Component Wit Recommended Exposure Limits (TWA)
Microcrystalline wax 5-10 ACGIH TLV: 2 mg/m’

CAS #64742-42-3 OSHA PEL: 2 mg/m’

Petroleum distillates, solvent dewaxed 5-15 ACGIH TLV: 5 mg/m’

heavy paraffinic

CAS #64742-65-0 OSHA PEL: 5 mg/m?

Sulfonic acids, petroleum, 5-15 ACGIH TLV: 5 mg/m’ (oil mist)
Calcium salts, overbased OSHA PEL: § mg/m (oil mist)

CAS #68783-96-0

White mineral oil, petroleum 50-60 ACGIH TLV: 5 mg/m? (oil mist)
CAS #8042-47-5 OSHA PEL: 5 mg/m’ (oil mist)
Bentonite, quaternary ammonium 0.3-1.0 Not established

compound modified
CAS# 68953-58-2

712AM Page 1 of 4
Soybean oi] polymer with isophthalic 0.44 Not established
acid and pentaeryihritol
CAS# 66071-86-1

Castor oil, dehydrated, polymerized 5-15 Not established

CAS# 68038-02-8

Calcium Carbonate §-10 OSHA PEL: 5 mg/m? (respirable fraction)
CAS #471-34-1 OSHA PEL: 15 mg/m? (total dust)

ACGIH TLV: 10 mg/m’ (7! nuisance dust)

1 This component poses a hazard only if a dust is formed, i.c., by sawing, sanding, drilling, etc.

SECTION 3: HEALTH HAZARD INFORMATION

Primary Routes of Entry: Skin absorption, cyes (splashing).

Acute Effects: May cause eye irritation and reversible skin irritation. Prolonged skin exposure may cause dermatitis
or oil acne. Breathing mists may cause dizziness or pulmonary irritation.

Chronic Overexposure:

Carcinogenicity: None of the components of this product are listed as carcinogens by NTP, IARC, or OSHA
1910(Z).

Pre-Existing Medical Conditions Aggravated by Exposure: Exposure may aggravate pre-existing respiratory or
skin problems.

SECTION 4: FIRST AID PROCEDURES

Inhalation (mist): Move victim to fresh air and call emergency medical care. If not breathing, give artificial
respiration; if breathing is difficult, give oxygen.

Eyes: In case of contact with material, immediately Mush eyes with running water for at least 15 minutes, Seck
immediate medical attention.

Skin: Wash skin with soap and water. Remove and isolate contaminated clothing and shoes at the site.

Ingestion: DO NOT INDUCE VOMITING. Consult a physician. If vomiting occurs spontaneously, keep head
below hips to prevent aspiration of liquid into the lungs.

| SECTION 5: FIRE AND EXPLOSION HAZARD DATA

Flash Point: >200°C (TCC )
Explosive Limits: LEL: N/A UEL: N/A

EXTINGUISHING MEDIA: Small Fires: Dry chemical, CO2, water spray, or regular foam. Large Fires: Waier
spray, fog, or regular foam. Move container from fire area if you can do it without risk. Apply cooling water to sides
of containers that are exposed to flames until well after fire is out. Stay away from ends of tanks. For massive fire in
cargo area, use unmanned hose holder or monitor nozzles. If this is impossible, withdraw from area and let fire burn.
Withdraw immediately in case of rising sound from venting safety device or any discoloration of tank duc to fire.
Special Firefighting Protection/Emergency Action: Fire may produce irritating or poisonous gases. Positive
pressure self-contained breathing apparatus (SCBA) and structural firefighters’ protective clothing will provide
limited protection. Keep unnecessary people away; isolate hazard area and deny entry. Stay upwind; keep out of low
areas. Isolate for 1/2 mile in all directions if tank, rail car or tank truck is invelved in fire, If runoff from fire control
occurs, notify the appropriate authorities,

Unusual Fire/Explosion Hazards: Combustible material; may be ignited by flames. Container may explode in heat
of fire.

Products of Combustion: Carbon monoxide, carbon dioxide, oxides of sulfur, miscellaneous hydrocarbons.

712AM Page 2 of 4

| SECTION 6: SPECIAL PRECAUTIONS AND SPILL/LEAK PROCEDURES |

Steps to be taken in case Material is Released or Spilled: Shut off ignition sources; no flares, smoking or flames
in hazard area, Stop leak if you can do it without risk.

Small Spills: Take up with sand or other noncombustible absorbent material and place into containers for later
disposal.

Large Spills: Dike far ahead of liquid spill for later disposal.

SECTION 7: SAFE HANDLING INFORMATION

Precautions To Be Taken In Handling/Storage: Store in cool, well-ventilated area. Keep away from flames.
Never use a torch to cut or weld on or near container.

Other Precautions: Never wear contaminated clothing. Launder or dry clean before wearing. Discard oil-soaked
shoes. Wash thoroughly with soap and water (waterless hand cleaner may be helpful in removing residues) afier use
and before smoking or eating. Avoid excessive skin contact.

| SECTION 8: EXPOSURE CONTROLS

Respiratory Protection: NJOSH-approved respirator for organic vapor and mist to contro] exposure where
ventilation is inadequate.

Ventilation: General and local exhaust.

Personal Protective Equipment: Protective Gloves: Impervious gloves (Viton, PVOH, etc.} Eye Protection: Safety
glasses with sideshields or chemical goggles. Other Protective Clothing or Equipment: If splashing is anticipated,
wear rubber apron and boots or other protective equipment to minimize contact.

SECTION 9: REACTIVITY HAZARD DATA

Stability: Stable

Incompatibility: Strong acids, oxidizing agents.

Hazardous Decomposition Products: Carbon monoxide, carbon dioxide, oxides of sulfur, miscellaneous
hydrocarbons.

Hazardous Polymerization: Will not occur.

| SECTION 10: PHYSICAL AND CHEMICAL PROPERTIES |
Color: Tan
Appearance: Viscous Liquid
Odor: Oil

Boiling Point (initial): NA
Evaporation Rate (n-Butyl Acetate=1 ): a - |

Personal Protection _—

Soken Trade Corporation Page 8 of 9 www.noxudolusa.com
A MATERIAL SAFETY DATA SHEET

Noxudol 300 S
VJ AUSON Last Updated April 18, 2011
ee

National Fire Protection Association (NFPA):

NFPA Ratings: Health: 1, Flammability: 1, Reactivity: 0

NFPA/HMIS Definitions: 0-Least, 1-Slight, 2-Moderate, 3-High, 4-Extreme
Protective Equipment: Goggles & shield; lab coat & apron; vent hood; proper gloves; class b extinguisher.

Prepared By: Donato Polignone (MSDS Authoring Services) Part Number: --
Approved By: Soken Trade Corporation
Approval Date: April 18, 2011 Supersedes Date: March 1, 2011

ADDITIONAL INFORMATION:

The data in this Materiat Safety Data Sheet relates only to the specific material designated herein. It does not relate to use in
combination with any other maternal or in any process. This Material Safety Data Sheet (MSDS) has been reviewed to fully comply with
the guidance contained in the ANSI MSDS standard (ANS! Z400.1-2004)

This information is fumished without warranty, expressed or implied, except that it is accurate to the best knowledge of Soken Trade
Corporation. The data on this sheet are related only to the specific material designated herein. Soken Trade Corporation assumes no
legal responsibility for use or reliance upon these data.

To the best of our knowledge, the information contained herein is accurate. However, neither the above named supplier nor any of its
subsidiaries assumes any liability whatsoever for the accuracy or completeness of the information contained herein. Final
determination of suitability of any material is the sole responsibility of the user. All materials may present unknown hazards and
should be used with caution. Although certain hazards are described herein, we cannot guarantee that these are the only hazards that
exist.

END OF MSDS

Soken Trade Corporation Page 9 of 9 www.noxudolusa.com
(This page intentionally left blank.)
6 AUSON

Jctober 22, 2010

Toyota Motor Company
1 Toyota-Cho
Toyota City, Aichi Prefecture 471-8571, Japan

This letter is to inform you that Auson AB and Vaupel GmbH wiil certify that the 3300 HSDR
pressure pot gun meets or even exceeds the transfer efficiency of HVPL equipment.

The transfer efficiency of the 3300 HSDR spray gun and 90° hooked wand was evaluated using
Auson’s Noxudol 300 rust preventive under-body material. Testing was performed at Auson
AB’s laboratory at “Verkstadsgatan 3, 43442 Kungsbacka Sweden.

The South Coast AQMD Spray Equipment Transfer Efficiency Testing Procedure for
Equipment Users dated May 24, 1989 was the test protocol employed under the application
conditions indicated

The 3300HSDR spray equipment that we have provided you for the application of Noxudol300
exceed the minimum transfer efficiency of 65% when operated between 50 and 90 PSI.
Attached find actual data and files associated with our testing.

Please don’t hesitate to contact us with eventual questions.

incerely
Pér Udesen \
Gen. Manager President
Auson AB Vaupel GmbH

Auson AB Verkstadsgatan 3 * 434 42 Kungsbacka
Tel. 0300-562000 + Fax. 0300-562001 + Email. [email protected] » www.auson.se
(This page intentionally left blank.)
nm South Coast
Air Quality Management District

»,, ~'865 Copley Drive, Diamond Bar, CA 91765-4178
(909) 396-2000 - www.aqmd.gov

March 22, 2011

Mr. Daniel E. Monette

National Manager
Environmental, Health and Safety
Toyota Motor Sales, U.S.A., Inc.
19001 South Western Avenue
Torrance, CA 90501

Dear Mr. Monette:
Subject: Rule 1151 Transfer Efficiency Approval of the Vaupel HSDR 3300 Spray Gun

Reference is made to your application number 518629 which you submitted to request
that the Vaupel HSDR 3300 spray gun be considered equivalent to high-volume, low-
pressure (HVLP) spray equipment under Rule 1 151(d)(7)A)(iii) for the application of
internal (Parker 712 AM) and external (Auson AB Noxudol 3008S) protective coatings on
the frame rails of Toyota Tacoma trucks (model years 1995 through 2004) and Toyota
Tundra trucks (model years 2000 through 2006). In support of your request, you
submitted the following information.
1. A report entitled, “Supplemental Spray Equipment Transfer Efficiency Test of the
Vaupel HSDR 3000 using Noxudol 300” dated January 19, 2011
2. MSDS for the Parker 712 AM and Auson AB Noxudol 300 S coatings
3. Photographs of spray patterns for typical HVLP spray guns and the Vaupel HSDR
3300 spray gun
4. Photographs of the Tundra undercarriage showing the frame rails
5. Drawings of the Tacoma and Tundra frames
6. An e-mail dated February 3, 2011 containing supplemental information

The results of the transfer efficiency testing performed on December 28, 2010 indicate
that the Vaupel HSDR 3300 spray gun is capable of achieving a transfer efficiency of
69.04% when applying the Auson AB Noxudol 300 S exterior protective coating. Toyota
Motor Sales did not submit transfer efficiency test results for an HVLP spray gun
applying the Auson AB Noxudol 300 S exterior protective coating for comparison
purposes since HVLP spray technology is not capable of reaching all of the exterior
surfaces of the frame rails due to the configuration of the frame rails and other vehicle
parts that are in close proximity to the frame rails. The lack of sufficient accessibility to
the frame rails prevents the successful use of HVLP spray technology for applying the
exterior protective coating.
Mr. Daniel E. Monette -2- March 22, 2011

While actual transfer efficiency testing was not conducted to simulate the proposed
application of the Parker 712 AM interior protective coating, Toyota Motor Sales did
submit information on February 26, 2009 and January 21, 2011 regarding the
configuration of the frame rails and the viscosity of the coating. Both the interior
configuration of the frame rails and the high viscosity of the Parker 712 AM coating
make the use of HVLP spray equipment infeasible. A review of the design of the tubular
frame rails of the Tacoma and Tundra trucks indicates that the transfer efficiency for
coating the interior of the frame rails should approach 99%.

Based on the transfer efficiency test data for the Auson AB Noxudol 300 S$ exterior
protective coating, an evaluation of the configuration of the Tacoma and Tundra frame
rails, the tubular configuration of portions of the Tacoma and Tundra frame rails, the
calculated transfer efficiency for coating the interior of the tubular frame rails, and the
viscosity of the Parker 712 AM interior coating, the Vaupel HSDR 3300 spray gun is
approved for limited operations subject to Rule 1151, Motor Vehicle and Mobile
Equipment Non-Assembly Line Coating Operations, under Rule 1151(d)(7)(A)(iii)
provided the following conditions are met.

1. The Vaupel HSDR 3300 spray gun shall only be used to apply Auson AB
Noxudol 3008 and Parker 712AM corrosion preventive coatings to the frame
rails of Toyota Tacoma trucks model years 1995-2004 and Tundra trucks model
years 2000-2006 at the Toyota Motor Sales, U.S.A., Inc. facility located at 2015
W. 190" Street, Torrance, CA 90501 and identified by District facility ID
80904.

2. This approval is only valid if the air pressure supplied to the Vaupel HSDR 3300
spray gun is equal to or less than 52 psig when applying the Auson AB Noxudol
300 S coating and equal to or less than 75 psig when applying the Parker 712
AM coating.

3. This approval is only valid if during actual operation the Vaupel HSDR spray
gun is equipped with a 160 psig (full scale) mechanical pressure gauge with
markings every 2 psig and the pressure gauge is operating properly.

4. The Vaupel HSDR 3300 spray gun shall be equipped with a Vaupel Cavity
Spray Tube 3900/3901-WH spray wand when applying the corrosion preventive
coatings. The Auson AB Noxudol 300 §S protective coating shall only be
applied to the exterior of the frame rails. The Parker 712 AM protective coating
shall only be applied to the interior of the frame rails. During operation, the
maximum distance of the spray wand tip to the substrate to be coated shall not
exceed 8 inches.

5. Pursuant to District Rule 219, unless a permit to construct and operate is
obtained from the District for the Vaupel HSDR 3300 spray gun, the maximum
quantity of coatings and associated VOC containing solvents (including clean-
up) used in the Vaupel HSDR 3300 spray gun shall not exceed 1 gallon per day
or 22 gallons per calendar month. Toyota Motor Sales shall maintain records of
Mr. Daniel E. Monette -3- March 22, 2011

the coating usage. The last two years of records shall be retained at the facility
and be made available to District representatives upon request.

6. This approval is only valid for the Vaupel HSDR 3300 spray gun model tested.
Any modification of the spray gun or pressure gauge design shall invalidate this
approval unless the modification is approved by the South Coast Air Quality
Management District.

If you have any questions regarding this approval, please call Emmanuel Quizon, AQ
Engineer, at (909) 396-2523 or send him an e-mail at [email protected].

Sincerely,

Fad Seen

Fred Lettice

Senior Manager

Coating, Printing, Plating, Military
& Entertainment Operations

FEL:EVQ
(This page intentionally left blank.)
6007 VET 18S

SS

‘JOUUBU 1901209 APE}USWUORAUS UB Li) pass aq
PMOYS euAeW Bupjoed pus seyossesce g) 'aAep ay) —-
TO3s}ol J eeu oA

uaBbe Bupuess iim sysodep sacway

‘paBBop Apved ()) un6 so e[zzou ojB8ue so Awds puna

agra Amides Aves ‘{pe) oqn) Gupusose ‘{g)) ejzzou Ads
-Apadoud Awdsjou seop ung -

“SBlUA jbisAes (z) 1966)9 oy) sseudeg -unG

Uf 20 Lod |yaqu) J/€ Oly Oyu! 40 3}0g AIBA Ot UO FO Ing
{BS0/9 JOU SBOP JO YON)S 8] (B) yO BA|EA, -
Bynes

‘Wei 07a 8] Jo Bulfup
0} enp peBGop swoteq Ae sys Aeuds ou) eeURUO
‘URS Ge Aoy) UaYyM AUC seqry Adds 9un 82035
Loney
‘(BBO
jnoge jo poved pepusyxe ue Jo) pesnun wewes o) e UNG
04) JI) queGe Guess i esn Lee Joye UNE oi UReID -
BoURS

UR) aunssaud

94) Uy) Supe jee 3) 1YBudn Ao unG oy) sung -
“Ueupy}yS

JO YOBEY JO 1NO SSYOeEEOTE cy PUR SoJAeP GY) aIaIG -
‘sedeoee Je jQUN Yo] GU) OF JeU/E]U09 aunssaud

84) WTg ‘asodind 119 Joy (UNG oy) Woy ainsseud aseaiay -

‘Addins spe ay
dd) B{ASp O17 JOSULOISIP 'eqn) Awids AWeD GAOUAY -
“dope joiy a1 0) 968g ay
Seoudep ‘s/h JO] 418 YM Jeep eqn, Aedes AIARS o19 MOQ =
BOOM Peysyoy USy AK

Jus you aye saqny Aids 81g jeu Ueyeo Apinjosqe GYEW -
‘peAeids oq ues sooepns
‘POPSSLy 8) SZZOU aBue yA aqny Aside orn UByAA -
“(oy [speyeus drwequy [wm 8719) AAR aU) BOARS]
8|ZZ0U Puno: o1p sug 1806p) ay) eseomy 1856
ou) Bujesedep ou) Sues OLp JE OYA 4) MeupInIA AMols
pue Ajazo 19 OW] @2Z0U puncy LAYA Ogny Amids Oy eeu) -
“Meunsnipe spy LAM Pau
Oq UED |Bo}ew Lpee to) wajed Awds jeudo uy
(2) moos dojs o1p Bursn payenipe 5) yeu Moy [SHaIBWY -
‘Bujuedo egzou ay) woy senss) we Aids
Jee Heyd pus deys ysuy OL) O} 2265) eLn ssaudeq
‘Addns ae-paseaidiios oy) o unB ey peuu0y -
oz} Guns
¥O{Nb Sp Oy ejddu pue @[zzou efue cay eqm Aeids
AYARO Jo 9jzzou Aedes puro nim eqry Agids AjAEO Yosuy -
“une ay)
JO SPIRE PUN BLY O} JOURS Sy) Mauos pus yoNpold Awds
Ou) GyU) eq] uipusose ujwa Apog jajerd ely ere] -
‘Pnpaid Aesds ym (ze) seuEUCS eunssald OU Hy -

TOPS May 7 SUS SET] CUO

“Ino|wByeq Aeds oly sovcuduy Aiqeapisucs
OS/e YONA ‘Washes He-pessaidios ay oyu) peresajU!
d0ya7edes ||0 pus Ja}em 8 Aq palo aq UeD s]U)
‘Aiesseceu Apyryosqe 9) 4/8 Aup
‘UBOD '100) He-passaudi0o ay) jo UCQBUado EUAdO JOY -
‘Aesteceu y] ene pue waysis
UOANgUISp Jje-pessoud wos a1 Uy aunssaud ou WIS -
anes

“Sanu Ages pue souyopind qjeuda:dde
Olf GAUSSQO ‘S}BLaIBW |eyWeYys IM Buywep usu
“aBewep aqisyA soy una yosyD =~

“MOY G8) MOYE
yenw (be) qr Guypuecse pus (61) peey azzousy, = -
“@8N GugjeG UCQBIEdS auoo KUNG eu xOSYyy —-
POSHINAST] SES

YOSH 00¢E

son}, = Ayoede>
489 9-2 ‘Ssalg Bupoa, = eq 9 “S8alg ‘“xEW

SSMS IES SSAC

‘UaUppyO

JO UDBGU JO 1NO SayOssesoE g]] pUe SoMSp a9 BOIS

7s ABsds a/eYU) jou OG

‘suogeinBau

Ayeyes sU0M pur inieay aqeaydde 0; uucyuco yenw
PUB PeleiAUSA Ram Jn ARYBi2q 6q JenW Seale BuDOAA
“se1poq Guyno)6 owe Jo sawey oyu) Aedes joucg = -

‘eunesaud paquose.d sy} UMA AUC GAP ayy esp)
‘sai0sseoce jeuiGpyo Ajuo esy)
USPPIQIO) 6] SHAG OLp JO LORBOYPOW JO UOBeyy =~
“geda eyew 0] \sepeds ea Auo Moy = -
"@SN YOBO Guojaq BOOP ayy —-
‘asn
yay UNA ugyeq UOgoNASUy |eOnIEd aASY Oo} obuELy ==
UPOY) peujEjuoS
SUORONASU SY) MORO) AAOUNS PUR IINy Wy) YGnoy
SUO}oMU}sU] Aes pue suotoNgSsLy Bungsado otf pod
NOA | aqussod Ajuo s1 SO;WOp Oly LNA JOM Boy-peZe}Y -

APRTMNOA s

“HOBE / O08E Seqny ABids AiAeo

Wis uopoUNfucS Uy onpoid Aes AyAed Guyt|dde Jo)
Pash 4 NNO YANIWINOOS SYNSSSYd ALIAVO SUL =
Papo] se ser,

JO|S B SABY Speeiuy)
YIM SIOUIEJUOD
einsseid 10) pasn

eq Ajuo Aew un6 siyy

NNS YANIVLNOD
aYNSS3Aud ALIAVD

SNOILONULSNI ONILVYAdO

UudsH o00¢e

@:

'
i
|

JOjS B Any SPpeaty
YAY M s1aUyNUOS
aanssaid 40) pasnaq
djuo