“This site contains affiliate links for which OEMDTC may be compensated” |
October 14, 2022 NHTSA CAMPAIGN NUMBER: 22V773000
An inverted cooktop flame increases the risk of injury or fire.
NHTSA Campaign Number: 22V773
Manufacturer Jayco, Inc.
Components EQUIPMENT
Potential Number of Units Affected 2,748
Summary
Jayco, Inc. (Jayco) is recalling certain 2021-2022 Jayco Jay Feather, Jay Flight, and Jay Flight SLX travel trailers. The cooktop flame may invert when the stove and furnace are operated at the same time.
Remedy
Dealers will install sealant and plywood panels to seal the area, free of charge. Owner notification letters were mailed November 29, 2022. Owners may contact Jayco customer service at 1-800-283-8267. Jayco’s number for this recall is 9901582.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Jayco Inc. has decided that a defect which relates to motor vehicle safety exists in certain Jayco; 2021 Jay Flight, 2022 Jay Flight SLX, 2022 Jay Feather, Starcraft RV; 2021-2022 Autumn Ridge Outfitter, Highland Ridge RV; 2021-2022 Open Range, 2022 Range Lite, 2022 Olympia, and 2022 Olympia Sport travel trailers.
Reason for this recall
The flame on the cooktop will invert when the furnace is running. The cooktop is installed in a cabinet that is not sealed from the furnace area. When the furnace and the cooktop are operated at the same time the cooktop burner flame can invert leading to an increased risk of personal injury or fire.
Recall Remedy
Remedy consists of adding sealant and plywood panels to seal the area around the gas line hose and the area adjoining the cooktop. The remedy will be performed free of charge to you and will take approximately 45 minutes to complete.
What we need you to do
Please contact a Jayco certified repair facility and schedule an appointment for this remedy. CAUTION: Do not use the cooktop and the furnace at the same time until the remedy is completed.
Chronology :
In January 2022, Jayco received a claim of an inverted flame on the cooktop of a unit built in our Idaho location.
Jayco began monitoring our data for other similar allegations. Claims slowly continued to come in and each was discussed and evaluated in our weekly Warranty Incident Review Committee (WIRC) meetings.
In May 2022, an incident on a Starcraft unit was elevated from WIRC to the Corrective Preventive Action Committee (CPAC). The CPAC committee met on May 18, 2022 and discussed the incidents and decided to open an investigation.
On September 7, 2022, CPAC decided to elevate this matter to the Safety Steering Committee (SSC). Jayco towable engineering conducted testing to better understand the conditions that could lead to an inverted flame. This research was concluded at the start of October 2022.
On October 10, 2022 SSC met to discuss this matter and voted in favor of proceeding with a safety recall. Jayco received a total of eight claims between January 2022 and October 2022.
6 Affected Products
Vehicles
MAKE | MODEL | YEAR |
JAYCO | JAY FEATHER | 2021-2022 |
JAYCO | JAY FLIGHT | 2021-2022 |
JAYCO | JAY FLIGHT SLX | 2021-2022 |
10 Associated Documents
Recall Acknowledgement
RCAK-22V773-6170.pdf 645.973KB
Defect Notice 573 Report
RCLRPT-22V773-2398.PDF 215.338KB
Recall 573 Report – 11/11/2022
RCLRPT-22V773-2159.PDF 215.553KB
Recall 573 Report – 11/18/2022
RCLRPT-22V773-2804.PDF 215.553KB
Remedy Instructions and TSB
RCRIT-22V773-9152.pdf 1616.252KB
Manufacturer Notices(to Dealers,etc)
RCMN-22V773-0977.pdf 168.019KB
ISSUED Owner Notification Letter(Part 577)
RCONL-22V773-0165.pdf 60.898KB
Recall Quarterly Report #1, 2022-4
RCLQRT-22V773-3831.PDF 211.12KB
Recall Quarterly Report #2, 2023-1
RCLQRT-22V773-2753.PDF 211.217KB
Recall Quarterly Report #3, 2023-2
RCLQRT-22V773-5776.PDF 211.307KB
Latest Recalls Documents
For the Latest and Most Recent Recalls Information Visit the link below…
https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=22V773&docType=RCL
- 【PORTABLE INDUCTION BURNER】Duxtop induction cooktop uses 110/120V 15 amp electrical outlet–standard in all North American homes. ETL listed and built to North American electrical standards. It is lightweight and compact for easy handling and storage. Portable induction burner is perfect for kitchen, dorm, RV, boats, and etc.
- 【HIGH ENERGY EFFICIENCY】 Choose from 20 preset power levels (100W to 1800W) and 20 preset temperature level settings (100°F to 460°F). With an 83% energy efficiency, induction burner is more efficient than traditional gas or electric stoves. Duxtop portable cooktop is perfect for bringing water to a boil quickly and for all of your cooking needs.
- 【DIGITAL LCD SENSOR】Touch control panel: child safety lock keeps the cooking and timer settings from being accidentally changed once they have been set; fast boil button; keep warm button (for 1-30 minutes at 140°F); up to 10-hour timer button.
- 【COMPATIBLE WITH MAGNETIC COOKWARE】 In order to use this and any other induction stove, you need to use cookware with a magnetic bottom. The auto-pan detection will shut the unit off automatically after 60 seconds if no cookware, or the incorrect cookware is detected. Compatible with induction cookware having a diameter of at least 5 inches, which ensures a large and uniform heated area.
- 【WARRANTY】Although induction itself is a noiseless process, there may be high pitched sounds from the cookware due to multiple layers of metals sandwiched together. Please allow the induction cooker to cool down before cleaning. 2-year manufacturer’s warranty, as well as customer service.
- Duxtop Induction Cooktop uses 120V 15 amp electrical outlet - standard in all North American homes; lightweight and compact for easy handling and storage.
- Digital control panel. Built-in count-down digital timer with 1 minute increments up to 170 minutes; 10 temperature range from 140 °F to 460 °F; 10 power levels from 200 to 1800 Watts.
- With no open flame or heating element, food does not burn-on the glass cooktop so this induction burner is easy to clean—just wipe with a damp towel. Durable 7-blade fan rapidly dissipates heat to ensure a longer product life.
- The auto-pan detection will shut the unit automatically after 60 seconds if no cookware is detected; equipped with diagnostic error message system, low and high voltage warning system; ETL approved.
- Note: In order to use this and any other induction stove, you need to use cookware with a magnetic bottom, whose diameter is at least 5 inches. 2-year manufacturer's warranty, as well as customer service.
- Practical and Portable: The highly versatile RapidTherm Induction Cooktop boasts 1800W of cooking power, and many smart features at your fingertips. ETL approved and operating at standard 120V, the lightweight electric cooktop is easy to handle and store and is the ideal size for RV’s, small apartments or anywhere you need an extra cooktop. With no hot coils or open flames, it’s the hassle-free way to create sumptuous dishes.
- Energy-Friendly: The powerful induction burner only heats the diameter of the pan, so no energy is wasted. Plus heat is instant and evenly distributed, cooking your food 50% faster than conventional gas or electric cooktops. Suitable for induction-ready cookware with flat ferrous bases (test with a magnet) such as cast iron, enameled steel, or magnetic stainless steel with base diameter between 4.8”-10.2”.
- Digital Control Panel: Swiftly choose between 4 preset programs: Hot Pot, Slow Cook, Boil and Keep Warm that will automatically switch off after cooking. Or, for maximum flexibility, make use of the 8 power levels (200-1800 Watts), wide temperature range (140-460°F), and handy extra-long 4 hour digital timer. Includes durable blade fan for overheat protection.
- Safe And Easy To Use: In order to use this and any other induction stove, you need to use cookware with a magnetic bottom. The auto-pan detection will shut the unit off automatically after 60 seconds if no cookware, or the incorrect cookware is detected. When you need to step away for a minute, use the Pause feature to temporarily stop cooking while locking in your cooking settings. When you’re all done, simply wipe with a damp cloth.
- Superior Quality With Mueller - We are here to offer you only the best quality products designed to make your life easier. If you need any help, please feel free to contact us. Our unparalleled 24/7 live telephone customer support is ready and waiting to assist with anything you need!
- MAKE ADJUSTMENTS ON-THE-FLY – Want hotter temperature or need to cook it longer? No problem. Simply adjust on-the-fly any time. Starting the cooking process over is not necessary. Gold induction cooktop’s intuitive digital controls are easy to operate, and the response is immediate.
- 51 PRE-PROGRAMMED TEMPS - Select from the 6 convenient preset temperature settings or fine tune your own temperature from 100°F to 575°F in 10°F increments. You can also add or deduct cooking time at any time.
- SHATTER-PROOF CERAMIC GLASS – There are no open flames or hot coils that can cause burns. Unlike the competition, Gold’s heating surface is heavy-duty shatter-proof ceramic glass, which was rigorously tested to withstand intense heat without shattering. It is one of the safest cooktops in the market.
- FAST and EFFICIENT – Gold heats the pot directly transferring 85% to 90% of its electro-magnetic energy to heat energy! Traditional stovetops only convert about 30% of their heat for cooking. Cook faster without wasting energy and money.
- MELT CHOCOLATE - Mastery of the double boilers is not necessary. Simply set the Gold at 120°F; add chocolates into an induction-ready pot; and stir. It will never burn. Even preparing the most delicate sauces like Hollandaise, Beurre Blanc, and Beurre Fondue is no longer daunting.
- MAKE ADJUSTMENTS ON-THE-FLY – Want hotter temperature or need to cook it longer? No problem. Simply adjust on-the-fly any time. No need to start over. Flex’s intuitive digital controls are easy to operate, and the response is immediate.
- 45 PRE-PROGRAMMED TEMPS - Select from the 6 convenient preset temperature settings or fine tune your own temperature from 100°F to 500°F in 10°F increments. You can also add or deduct cooking time at any time.
- PRECISE TEMPERATURE CONTROL – With 45 precise temperatures at your fingertips, you can keep delicate sauces warm at 100°F to grilling a juicy steak with serious grill marks at 500°F.
- SHATTER-PROOF CERAMIC GLASS – The heating surface is heavy-duty shatter-proof ceramic glass. It was rigorously tested to withstand intense heat without shattering. It is one of the safest cooktops on the market.
- SUPERIOR TECHNOLOGY - The slim design of Flex and its patented insulation technology brings the induction heating coils closer to your cookware than the competition for faster & even heating, ensuring no hot or cold spots for optimal cooking experience.
- 51 PRE-PROGRAMMED TEMPS - Select from the 6 convenient preset temperature settings or fine tune your own temperature from 100°F to 575°F in 10°F increments. You can also add or deduct cooking time at any time.
- SHATTER-PROOF CERAMIC GLASS – There are no open flames or hot coils that can cause burns. Unlike the competition, Gold’s heating surface is heavy-duty shatter-proof ceramic glass, which was rigorously tested to withstand intense heat without shattering. It is one of the safest cooktops in the market.
- MAKE ADJUSTMENTS ON-THE-FLY – Want hotter temperature or need to cook it longer? No problem. Simply adjust on-the-fly any time. Starting the cooking process over is not necessary. Gold induction cooktop’s intuitive digital controls are easy to operate, and the response is immediate.
- PRECISE TEMPERATURE CONTROL – With 51 precise temperatures at your fingertips, you can keep delicate sauces warm at 100°F to grilling a juicy steak with serious grill marks at 575°F. Nuwave Induction Cooktops are the first induction cooktops to revolutionize the industry by introducing precision temperatures to induction cooking.
- SAFETY BUILT-IN – Even if you forget, Gold will shut off automatically when the set cook time is completed. When there is no cookware on the cooktop, Gold will not start. There are no hot coils or open flames reducing the risk of burns.
- HEATS 40% FASTER (than a typical smooth top range or stove when boiling water): Whether you're cooking a family meal or heating soup, you'll enjoy fast heat up and time-saving meal preparation with this induction cooktop.
- Flexible cooking Controls with display: Choose a heat level from 1-10 or cook with an exact temperature in Fahrenheit (180-450) or Celsius (82-232) with this induction cooker.
- ZERO TO BOIL IN 7 MINUTES: You'll enjoy less waiting time every time you boil water for hot beverages or pasta. When boiling 1. 5 quarts of water from room temperature
- Versatile pan sizes: cook with everything from small 4" Diameter Saucepans up to 10" Diameter frying pans and stockpots — it's like having a fifth burner right where you need it.
- Includes induction test magnet: if it sticks to your pan, it's induction-ready cookware.
- TWO HEATING ZONES: This Professional Digital Countertop Dual Induction Cooker by NutriChef is equipped with 2 Circular Top Panel Heating Zones with Independent Configurable Temperature Zone Setting & a Digital LCD Display Screen
- MULTIPLE COOKING MODE: Switch from one cooking mode to another w/ just one press. This has a manual cooking function with fry, steam, & water mode for easy cooking, & an automatic warm function which keeps the food warm for later serving
- LOCK FUNCTION: This product is also equipped with a Built in Child Safety Lock which locks all the operating buttons of the cooktop to protect the little ones from injuries such as scalding
- ENERGY EFFICIENT: This heavy duty 120v Electric Induction cooktop cooks food by using electromagnets so no heat is lost between the cooking surface & the pot which makes it highly energy efficient & it also makes cooking a lot easier & faster
- COMPACT & VERSATILE: This double burner is compatible with steel, cast iron, enameled iron, stainless steel, flat bottom pan or pot w/ a diameter of 12 to 26 cm. Lightweight & compact, great for home / outdoor cooking & its easy to clean
- 【STAINLESS STEEL HOUSING】Induction cooktop made of high quality 18/10 stainless steel, can withstand high temperatures, humidity, and other conditions without deformation or melt. Strong metal housing allows it to support up to 100 pounds on the surface.
- 【HIGH EFFICIENCY】This induction burner has easy-touch controls with 10 power levels from 200 to 1,800 watts and a temperature settings from 120°F to 460°F / 50°C to 240°C for accurate, even heating. Operates with 90-percent energy efficiency,and it's more efficient than traditional gas stove and electric hot plate.
- 【LONG-TIME COOKING】There’ s a timer you can set for as long as 10 hours.
- 【PORTABLE & COMPACT】Induction cooktop with durable stainless steel exterior is built to last. Lightweight design can be widely used for indoors and outdoors, includes gardens, RVs, hotel rooms,cabins,boats,yacht and homes with limited kitchen space. Compact design saves valuable counter space, convenience in storage.
- 【CERTIFICATED & SAFETY】UL commercial standard 197, completely ETL & NSF approved. Safety features include auto-pan detection, over-heat protection. Designed for commercial and professional settings, such as restaurants, industrial kitchens and other catering services.
- 🍲2 IN 1 INDUCTION COOKTOP &GRILL PAN:Portable induction cooktop 2 burner with removable cast iron griddle pan can be used either as a replacement for electric indoor grills or as a stand-alone induction burner. You can enjoy versatile cooking options with our induction cooker, perfect for frying pancakes, sausages, steaks and eggs without sticking to the grill pan🔥🔥IMPORTANT NOTE: You had to put the pan/pot on the burner BEFORE turning it on or it will shows error.
- 🍳DUAL INDUCTION COOKTOP&DUAL INDEPENDENT CONTROL:This induction cooktop has two 1200W burners, with separate controls on the left and right, allowing the two heating zones to have independent and adjustable 8 power settings.Amazingly, you can set different temperatures on both sides of the induction cooktop to meet your temperature needs for different foods (The frying function is at the same temperature). Prepare multiple dishes simultaneously and impress your guests with your culinary prowess.
- 🥩VERSATILE NON-STICK GRIDDLE:With a unique combination of textured and smooth surfaces, our removable non-stick griddle offers the freedom to grill savory kebabs on one side and fry eggs or fry pancakes on the other. And grill pan provides excellent heat retention and distribution.Barbecue while keeping warm without worrying about food cooling or burning off, reducing smoke by 95 percent for a healthier dining environment.
- 🧽EASY TO CLEAN:The induction cooktop and baking tray can be separated, and the induction burner has a high-quality smooth glass surface that can be easily cleaned with a damp cloth. The smooth surface of the all cast iron baking tray is covered with a non-toxic and non stick coating, which will not leave any fried residue.
- 🙌RUBBER-COATED HANDLES: Safety meets convenience with our cooktop's rubber-coated handles. Easily remove the baking tray, even when hot, without the risk of burns or spills.
Last update on 2024-04-11 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.
SEOCONTENT-START
Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 1 of 11 Inverted Flame at Cooktop Publication Date: November 2022 Make(s): Jayco Model(s): Jay Feather, Jay Flight SLX, Jay Flight Model Year(s): 2021 & 2022 Bulletin Type: Recall Bulletin #(s): 22V-773 US 2022-586 Canada Job Code(s): 9901582 Flat Rate(s): 9901582A-0.20 Inspection only 9901582B-0.70 Inspection and Repair Incident: Inverted Flame Affected Units: 2021-2022 Jayco Jay Feather, Jay Flight SLX, Jay Flight Parts Kit Details: N/A Misc. Tools & Supplies: 1 – Screw gun with #2 Square bit 2 – 3/4“ open end or combination wrenches 2 – Wood #6×1 screws 1 – 5”x7” wood panel piece (1/8” thick at minimum) with a 7/8”x7/8” notch in corner 1 – 2” by 22” wood cabinet panel strip 1 – Tube of sealant (Orgasil-103 or silicone based) 1 – Bubble solution (ammonia free) 1 – LP bottle for test 1 – Caulk Gun Parts Return Information: No part return Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 2 of 11 Inverted Flame at Cooktop Publication Date: November 2022 Make(s): Starcraft Model(s): Autumn Ridge Outfitter Model Year(s): 2021 & 2022 Bulletin Type: Recall Bulletin #(s): 22V-774 US 2022-587 Canada Job Code(s): 9902582 Flat Rate(s): 9902582A-0.20 Inspection only 9902582B-0.70 Inspection and Repair Incident: Inverted Flame Affected Units: 2021-2022 Starcraft Autumn Ridge Outfitter Parts Kit Details: N/A Contents: Misc. Tools & Supplies: 1 – Screw gun with #2 Square bit 2 – 3/4“ open end or combination wrenches 2 – Wood #6×1 screws 1 – 5”x7” wood panel piece (1/8” thick at minimum) with a 7/8”x7/8” notch in corner 1 – 2” by 22” wood cabinet panel strip 1 – Tube of sealant (Orgasil-103 or silicone based) 1 – Bubble solution (ammonia free) 1 – LP bottle for test 1 – Caulk Gun Parts Return Information: No part return Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 3 of 11 Inverted Flame at Cooktop Publication Date: November 2022 Make(s): Highland Ridge Model(s): Open Range, Range Lite, Olympia Sport, Olympia Model Year(s): 2021 & 2022 Bulletin Type: Recall Bulletin #(s): 22V-775 US 2022-588 Canada Job Code(s): 9904582 Flat Rate(s): 9904582A-0.20 Inspection only 9904582B-0.70 Inspection and Repair Incident: Inverted Flame Affected Units: Highland Ridge 2021-2022 Open Range, Range Lite, Olympia Sport, Olympia Parts Kit Details: N/A Misc. Tools & Supplies: 1 – Screw gun with #2 Square bit 2 – 3/4“ open end or combination wrenches 2 – Wood #6×1 screws 1 – 5”x7” wood panel piece (1/8” thick at minimum) with a 7/8”x7/8” notch in corner 1 – 2” by 22” wood cabinet panel strip 1 – Tube of sealant (Orgasil-103 or silicone based) 1 – Bubble solution (ammonia free) 1 – LP bottle for test 1 – Caulk Gun Parts Return Information: No part return Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 4 of 11 1. Make sure all the cabinet doors are closed. Turn on the furnace and the stove burners to the lowest setting. Verify if inverted flame is present like in Object A. If yes, follow instructions below for the cooktop. 1.) Turn gas “OFF” at LP bottle(s) at front of unit. 2.) Remove cooktop from countertop area (Model 174 BH shown). a. Remove cooking grate then remove 2 screws (yellow arrows) holding black top to cooktop pan shown in Figure 1. b. Gently, pull up near glass top to remove top of cooktop. c. Using two ¾” wrenches, disconnect gas line hose from cooktop. (Figure 2) INVERTED FLAME COOKTOP INSPECTION VISUAL INSTRUCTIONS FOR SEALING COOKTOP SHELF AREA Screw Screw PlacementPlacement Fig. Fig. 11 Gas Gas LineLine Fig Fig.. 22 Object A Object A Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 5 of 11 d. Remove 4 screws shown in Figure 3 with yellow arrows connecting cooktop pan to countertop/cleat(s) then lift out cooktop pan from countertop. e. Remove each individual white and black wire from each wire connector shown in Object 1 & Object 2 so cooktop can be removed. 3.) Seal the gas line hose 7/8”x 7/8” notch. a. Cut 5”x7” square out of the 1/8” minimum thickness wood panel. b. Cut a 7/8”x7/8” notch in one corner of the 5”x7” wood panel. c. Use 5”x7” wood panel piece to close up larger notch in cooktop shelf area where gas line hose came through. d. Position gas line hose to pass through 7/8”x7/8” corner notch, with a minimum of 2 screws secure 5”x7” wood panel piece down to cooktop shelf. e. Use sealant to seal around gas line hose and 5”x7” wood panel piece. Figure 4 is before repair & Figure 5 is after repair. Fig. Fig. 33 Fig. Fig. 55 Object 1 Object 1 Object 2 Object 2 Fig. Fig. 44 Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 6 of 11 4. Seal shelf and area adjoining cooktop area a. Check to see if divider panel located between cooktop shelf and kitchen sink area is secured to cooktop shelf. If not, secure divider panel to cooktop shelf. b. Use sealant to seal cooktop shelf to all sides. c. Use sealant to seal cooktop shelf corners and any other visible holes in paneling. d. Use sealant to seal divider panel to countertop bottom that is located between cooktop area and kitchen sink. Seal is to be applied to cooktop shelf side or kitchen sink side of divider panel. Figure 6 is before sealant and Figures 7 – 9 are after seal. Fig. Fig. 66 Fig. Fig. 88 Fig. Fig. 99 Fig. Fig. 77 Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 7 of 11 *** Refer to Figure 10 if the unit needs an exterior 2” by 22” wood cabinet panel strip under the sink. Secure wood cabinet panel strip to the divider panel with the wood screws to close the space between top left and top right of divider panel and countertop. Then seal around the wood cabinet panel strip. *** 5. Re-install cooktop in countertop area. a. Reverse steps 2c through 2e. b. Before securing cooktop top, turn gas “ON” at LP bottle(s) at front of unit. c. Check for leaks with bubble solution (ammonia free) at gas line hose and cooktop connection. If leak is detected, then correct and re-check. Once no leak is detected, proceed to next step. d. Install cooktop top onto cooktop pan and cooktop grate as in steps 2a & 2b. 6. Validate flame does not invert when cooktop and furnace are both “ON”. a. Light both burners on cooktop and set to “High”. b. Turn furnace “ON”. c. Turn cooktop burners to “Low”. d. Validate flame is not inverted. i. Figure 11 show flame to be inverted (flames are turned downwards towards cooktop pan). Figures 12 & 13 show the flame to be normal flames are turned upwards away from cooktop. Fig. Fig. 1010 Fig. Fig. 1111 Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 8 of 11 INVERTED FLAME COOKTOP OVEN INSPECTION 1.) Make sure all the cabinet doors are closed. Turn on the furnace and the cooktop burners to the lowest setting. Verify if inverted flame is present as shown in Figure 1. Follow instructions below for the cooktop oven if inverted flame is present. Fig. Fig. 1313 Fig. Fig. 1212 Fig. Fig. 11 Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 9 of 11 1. Turn gas “OFF” at LP bottle(s) at front of unit. a. Locate a scrap panel piece and cut to size 25 ¾ x 21 11/16. Then follow the print (PATTERN –AF) to cut notches. (Figure 1) 2. Cut 2 cleats to ¾ X ¾ X 17”. 3. Cut 1 cleats to ¾ X ¾ X 20”. 4. Place one 20” cleat along the edge that is 25 ¾” closest to the cabinet drawers. Place the 17” cleats along both edges that are 21 11/16” using D10 staples. (Figure 2) 5. Remove the oven: a. Take the cooktop off. b. Unscrew the four screws, two on each side of the cooktop. (Figure 3) c. Unscrew the two that are in the front when you open the oven door. (Figure 4) INVERTED FLAME COOKTOP OVEN REPAIR INSTRUCTIONS Figure 1Figure 1 Fig. Fig. 22 Fig. Fig. 33 Fig. Fig. 44 Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 10 of 11 6. Unhook the LP hose and the wires. (Figure 5 and 6) 7. Remove the top two drawers of the kitchen cabinet and pull the power center out. 8. Install the panel with the cleats facing down. Attach one cleat with a wood screw to the side wall (Figure 7). Attach another cleat to the back of the power center face frame using L14 staples (Figure 8). From the drawerside, 19” up from the floor, attach the panel to a cleat using D10 staples (Figure 9). Fig. Fig. 55 Fig. Fig. 66 Fig. Fig. 77 Fig. Fig. 88 Fig. Fig. 99 Recall # 22V-773, 774, 775 Inverted Flame November 2022 Page 11 of 11 9. Install the grommet over the gas line so that it sits in the notch where the gas line comes through the panel. Attach to the panel with a wood screw. Seal the oven box. (Figure 10) 10. Reinstall the drawers and load center. Place the oven back in the box, hooking up the LP and wires. Check for leaks with bubble solution (ammonia free) at gas line hose and oven connection. If leak is detected, then correct and re-check. Once no leak is detected, proceed to next step. Fully push in the oven and reinsert screws. 11. Retest for inverted flame per the inspection section. If properly sealed, the flames will go upwards as normal. (Figure 11) Jayco’s sole obligation under our limited warranty is to repair or replace defective materials and/or workmanship deemed our responsibility as determined by Jayco in our sole discretion. Jayco reserves the right to use new and/or remanufactured parts or materials of similar quality to complete any work, and to make parts and/or design changes as appropriate without notice to anyone. Jayco designs and/or materials changes are done without obligation to incorporate such changes in previously manufactured product. Jayco makes every reasonable effort to ensure field remedies will not adversely affect performance and/or safety of the unit. This field remedy is not intended to extend to future performance of this RV, or any of its materials, components or parts beyond the standard warranty period. The RV owner’s obligation to notify Jayco, or one of its independent, authorized dealers, of a claimed defect does not modify any obligation placed on the RV owner to contact Jayco directly when attempting to pursue remedies under state or federal law. 903 South Main Street • P.O. Box 460 • Middlebury, IN 46540 Fig. Fig. 1010 Fig. Fig. 1111
**************************************************************************************************************
MPORTANT SAFETY RECALL This Notice Applies to Your Recreational Vehicle «unit_serial_» «NAME» «ADDRESS» «CITY», «ST» «ZIP» Dear Valued Customer: This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act. Jayco Inc. has decided that a defect which relates to motor vehicle safety exists in certain Jayco; 2021 Jay Flight, 2022 Jay Flight SLX, 2022 Jay Feather, Starcraft RV; 2021-2022 Autumn Ridge Outfitter, Highland Ridge RV; 2021-2022 Open Range, 2022 Range Lite, 2022 Olympia, and 2022 Olympia Sport travel trailers. The flame on the cooktop will invert when the furnace is running. The cooktop is installed in a cabinet that is not sealed from the furnace area. When the furnace and the cooktop are operated at the same time the cooktop burner flame can invert leading to an increased risk of personal injury or fire. Remedy consists of adding sealant and plywood panels to seal the area around the gas line hose and the area adjoining the cooktop. The remedy will be performed free of charge to you and will take approximately 45 minutes to complete. Please contact a Jayco certified repair facility and schedule an appointment for this remedy. CAUTION: Do not use the cooktop and the furnace at the same time until the remedy is completed. Federal regulations require that any vehicle lessor receiving this recall notice must forward a copy of this notice to the lessee within ten days. If you had this repair completed prior to receipt of this recall notice, you may be eligible to receive reimbursement for the cost of obtaining a pre-notification remedy of the problem associated with this recall. Submit an email to service@jayco.com including your name, address, VIN, recall number, and a clear, legible receipt showing the identification of the product that was recalled. If your dealer does not remedy this condition at no charge, please contact our Customer Service Department at 800-283-8267. If you are unable to get this safety defect remedied without charge and/or within a reasonable amount of time after contacting your dealer and Jayco customer service, you may want to contact NHTSA. To submit a written complaint contact the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Avenue, SE., Washington, DC 20590; or call the toll-free Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153): or go to http://www.safercar.gov. We certainly regret this inconvenience; however, your safety is our most important priority. Sincerely, Compliance Management Jayco Inc. Towable Division Reason for this recall What we need you to do Recall Remedy November 2022 Safety Recall: Jayco-NHTSA # 22V-773 Starcraft RV-NHTSA # 22V-774 Highland Ridge-NHTSA# 22V-775
**************************************************************************************************************
IMPORTANT SAFETY RECALL This Notice Applies to Your Recreational Vehicle «NAME» «ADDRESS» «CITY», «ST» «ZIP» Dear Valued Dealer: This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act. Jayco Inc. has decided that a defect which relates to motor vehicle safety exists in certain Jayco; 2021 Jay Flight, 2022 Jay Flight SLX, 2022 Jay Feather, Starcraft RV; 2021-2022 Autumn Ridge Outfitter, Highland Ridge RV; 2021-2022 Open Range, 2022 Range Lite, 2022 Olympia, and 2022 Olympia Sport travel trailers. The flame on the cooktop will invert when the furnace is running. The cooktop is installed in a cabinet that is not sealed from the furnace area. When the furnace and the cooktop are operated at the same time the cooktop burner flame can invert leading to an increased risk of personal injury or fire. Remedy consists of adding sealant and plywood panels to seal the area around the gas line hose and the area adjoining the cooktop. The remedy will take approximately 45 minutes to complete and must be performed free of charge to the retail owner. Our records show the following unit is affected by this recall and is part of the current inventory at your dealership. «VIN» Federal law requires the Recall Remedy be completed on this unit prior to customer delivery. Please confirm the unit serial number requires the Recall Remedy using Unit Management in Jayco Partners. The instructions for the Recall Remedy are available under the Case Recall number in attachments. If you sold this unit recently, please contact the owner immediately to inform them of this recall. In addition, please register this unit through Jayco Partners. Federal regulations require that any vehicle lessor receiving this recall notice must forward a copy of this notice to the lessee within ten days. If you have any questions, please contact Jayco Customer Service at 800-283-8267 for assistance. We certainly regret this inconvenience; however, our Customers’ safety is our most important priority. Sincerely, Compliance Management Jayco Inc. Towable Division November 2022 Safety Recall: Jayco-NHTSA # 22V-773 Starcraft RV-NHTSA # 22V-774 Highland Ridge-NHTSA# 22V-775 Reason for this recall What you need you to do Recall Remedy
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-773 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Jayco, Inc. Submission Date : NOV 18, 2022 NHTSA Recall No. : 22V-773 Manufacturer Recall No. : 9901582 Manufacturer Information : Manufacturer Name : Jayco, Inc. Address : 903 South Main Street PO Box 460 Middlebury IN 46540 Company phone : 800-283-8267 Population : Number of potentially involved : 2,748 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2021-2022 Jayco Jay Feather, Jay Flight, Jay Flight SLX Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : The recall population was determined using our production records. Production Dates : JUL 14, 2020 – JUN 27, 2022 VIN Range 1 : Begin : 1UJBJ0AH0N77D0074 End : 1UJBJ0BRXM1TD0175 ✔ Not sequential Description of Defect : Description of the Defect : Flame on the cooktop may invert when the furnace is running. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : When the furnace and cooktop are operated at the same time the cooktop burner flame may invert leading to an increased risk of personal injury of fire. Description of the Cause : The cooktop is installed in a cabinet that is not sealed from the furnace area. Identification of Any Warning that can Occur : An inverted flame could be detected visually. Involved Components : Part 573 Safety Recall Report 22V-773 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : Furnace Component Description : FURNACE, 19000 BTU SBRBN NT-20SEQ W/DIRECT DISCH GRL BLK Component Part Number : 2016165 Component Name 2 : Stove Component Description : STOVE, TOP 2-BNR GRAST GL TOP BLK Component Part Number : 2023364 Component Name 3 : Stove Component Description : STOVE, GAS 3BNR 17″ OVN BLK W/LED LT & GL DR Component Part Number : 2015062 Supplier Identification : Component Manufacturer Name : NR Address : NR NR Country : NR Chronology : In January 2022, Jayco received a claim of an inverted flame on the cooktop of a unit built in our Idaho location. Jayco began monitoring our data for other similar allegations. Claims slowly continued to come in and each was discussed and evaluated in our weekly Warranty Incident Review Committee (WIRC) meetings. In May 2022, an incident on a Starcraft unit was elevated from WIRC to the Corrective Preventive Action Committee (CPAC). The CPAC committee met on May 18, 2022 and discussed the incidents and decided to open an investigation. On September 7, 2022, CPAC decided to elevate this matter to the Safety Steering Committee (SSC). Jayco towable engineering conducted testing to better understand the conditions that could lead to an inverted flame. This research was concluded at the start of October 2022. On October 10, 2022 SSC met to discuss this matter and voted in favor of proceeding with a safety recall. Jayco received a total of eight claims between January 2022 and October 2022. Part 573 Safety Recall Report 22V-773 Page 3 The information contained in this report was submitted pursuant to 49 CFR §573 Description of Remedy : Description of Remedy Program : Sealant and plywood panels will be used to seal the area around the gas line hose and the area adjoining the cooktop. On some units, plywood panels will be installed to separate the furnace and cooktop. This remedy will be done at no cost to the owner. Repairs made prior to the recall will be reimbursed in accordance with our Recall Reimbursement Plan on file with NHTSA. Jayco Inc. will file completion reports. How Remedy Component Differs from Recalled Component : The flame on the cooktop will not invert when the furnace operates. Identify How/When Recall Condition was Corrected in Production : By the start of October 2022, information was shared with production to emphasize the importance of sealing the area around the cooktop when the furnace is located in or near the cooktop. Sealant and plywood panels were used to seal the area around the gas line hose and the area adjoining the cooktop. Recall Schedule : Description of Recall Schedule : Jayco Inc. will notify its dealers and affected retail owners. Planned Dealer Notification Date : NOV 30, 2022 – NOV 30, 2022 Planned Owner Notification Date : NOV 30, 2022 – NOV 30, 2022 * NR – Not Reported
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-773 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Jayco, Inc. Submission Date : OCT 14, 2022 NHTSA Recall No. : 22V-773 Manufacturer Recall No. : 9901582 Manufacturer Information : Manufacturer Name : Jayco, Inc. Address : 903 South Main Street PO Box 460 Middlebury IN 46540 Company phone : 800-283-8267 Population : Number of potentially involved : 2,748 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2021-2022 Jayco Jay Feather, Jay Flight, Jay Flight SLX Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : The recall population was determined using our production records. Production Dates : JUL 14, 2020 – JUN 27, 2022 VIN Range 1 : Begin : 1UJBJ0AH0N77D0074 End : 1UJBJ0BRXM1TD0175 ✔ Not sequential Description of Defect : Description of the Defect : Flame on the cooktop may invert when the furnace is running. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : When the furnace and cooktop are operated at the same time the cooktop burner flame may invert leading to an increased risk of personal injury of fire. Description of the Cause : The cooktop is installed in a cabinet that is not sealed from the furnace area. Identification of Any Warning that can Occur : An inverted flame could be detected visually. Involved Components : Part 573 Safety Recall Report 22V-773 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : NR Component Description : NR Component Part Number : NR Supplier Identification : Component Manufacturer Name : NR Address : NR NR Country : NR Chronology : In January 2022, Jayco received a claim of an inverted flame on the cooktop of a unit built in our Idaho location. Jayco began monitoring our data for other similar allegations. Claims slowly continued to come in and each was discussed and evaluated in our weekly Warranty Incident Review Committee (WIRC) meetings. In May 2022, an incident on a Starcraft unit was elevated from WIRC to the Corrective Preventive Action Committee (CPAC). The CPAC committee met on May 18, 2022 and discussed the incidents and decided to open an investigation. On September 7, 2022, CPAC decided to elevate this matter to the Safety Steering Committee (SSC). Jayco towable engineering conducted testing to better understand the conditions that could lead to an inverted flame. This research was concluded at the start of October 2022. On October 10, 2022 SSC met to discuss this matter and voted in favor of proceeding with a safety recall. Jayco received a total of eight claims between January 2022 and October 2022. Description of Remedy : Description of Remedy Program : Sealant and plywood panels will be used to seal the area around the gas line hose and the area adjoining the cooktop. On some units, plywood panels will be installed to separate the furnace and cooktop. This remedy will be done at no cost to the owner. Repairs made prior to the recall will be reimbursed in accordance with our Recall Reimbursement Plan on file with NHTSA. Jayco Inc. will file completion reports. How Remedy Component Differs from Recalled Component : The flame on the cooktop will not invert when the furnace operates. Part 573 Safety Recall Report 22V-773 Page 3 The information contained in this report was submitted pursuant to 49 CFR §573 Identify How/When Recall Condition was Corrected in Production : By the start of October 2022, information was shared with production to emphasize the importance of sealing the area around the cooktop when the furnace is located in or near the cooktop. Sealant and plywood panels were used to seal the area around the gas line hose and the area adjoining the cooktop. Recall Schedule : Description of Recall Schedule : Jayco Inc. will notify its dealers and affected retail owners. Planned Dealer Notification Date : NOV 21, 2022 – NOV 21, 2022 Planned Owner Notification Date : NOV 21, 2022 – NOV 21, 2022 * NR – Not Reported
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-773 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Jayco, Inc. Submission Date : NOV 11, 2022 NHTSA Recall No. : 22V-773 Manufacturer Recall No. : 9901582 Manufacturer Information : Manufacturer Name : Jayco, Inc. Address : 903 South Main Street PO Box 460 Middlebury IN 46540 Company phone : 800-283-8267 Population : Number of potentially involved : 2,748 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2021-2022 Jayco Jay Feather, Jay Flight, Jay Flight SLX Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : The recall population was determined using our production records. Production Dates : JUL 14, 2020 – JUN 27, 2022 VIN Range 1 : Begin : 1UJBJ0AH0N77D0074 End : 1UJBJ0BRXM1TD0175 ✔ Not sequential Description of Defect : Description of the Defect : Flame on the cooktop may invert when the furnace is running. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : When the furnace and cooktop are operated at the same time the cooktop burner flame may invert leading to an increased risk of personal injury of fire. Description of the Cause : The cooktop is installed in a cabinet that is not sealed from the furnace area. Identification of Any Warning that can Occur : An inverted flame could be detected visually. Involved Components : Part 573 Safety Recall Report 22V-773 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : Furnace Component Description : FURNACE, 19000 BTU SBRBN NT-20SEQ W/DIRECT DISCH GRL BLK Component Part Number : 2016165 Component Name 2 : Stove Component Description : STOVE, TOP 2-BNR GRAST GL TOP BLK Component Part Number : 2023364 Component Name 3 : Stove Component Description : STOVE, GAS 3BNR 17″ OVN BLK W/LED LT & GL DR Component Part Number : 2015062 Supplier Identification : Component Manufacturer Name : NR Address : NR NR Country : NR Chronology : In January 2022, Jayco received a claim of an inverted flame on the cooktop of a unit built in our Idaho location. Jayco began monitoring our data for other similar allegations. Claims slowly continued to come in and each was discussed and evaluated in our weekly Warranty Incident Review Committee (WIRC) meetings. In May 2022, an incident on a Starcraft unit was elevated from WIRC to the Corrective Preventive Action Committee (CPAC). The CPAC committee met on May 18, 2022 and discussed the incidents and decided to open an investigation. On September 7, 2022, CPAC decided to elevate this matter to the Safety Steering Committee (SSC). Jayco towable engineering conducted testing to better understand the conditions that could lead to an inverted flame. This research was concluded at the start of October 2022. On October 10, 2022 SSC met to discuss this matter and voted in favor of proceeding with a safety recall. Jayco received a total of eight claims between January 2022 and October 2022. Part 573 Safety Recall Report 22V-773 Page 3 The information contained in this report was submitted pursuant to 49 CFR §573 Description of Remedy : Description of Remedy Program : Sealant and plywood panels will be used to seal the area around the gas line hose and the area adjoining the cooktop. On some units, plywood panels will be installed to separate the furnace and cooktop. This remedy will be done at no cost to the owner. Repairs made prior to the recall will be reimbursed in accordance with our Recall Reimbursement Plan on file with NHTSA. Jayco Inc. will file completion reports. How Remedy Component Differs from Recalled Component : The flame on the cooktop will not invert when the furnace operates. Identify How/When Recall Condition was Corrected in Production : By the start of October 2022, information was shared with production to emphasize the importance of sealing the area around the cooktop when the furnace is located in or near the cooktop. Sealant and plywood panels were used to seal the area around the gas line hose and the area adjoining the cooktop. Recall Schedule : Description of Recall Schedule : Jayco Inc. will notify its dealers and affected retail owners. Planned Dealer Notification Date : NOV 21, 2022 – NOV 21, 2022 Planned Owner Notification Date : NOV 21, 2022 – NOV 21, 2022 * NR – Not Reported
SEOCONTENT-END