“This site contains affiliate links for which OEMDTC may be compensated” |
March 6, 2024 NHTSA CAMPAIGN NUMBER: 24V178000
A loss of steering control increases the risk of a crash.
NHTSA Campaign Number: 24V178000
Manufacturer Prevost Car (US) Inc.
Components STEERING
Potential Number of Units Affected 23
Summary
Prevost Car (US) Inc. (Prevost) is recalling certain 2023 H3-45 and 2022-2023 H3-45 VIP vehicles. The steering column joints may fail, causing a loss of steering control.
Remedy
Owners are advised not to drive their vehicle until the repair has been performed. Prevost will replace the steering column joints, free of charge. Owner notification letters are expected to be mailed April 19, 2024. Owners may contact Provost customer service at 1-866-870-2046. Prevost’s number for this recall is SR24-11.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Prevost Technical Publications
Chronology :
2023-10-26: Prevost realized that vehicles equipped with non-qualified joints were potentially delivered to end users. Prevost initiated an investigation to determine the possible differences between non-qualified and qualified joints.
2024-02-14 Prevost communicated with the joint supplier to clarify the conditions for using non-qualified joints. The supplier indicated that these components are not intended for installation on vehicles sold to end users.
2024-02-20 Case was presented on Volvo Product Safety Evaluation Committee (PSEC) to evaluate if there is a potential safety-related issue. Decision made to raise the potential safety issue to Volvo Product Safety Committee (PSC) for review and determination.
2024-02-29 Case was presented to Volvo Product Safety Committee (PSC). It was concluded that there was a safety-related defect, and that a recall combined with a “Do Not Drive Warning” are needed.
2024-03-06 Defect Information Report submitted to authorities.
No warranty claims related to this issue. No field reports, incidents, accidents, injuries or fatalities related to this issue were reported.
3 Affected Products
Vehicles
MAKE | MODEL | YEAR |
PREVOST | H3-45 | 2023 |
PREVOST | H3-45 VIP | 2022-2023 |
2 Associated Documents
Defect Notice 573 Report
RCLRPT-24V178-9419.PDF 214.744KB
Recall Acknowledgement
Latest Recalls Documents
For the Latest and Most recent Recall Information Visit the link below…
https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=24V178&docType=RCL
- Intermediate Steering Shaft : Keeps the steering gearbox and steering wheel connected. The universal joint or also called as u-joint at the end of the steering shaft connects to the steering gearbox which has another u-joint that connects to the steering wheel allows for the angles between them to be supported resulting to your vehicle wheels smooth and easy turning.
- Direct Replacement - Easy Installation:While this is not a genuine OEM part, it is a direct replacement and will fit, work and function like the original part. This replacement intermediate steering shaft is manufactured from high quality steel to ensure longevity providing excellent value.
- Universal Joint :Direct replace your worn or damaged steering shaft, with new U-Joints featuring precision needle bearings for smooth, silent operation and reliable performance.
- Smooth Steering: TUCAREST steering shaft shows good strength, toughness and is not easy to wear and break. The size, fit and function of this steering shaft is the same as the original. After replacing the old, worn-out and noisy steering shaft with our brand new one, there's no more need to put up with annoying issues like hard steering, worn out bearings, a loose and wobbly steering wheel or a steering wheel not returning to center.
- PLEASE NOTE: Before placing the order, please check your car model in the Amazon Fitment Filter System in the top left corner,Do not count on year make and model only,please view compatability tab including the notes,or send us a message to make sure it matches exactly.
- 【OEM FIT】This lower steering shaft is manufactured to the OE specification to provide factory-fresh appearance and direct-fit. No more miserable experience with binding Feel, clunking sound or turning difficulty
- 【PREMIUM QUALITY】Long life-span matters, that is why our intermediate shaft is crafted from surface-treated reinforce steel for increased corrosion resistance, to outlast any other aftermarket lower shaft available
- 【FITS】Replacement for 2004 2005 2006 2007 2008 F150, 06 07 08 Lincoln Mark LT. This steering intermediate shaft assembly has undergone a rigorous testing to guarantee long-term dependability and increased rigidity
- 【REPLACE OE NUMBER】8L3Z-3B676-B, 8L3Z3B676B, 425-361. U-joints use precision engineered needle bearings, means you will get a fairly reliable steering shaft to effectively restores the smooth rotation of your steering wheel
- 【12-MONTH WARRANTY】If the intermediate steering column shaft fails, cracks, stops working or any other problems, you can rely on our service of carefree REPLACEMENT or REFUND
- Steering shaft function is to connect the steering wheel with the car's steering gear, makes it easy to turn your car wheels.
- Precise fit : AUQDD steering shaft is engineered within strict tolerances to directly replace the original shaft on certain vehicle years, Makes and models.
- Trustworthy performance : built to meet thorough torsional, tensile, fatigue and other durability testing for reliable operation.
- Cost-effective : We are a factory direct sales.Customers can spend a small amount of money and get high quality Brand new Intermediate Steering Shaft.
- PLEASE NOTE : Before placing the order, please check your car model in the Amazon Fitment Filter System in the top left corner,Do not count on year make and model only,view compatability tab including the notes.
- APPLICATION - The power steering intermediate shafts fits for Jeep Cherokee 1984-1994/Comanche 1986-1992/Wagoneer 1984-1990, replaces part number 4713943, 425-284, 237.AM8686, 237.AM8288, JCXJ84, 18016.05
- RELIABILITYT - This steering shaft is designed to connect the steering wheel and the car's steering gear, improves steering precision. Before leaving the factory, it undergoes rigorous testing to perfectly match your vehicle
- PREMIUM LOWER STEERING SHAFT - Made of high quality metal, which can effectively prevent corrosion and rust, equipped with heavy duty universal U-joints, which use precision engineered needle bearings for smooth operation, durable wear and high strength
- DIMENSION - The length is 589 mm/23.19 inch(not adjustable). If your shaft occurs strange sounds, loose/tilt of steering wheel , difficulty in turning or your steering wheel does not go back to the center after turning, only replace it to get rid of unsafe and uncomfortable driving experiences
- 12 MONTHS WARRANTY - maXpeedingrods is committed to offer you replacement quality parts at great value. If the item has any problem, please contact us, we will provide comprehensive quality assurance for our product
- [Vehicle Fitment]: Compatible with Jeep Cherokee 1984-1994; Comanche 1986-1992; Wagoneer 1984-1990 --- with Power Steering
- [Reference Part Number]: 425-284, 425284, 4713943
- [Specification]: ①Position: Lower; ②Part Type: Steering Shaft; ③Material: Steel; ④Surface Finish: Black and Anti-Corrosion; ⑤Length(in.): 23.2; ⑥Diameter(in.): 0.8; ⑦Spline Quantity: 0; ⑧Universal Joint Quantity: 2
- [Smooth Steering]: A-premium steering shaft is made of sturdy steel, which shows good strength, toughness and is not easy to wear and break. The size, fit and function of this steering shaft is the same as the original. After replacing the old, worn-out and noisy steering shaft with our brand new one, there's no more need to put up with annoying issues like hard steering, worn out bearings, a loose and wobbly steering wheel or a steering wheel not returning to center.
- [Buy with Confidence]: A-Premium offers a one-year unlimited-mileage guarantee on our meticulously crafted steering shaft. We offer a wide variety of automotive accessory categories, ensuring that you can hit the road with peace of mind.
- Intermediate Steering Shaft : Keeps the steering gearbox and steering wheel connected. The universal joint or also called as u-joint at the end of the steering shaft connects to the steering gearbox which has another u-joint that connects to the steering wheel allows for the angles between them to be supported resulting to your vehicle wheels smooth and easy turning.
- Direct Replacement - Easy Installation:While this is not a genuine OEM part, it is a direct replacement and will fit, work and function like the original part. This replacement intermediate steering shaft is manufactured from high quality steel to ensure longevity providing excellent value.
- Universal Joint :Direct replace your worn or damaged steering shaft, with new U-Joints featuring precision needle bearings for smooth, silent operation and reliable performance.
- Smooth Steering: TUCAREST steering shaft shows good strength, toughness and is not easy to wear and break. The size, fit and function of this steering shaft is the same as the original. After replacing the old, worn-out and noisy steering shaft with our brand new one, there's no more need to put up with annoying issues like hard steering, worn out bearings, a loose and wobbly steering wheel or a steering wheel not returning to center.
- PLEASE NOTE: Before placing the order, please check your car model in the Amazon Fitment Filter System in the top left corner,Do not count on year make and model only,please view compatability tab including the notes,or send us a message to make sure it matches exactly.
- Package:Lower Intermediate Steering Shaft*1 Steering Shaft Slip Joint*1 Bolt*2
- Fit For 2005-2015 Toyota Tacoma 4WD
- Fit For 2005-2015 PreRunner 2WD or 4WD
- Made of High-Quality Materials, Easy to Install
- Replace part No.: 4520304021, 45203-04021
- [Vehicle Fitment]: Compatible with Ford F-150 2004-2008; Fit For Lincoln Mark LT 2006-2008
- [Reference Part Number]: 425-361, 425361, 4L3Z3B676DA, 5L3Z3B676AA, 7L3Z3B676A, 8L3Z3B676A, 8L3Z3B676B
- [Specification]: ①Position: Lower Intermediate; ②Part Type: Steering Shaft; ③Material: Steel; ④Surface Finish: Black and Anti-Corrosion; ⑤Length(in.): 15; ⑥Diameter(in.): 1; ⑦Spline Quantity: 0; ⑧Universal Joint Quantity: 2
- [Smooth Steering]: A-premium steering shaft is made of sturdy steel, which shows good strength, toughness and is not easy to wear and break. The size, fit and function of this steering shaft is the same as the original. After replacing the old, worn-out and noisy steering shaft with our brand new one, there's no more need to put up with annoying issues like hard steering, worn out bearings, a loose and wobbly steering wheel or a steering wheel not returning to center.
- [Buy with Confidence]: A-Premium offers a one-year unlimited-mileage guarantee on our meticulously crafted steering shaft. We offer a wide variety of automotive accessory categories, ensuring that you can hit the road with peace of mind.
- Intermediate Steering Shaft : Keeps the steering gearbox and steering wheel connected. The universal joint or also called as u-joint at the end of the steering shaft connects to the steering gearbox which has another u-joint that connects to the steering wheel allows for the angles between them to be supported resulting to your vehicle wheels smooth and easy turning.
- Direct Replacement - Easy Installation:While this is not a genuine OEM part, it is a direct replacement and will fit, work and function like the original part. This replacement intermediate steering shaft is manufactured from high quality steel to ensure longevity providing excellent value.
- Universal Joint :Direct replace your worn or damaged steering shaft, with new U-Joints featuring precision needle bearings for smooth, silent operation and reliable performance.
- Smooth Steering: TUCAREST steering shaft shows good strength, toughness and is not easy to wear and break. The size, fit and function of this steering shaft is the same as the original. After replacing the old, worn-out and noisy steering shaft with our brand new one, there's no more need to put up with annoying issues like hard steering, worn out bearings, a loose and wobbly steering wheel or a steering wheel not returning to center.
- PLEASE NOTE: Before placing the order, please check your car model in the Amazon Fitment Filter System in the top left corner,Do not count on year make and model only,please view compatability tab including the notes,or send us a message to make sure it matches exactly.
Last update on 2024-04-11 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.
SEOCONTENT-START
OMB Control No.: 2127-0004
Part 573 Safety Recall Report 24V-178
The information contained in this report was submitted pursuant to 49 CFR §573
Manufacturer Name : Submission Date :
Prevost Car (US) Inc. MAR 06, 2024 NHTSA Recall No. : 24V-178 Manufacturer Recall No. : SR24-11 Manufacturer Information :
Manufacturer Name : Prevost Car (US) Inc.
Address : 201 South Avenue
South Plainsfield NJ 07080 Company phone : 908-222-7211
Population :
Number of potentially involved : 23 Estimated percentage with defect : 100 %
Vehicle Information : Vehicle 1 : 2023-2023 Prevost H3-45
Vehicle Type : BUSES, MEDIUM & HEAVY VEHICLES Body Style : OTHER Power Train : DIESEL
Descriptive Information : The population was determined based on the production period and location as it is a production issue. The subject vehicles are certain MY2023 Prevost H3-45 vehicles manufactured during the indicated production dates. The recalled products are limited to these specific vehicles since they were the only ones equipped with a non- qualified steering column joint. A total of 2 MY2023 Prevost H3-45 vehicles are affected by the recall. Production Dates : AUG 19, 2022 – OCT 31, 2022
VIN Range 1 : Begin : NR End : NR Not sequential Vehicle 2 : 2022-2023 Prevost H3-45 VIP Vehicle Type : BUSES, MEDIUM & HEAVY VEHICLES Body Style : OTHER Power Train : DIESEL
Descriptive Information : The population was determined based on the production period and location as it is a production issue. The subject vehicles are certain MY2022 to MY2023 Prevost H3-45 VIP vehicles manufactured during the indicated production dates. The recalled products are limited to these specific vehicles since they were the only ones equipped with a non-qualified steering column joint.
A total of 4 MY2022 and 17 MY2023 Prevost H3-45 VIP vehicles are affected by the recall.
Production Dates : JUL 15, 2021 – NOV 16, 2022 VIN Range 1 : Begin : NR End : NR Not sequential Part 573 Safety Recall Report 24V-178 Page 2 Description of Defect :
Description of the Defect : Certain vehicles were delivered to end users with non-qualified steering column joints. These joints were not intended for installation on vehicles sold to end users and may potentially fail prematurely. In this eventuality, the driver could experience a loss of steering control.
FMVSS 1 : NR FMVSS 2 : NR
Description of the Safety Risk : A loss of steering control may increase the risk of a crash. In addition to the Safety Recall, Prevost issued a “Do Not Drive Warning” for this defect until the vehicles are remedied.
Description of the Cause : The issue results from a Prevost manufacturing error as the non-qualified steering column joints were not replaced before delivering the subject vehicles to end users. Identification of Any Warning
that can Occur : In some cases, the driver may notice an abnormal noise (clicking/rattling noise) and/or a free play increase when steering. Involved Components : Component Name 1 : Double Joint
Component Description : Steering Column Double Joint Component Part Number : 660045 Supplier Identification : Component Manufacturer
Name : NR Address : NR
NR
Country : NR Chronology :
2023-10-26: Prevost realized that vehicles equipped with non-qualified joints were potentially delivered to end users. Prevost initiated an investigation to determine the possible differences between non-qualified and qualified joints. The information contained in this report was submitted pursuant to 49 CFR §573 Part 573 Safety Recall Report 24V-178
Page 3
The information contained in this report was submitted pursuant to 49 CFR §573
2024-02-14 Prevost communicated with the joint supplier to clarify the conditions for using non-qualified joints. The supplier indicated that these components are not intended for installation on vehicles sold to end users. 2024-02-20 Case was presented on Volvo Product Safety Evaluation Committee (PSEC) to evaluate if there is a potential safety-related issue. Decision made to raise the potential safety issue to Volvo Product Safety Committee (PSC) for review and determination. 2024-02-29 Case was presented to Volvo Product Safety Committee (PSC). It was concluded that there was a safety-related defect, and that a recall combined with a “Do Not Drive Warning” are needed. 2024-03-06 Defect Information Report submitted to authorities. No warranty claims related to this issue. No field reports, incidents, accidents, injuries or fatalities related to this issue were reported.
Description of Remedy :
Description of Remedy Program : Prevost will replace the steering column joints on all subject vehicles.
Letters will be sent to customers to inform them on how to proceed. Prevost will execute this correction free of charge (parts and labor) for the customers. In case a customer has already inspected and corrected this defect before the safety recall has been launched, this customer will be reimbursed according to Prevost reimbursement plan. How Remedy Component Differs from Recalled Component :
Identify How/When Recall Condition was Corrected in Production : The recalled component is a non-qualified joint, while the remedy component is a fully qualified joint.
The recall condition did not need to be corrected in production as the recalled component is no longer installed in vehicles currently being manufactured. Recall Schedule :
Description of Recall Schedule : Please note that Prevost does not have a dealer network and the dates
entered for the planned dealer notification begin/end date are only to avoid NHTSA Recall Portal error while submitting the recall report.
Planned Dealer Notification Date : APR 19, 2024 – APR 19, 2024
Planned Owner Notification Date : APR 19, 2024 – APR 19, 2024
* NR – Not Reported
**************************************************************************************************************
**************************************************************************************************************
SEOCONTENT-END