Leads / Through Hole
- Low Reverse Leakage / High Forward Surge Current Capability / High Temperature Soldering
- Pack in a ESD Bag with Main Specs Label, for Long Time Protection and Indetification.
- Isolates Towed Vehicle from Motorhome
- Splices Into Existing Harness
- Powers Taillights and Turn Signals on Towed Vehicle
- Black overall color
- 2 input spades and one output spade
- This model is anti-reverse diode MD 110A-16; to prevent backfeed ;Also called blocking diode ;Peak voltage 1600V;AC < 400VAC ;DC 3-1000VDC
- Because it is commonly used in solar energy and photovoltaic power generation, and is often paired with solar cells and solar panels, some customers might refer to it as a "solar diode."
- Using four diodes together can act as a rectifier bridge;Also known as a high current diode, if you need a higher current, please contact us
- Resistive load MAX=50A;The load bearing capacity depends on the use environment, the higher the temperature, the worse the effect;
- Sold by: Leichi; the brand is LCLCTC. If you purchase an item from a different brand, please report the discrepancy between the product and the images to Amazon.
- Package Dimensions: 10 L x 1 H x 6 W (inches)
- Package Weight: 0.15 pounds
- Country of Origin : United States
- Part Number: 792
Last update on 2024-04-24 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.