Loading...

NHTSA ID Number: 10203905

Manufacturer Communication Number: 07-178-21

TSB/Document Date: 2021-12-03


Summary

This bulletin is being released as guidance for proper testing and charging of vehicle batteries. This bulletin will focus on those required procedures necessary to ensure the best possible outcome.


ATTENTION:
GENERAL MANAGER

q

PARTS MANAGER

q

CLAIMS PERSONNEL

q

IMPORTANT - All
Service Personnel
Should Read and
Initial in the boxes
provided, right.

SERVICE MANAGER

q

© 2021 SubarueBay logo of America, Inc. All rights reserved.

SERVICE INFORMATION BULLETIN
APPLICABILITY:
SUBJECT:

All MYs / All Models
Battery Testing and Charging

NUMBER: 07-178-21
DATE: 11/15/21

INTRODUCTION:
This Service Information bulletin is being released as guidance for proper testing and charging of
vehicle batteries. This bulletin will focus on those required procedures necessary to ensure the best
possible outcome.
This bulletin contains the following sections / topics:



Required tools and related training for effective use and application
Proper identification of battery types used by SubarueBay logo and specifics about handling each
Warnings and Cautions when testing and charging batteries using the required tools
Required battery testing and evaluation criteria and instructions.

TOOL INFORMATION:
Knowledge base sites –helpful hints, user manuals:

DSS-5000: https://subaru.dss5000.com/
Use for quick analysis of the battery condition:
a. Cranking Condition – Battery’s ability to start the vehicle
b. Reserve Capacity – Battery’s ability to power accessory loads for extended periods of time.

DCA-8000: https://subaru.dca8000.com/
Use when Recharge decisions are reached from the DSS-5000 or, in the event of a customer
complaint regarding battery performance:
a. Cranking Condition – Battery’s ability to start the vehicle
b. Reserve Capacity – Battery’s ability to power accessory loads for extended periods of time
c. DCA-8000 Decision – Dynamic Charge Acceptance – Battery’s ability to accept charge after
time spent in a discharged condition
d. Defect detection – additional fault detection for Cranking, Reserve Capacity, and other
factors reducing battery performance.
NOTE: If any issues are experienced with the DSS-5000 or DCA-8000, the Midtronics
Technical Customer Support line is available at: 866-592-8052.

CAUTION: VEHICLE SERVICING PERFORMED BY UNTRAINED PERSONS COULD
RESULT IN SERIOUS INJURY TO THOSE PERSONS OR TO OTHERS.
SubarueBay logo Service Bulletins are intended for use by professional technicians ONLY. They
are written to inform those technicians of conditions that may occur in some vehicles,
or to provide information that could assist in the proper servicing of the vehicle. Properly
trained technicians have the equipment, tools, safety instructions, and know-how to
do the job correctly and safely. If a condition is described, DO NOT assume that this
Service Bulletin applies to your vehicle, or that your vehicle will have that condition.

SubarueBay logo of America, Inc. is
ISO 14001 Compliant
ISO 14001 is the internationaleBay logo standard for
excellence in Environmental Management
Systems. Please recycle or dispose of
automotive products in a manner that is friendly
to our environment and in accordance with all
local, state and federal laws and regulations.

Continued...
Bulletin Number: 07-178-21; Date: 11/15/21

Page 1 of 11

IDENTIFYING BATTERIES:
The two battery types SubarueBay logo uses are (see example images below):

Standard flooded batteries (Flooded)

Enhanced Flooded Batteries (EFB)

VEHICLE APPLICATIONS:

EFB –Utilized on Models equipped with Stop / Start ONLY:
○ 2020-22MY Legacy and Outback
○ 2019-22MY Forester
○ 2019-22MY Ascent
○ 2017-22MY Impreza
○ 2020-22MY Crosstrek with CVT
○ 2014-16MY Crosstrek HybrideBay logo (Engine Restart Battery only) HybrideBay logo Power Control
Module (HPCM)
NOTE: 2019-22MY Ascent and 2017-22MY Impreza could have either an EFB or Flooded
battery.

Flooded –All other SubarueBay logo models and Model Years

There are additional selections of battery types supported by the Midtronics tools which are not
applicable to SubarueBay logo: (AGM, AGM Spiral, Gel). IMPORTANT: With the latest Midtronics
software update (Q2, 2021, version “G” for DCA-8000 and “M” for DSS-5000),critical battery
information (battery type and CCA) which previously populated automatically after VIN entry is now
REQUIRED to be entered accurately by the Technician.
ENHANCED FLOODED BATTERIES (EFB) KEY POINTS:
EFB batteries require different charging and testing logic:

Charging with incorrect battery type entered can damage the battery.

Testing with incorrect battery type entered can produce incorrect results.

EFB battery types currently being used:

Q85 –2019-22MY Forester, 2020-22MY Crosstrek with CVT, 2019-22MY Ascent* and
2017-22MY Impreza*

LN2 –2020-22MY Legacy and Outback

55N –2014-16MY Crosstrek HybrideBay logo

REMINDER: 2019-22MY Ascent and 2017-22MY Impreza could have either an EFB or Flooded
battery.
Standard Flooded Type
CCA will vary by application

LN2 type EFB
2020-22MY Legacy and Outback

Continued...
Bulletin Number: 07-178-21; Date: 11/15/21

Page 2 of 11

Q85 Type EFB
2019-22MY Forester and 2020-22MY Crosstrek with CVT, 2019-22MY Ascent
and 2017-22MY Impreza

WARNINGS:
• Because batteries produce flammable gases, never bring any open flame close to the batteries.

Ventilate sufficiently when using or charging batteries in an enclosed space.

Electrolyte is a highly corrosive acid and has toxicity; use gloves and ALWAYS wear eye
protection whenever handling the fluid or cleaning any deposits / residue from the battery.

For safety, in case an explosion does occur, always wear eye protection when working near any
battery. In addition, never lean over the battery.

Always prevent electrolyte from coming into contact with skin, eyes or clothing. Especially if
coming in contact with eyes, flush with water for 15 minutes and get prompt medical attention.

Always prevent electrolyte from coming contact with any coated or painted surfaces.

Before starting work, remove rings, metal watchbands or other metal jewelry.

Never let any metal tools contact the positive battery terminal and possibly ground / short out
against anything close to it.

When operations using a metal tool on the positive terminal or anything connected to it are
required, CAREFULLY disconnect the ground terminal while supporting the battery sensor
with the other hand before proceeding. IMPORTANT: Always consult the applicable Service
Manual for proper Battery Sensor servicing procedures.

Always follow the manufacturer’s instructions when handling the battery charger.

Battery Inspection:
• Check the battery case, top cover and terminals for dirt or cracks, and perform the following
work as necessary:
○ Clean the battery with water and wipe with a dry cloth.
○ Apply a thin coat of readily available battery terminal protectant on the terminals to prevent
corrosion.

If terminal posts are corroded, the terminals must be removed and cleaned.
○ It may be necessary to test the battery with both terminals removed to ensure a good test
connection with the clamps.
○ Clean with a brush and common baking soda solution.

Continued...
Bulletin Number: 07-178-21; Date: 11/15/21

Page 3 of 11

Connecting Testers/Chargers to the Battery:

Before disconnecting the battery, ensure the vehicle has been switched off with all the doors
closed for a minimum of 60 seconds.

If the battery voltage is less than 8 volts, it is required to use the SubarueBay logo Midtronics
DCA-8000 Dynamic Diagnostic Charging System.

Connecting the clamps:
○ Always confirm the clamp teeth are clean and free of corrosion.
○ Disconnect the ground terminal or CAREFULLY remove the ground cable from the battery
sensor to prevent damage to alternator diodes or other electrical components.
IMPORTANT: Always consult the applicable Service Manual for proper Battery Sensor
servicing procedures.
○ Connect the clamps directly to the battery post/terminal. Avoid connecting to the terminal
bolt/nut. NEVER connect the tester/charger ground clamp to a body or engine ground point.
Use ONLY the battery posts or terminal clamps for testing and / or charging.

○ Rock/rotate clamps to ensure a clean connection onto the battery post/terminal.
IMPORTANT: Never connect the negative clamp to a point that will position the battery
sensor between the clamp and negative battery post.
DCA-8000 Main Menu Options:

In-Vehicle Charge and Test:
○ Warranty test for use when the battery is in the vehicle or when a system test is needed.
○ NOTE: This is the only test to be used in warranty situations.

Out of Vehicle Charge:
○ Non-warranty test for use when the battery is on the bench (an in-vehicle test can also be
used on the bench as long as the VIN is entered). Performs charge and test functions.

Manual Charge:
○ Use when needing to charge a battery without running a full diagnostic test procedure.
IMPORTANT: NEVER exceed the default time of (1 hr.) or use this mode without
closely monitoring the battery.
○ Should not be used in normal situations but may be used when battery voltage is too low
to begin an “In Vehicle Charge and Test”.

Power Supply mode:
○ Use when performing any vehicle reprogramming functions.

Jump Start:
○ Use to jump-start a vehicle with a dead or deeply discharged battery.

After New Battery Install:
○ Used for testing newly-installed batteries. Also includes vehicle electronics reset
information after battery installation.

DSS-5000 Main Menu Options:

In Vehicle Test:
○ Automates battery testing for quickly testing vehicles using the fewest steps. A VIN is
required and a Warranty Code is generated for all “Replace Battery” decisions.
○ NOTE: This and the Express Test (with a VIN scan / entry) listed below are the only
test to be used in warranty situations.
Continued...

Bulletin Number: 07-178-21; Date: 11/15/21

Page 4 of 11

Out of Vehicle Test:
○ To be used for testing out-of-vehicle batteries for possible return / replacement.

After New Battery Install:
○ To be used for testing newly-installed batteries. Also includes vehicle electronics reset
information after battery installation.

12

SaleBestseller No. 1
Autel Scanner MaxiCOM MK900BT, 2026 MK900-BT V2.0 Bidirectional Diagnostic Tool, 8in Up of MK900 MX900 MK808S MK808BT MX808S MK808Z, 3000+ Active Tests, 40+ Service, CAN-FD&DOIP, All System, FCA 11 OS
  • 💯【Conta.ct us for Support Directly】If you met any...
  • 🔥🔥🔥【2026 AUTEL FLAGSHIP MK900BT MK900-BT, NEW...
  • 🚗【3000+ ACTIVE TESTS (50➡3000+), SAME AS MS...
  • 🚗【40+ HOT SERVICES FOR 150 MAKES (28+➡40+)】Full...
  • 🚗【OE ALL SYSTEM DIAGNOSE, AUTO SCAN 2.0: SCAN LICENSE...
SaleBestseller No. 2
Autel Professional OBD2 Scanner AL319 Code Reader, Enhanced Check and Reset Engine Fault Code, Live Data, Freeze Frame, CAN Car Diagnostic Scan Tools for All OBDII Vehicles After 1996, 2026 Upgraded
  • 【TURN OFF CEL】 This AL319 car scanner diagnostic tool...
  • 【EXTENSIVE APPLICATION】 Autel AL319 Compatible with...
  • 【FOR END USER & DIYERS】 This error code reader AL319 is...
  • 【USER-FRIENDLY DESIGN】 This OBD2 scanner and check...
  • 【HIGH-QUALITY SERVICES】 12 months war.ranty from the...

If the PDF is very large, it may not load in the preview below.

Download PDF [2.59 MB]


Some older TSBs had multiple PDFs — visit the NHTSA Website to view all PDFs.

If the TSB PDF does not show, download or view it on the NHTSA Website.

Click on the (+) Plus Sign

Then Click on Associated Document(s)


Search NHTSA Database for Recalls

View Latest Recalls


Search NHTSA Database for Vehicle Investigations

View Latest Vehicle Investigations


Search NHTSA Database for Vehicle Complaints

View Latest Vehicle Complaints


TSB/Document ID: 07-178-21

Replacement Service Bulletin Number:

MFR Communication Date: 2021-11-15

MFR Internal Campaign ID/Software Version:

Communication Type: Service Bulletin/Repair Instructions

NHTSA Components: EQUIPMENT

MFR Component System:

MFR Component Subsystem:


Previous TSB

Next TSB



SaleBestseller No. 1
OTOFIX D1 Lite 2026 Bidirectional Scan Tool, Bluetooth OBD2 Scanner Diagnostic Tool, 2 Years Free Update, 38+ Services, CANFD & DoIP Protocols, All System Diagnoses, ABS Bleeding, Auto VIN
  • 🎉[OTOFIX D1 Lite, Perfect Cost-effective Diagnostic Tool]: OTOFIX D1 Lite, a newest bidirectional scan tool from OTOFIX company, is a great choice for DIYers and repair shops. 👉This obd2 scanner diagnostic tool packs all practical functions: OE level all systems diagnoses, Bi-Directional Control, 38+ reset services fixing 99% of common problems, support DoIP & CANDF protocols and FCAeBay logo AutoAuth, high-end hardware configuration. Worldwide vehicles and 🔥2 Years Free Updating🔥 covered.
  • 🎉[Bi-Directional Scan Tool, Active Test]: OTOFIX D1 Lite bluetooth obd2 scanner can also command ECUs and monitor the operation of the actuators to track down the problems of certain parts, like windows, sunroof, wipers, fuel pumps, etc., saving repair time & trouble. This makes OTOFIX D1 Lite the most cost-effective bidirectional scan tool.
  • 🎉[2026 Newest, 38+ Hot Reset Functions]: Equipped with 38+ reset functions in one, the OTOFIX D1 lite automotive scanner diagnostic tool allows you to troubleshoot 99% of common vehicle problems. You can use this car diagnostic scanner holding enough functions to easily repair common vehicle models in your repair shops. Including Oil Reset, Injector Coding, Throttle, DPF Reset, SCR Reset, Gear Learning, Clutch Learning, Suspension, etc. Note* Reset functions vary by model.
  • 🎉[OE Level Full Systems Diagnostics]: Unlike the 2-system and 4-system diagnostic tools, the OTOFIX auto scan tool can complete comprehensive system diagnostics within 5 minutes. It accesses and scans all available onboard systems like for Engine /AT /ABS /EPB /BMS /TPMS /SRS /SAS /Audio System /BCM /Air Conditioning / etc., to read & clear codes, view live data, and check ECU information. Note: Active test is not involved.
  • 🎉[Powerful Hardware Configuration]: Designed with a fashion appearance & a 7” touchscreen and a weight of 463g, this OTOFIX D1 Lite OBD2 diagnostic scanner scan tool is convenient for everywhere and easy to use & store. Android9.0 OS and 2+64GB memory enhance multi-task smoothness and diagnostic operation, no more wasting too much time. 5800mAh battery allows hours-lasting use. WiFi & VCI1 also bring faster communication for your diagnostics.
SaleBestseller No. 2
OTOFIX D1 Lite Bidirectional Scan Tool with 2-Year Free Updates, 2026 New All System Automotive Diagnostic Scanner, 38+ Reset Services, FCA AutoAuth, Active Test, CANFD&DOIP, Auto VIN
  • 🏆【2026 TOP OBD2 Scanner Diagnostic Tool】OTOFIX D1 Lite wireless obd2 scanner has upgraded hardware configuration and car coverage. The newly upgraded D1 Lite with 🔥OS Android 9.0🔥1.5Ghz 4 core high efficiency processor🔥2GB RAMeBay logo+64GB ROM large storage🔥5800mAh large battery, more stable and longer lasting diagnostics🔥 38+ Reset🔥action tests🔥full system diagnostic🔥Supports MV105 endoscope🔥21+ Language Supports🔥100000+ vehicle coverage to meet all your daily maintenance needs.
  • 👍【Bi-Directional Control / Active Test】D1 Lite obd2 scanner has bidirectional control(worth $300+), which is the most beloved feature among mechanic. If your headlights or car windows are broken, going to a repair shop will cost a lot of money. You can use D1 Lite to send execution commands to the ECU module and identify the repair status. Such as ABS, car windows, doors, valves, wipers, headlights, etc., effectively shorten diagnostic time and reduce diagnostic costs.
  • 🔥【All Systems Diagnostics, In-depth Checking】This advanced OBD2 Scanner D1 Lite can perform OE-level diagnosis of all systems including engine, transmission, airbag, ABS, ESP, TPMS, gateway, steering, radio, and air conditioning for more than 100 brands. This diagnostic scanner supports essential functions, such as reading ECU version info, reading and clearing fault codes, and reading data streams.With just a simple click, it provides you with accurate and in-depth diagnostics.
  • 🏆【38+ Reset Hot Functions】For repair workshops, holding an OTOFIX D1 Lite Auto scanner is a strong advantage over others. Its 38+ maintenance functions provide various solutions for all module repairs, including Oil Reset, TPMS Reset, Injector Coding, Suspension, Throttle Matching, etc., which will usher your repair business to a new pinnacle. Continuously updating will never make the functionality & compatibility out-of-date.
  • 🏆【150+ Models, 10000+ Car Coverage & 16 Languages】D1 Lite is a comprehensive car diagnostic scan tool, help you to troubleshoot car issues fast for 95% US, European, Asian auto makes. ✅ With frequent updates and optimizations allow D1 Lite to cover more vehicles to meet your needs. ✅ Multilingual menu allows auto mechanics around the world to use it without language barriers. 🚩Note: Kindly send us the S/N of the device to authorize new language updates before changing the menu language.
SaleBestseller No. 3
OTOFIX D1 Lite 2026 Bidirectional Scan Tool, 2 Years Free Update, 38+ Services, All System Diagnostic Scanner, Active Tests, AutoAuth FCA SGW, AutoVIN, CAN FD & DoIP, 99% Car Coverage
  • 【2026 OTOFIX D1 Lite Gives the Best Value for Money】OTOFIX D1 Lite bidirectional scan tool is more FASTER and SMARTER with 2026 Enhanced Hardwares & New Functions! 👍Alternative Bluetooth +USB connect 👍2G+64GB 👍4x ARM Cortex-A35 (1.5GHz) Processor (5X Faster CPU) 👍Android 9.0 OS 👍5G GHz WiFi 👍CANFD&DOIP 👍 FCAeBay logo AutoAuth 👍38+ Services 👍3K+ Bi-Directional Control 👍Full Systems Diagnose 👍2 Years Update 👍150+ Vehicle Coverage.
  • 👍【Active Tests】 OTOFIX D1 Lite is a bi-directional scan tool that can send commands to, and also receive information from vehicle control modules. This way, you can quickly locate and repair faulty auto parts. For Example: send direct commands to ask the vehicle to turn on/off the radiator fan, lights, sound horn, fuel pump, modulate throttle, open/close windows, operate mirrors and more. *Note that only available tests will be displayed in the menu.
  • 👍【38+ Service Functions】 OTOFIX D1 Lite scan tool offers 38+ of the hottest service functions that are commonly used for car repairs. That include Oil reset/SAS/EPB/BMS/Throttle/ABS bleeding, and 2065-new SUS/ADBLUE/NOX/Headlamp resets (and more) to help restore your car status after repairs are done. Compared to other diagnostic scanners for cars, the OTOFIX D1 Lite scanner is much more fully-featured. *Note that specific functions available depend on the make/model/year of your car.
  • 👍【All System Diagnostics + Cloud Report Management】 This 2026 car scanner OTOFIX D1 Lite provides troubleshooting and data for all ECUs: read/clear DTCs, view graphic live data/VIN, and locate system faults for safe driving. With Cloud Report Management, you can save detailed reports to cloud servers and easily shared them with others via QR codes/emails/text messages. Others can access these reports from any device (smartphones/tablets/PCs …) anytime, and you can better manage repair work.
  • 👍【99% Car Coverage】 This one-station car scanner diagnostic for all cars works on 150+ major car brands across the world. 1) It supports CAN-FD/DoIP protocols: compatible with GMCAVALIER/TRAX/Encore/Envision/GL8(LSY)/CT4/CT5 after 2019; VolvoeBay logo after 2018; Land RovereBay logo/JaguareBay logo after 2017; and BM.W F/G all chassis. 2) For models equipped with security modules (such as Renault & 2018+ FCAeBay logo SGW), its built-in AutoAuth allows you to easily break diagnostic barriers after registration.

Last update on 2026-06-11 / Affiliate links / Images from Amazon Product Advertising API


 

This product presentation was made with AAWP plugin.

Share to...