Technical Service Bulletin

fh.
S-SB-0007-15 Rev1 May 13, 2015 w Scion

Floor Mat Installation During PDS

Service
Category General
Scion Supports
Section Pre-Delivery Service Market USA ASE Certification i
Applicability
YEAR(S) MODEL(S) ADDITIONAL INFORMATION
2016 FR-S, iA, iM, tC

REVISION NOTICE
February 18, 2016 Rev1:
¢ The Installation Procedure: Pre-installed Post Style section has been added.

Any previous printed versions of this bulletin should be discarded.

Introduction

2016 model year vehicles are equipped with driver’s side floor mat retaining clips to secure the floor
mat in the correct position. In addition, some models may utilize retaining clips for passenger side
floor mats as well. Follow the appropriate installation procedure to attach the driver’s side and
passenger's side (if applicable) floor mat to the vehicle carpet using the floor mat retaining clips
during Pre-Delivery Service (PDS).

CAUTION

¢ ALWAYS verify the floor mat to ensure it is designed specifically for the model and model
year it is being installed in.

ONLY use floor mats that can be retained using the retaining clips. All OEM Scion floor mats
are specifically designed to fit correctly and be retained using the retaining clips.

Make sure the floor mat is properly placed on the vehicle carpet and secured with the retaining
clips. If the driver side floor mat is NOT properly placed and secured, it could slip and interfere

with the movement of the pedals during driving and may cause an accident.

Verify the operation of the accelerator, brake, and clutch (if equipped) pedals and clearance
to the mat.

NEVER install more than one floor mat at a time in the driver’s seating position.

If applicable, any secondary set of floor mats (based upon customer preference, such as the
all weather floor mats or other floor mats) MUST be placed in the trunk with all the packaging
material intact. Do NOT install the secondary mat on top of the primary floor mat already
installed in the driver’s seating position.

© 2016 Toyota Motor Sales, USA Page 1 of 13

SSscionm S-SB-0007-15 Rev1 May 13, 2015 Page 2 of 13

Floor Mat Installation During PDS

Warranty Information

OP CODE DESCRIPTION TIME OFP T1 T2
N/A Not Applicable to Warranty - — = -

Installation Procedure: Hook Style

1. Verify that the driver and passenger side (if applicable) floor mats are for the correct model
and model year they are being installed in.

2. Attach the driver and passenger side (if applicable) floor mats to the vehicle carpet using the
retaining clips. Secure the mat by inserting the retaining clips through the grommet holes.

Figure 1.
1 Retaining Clips 3 | Correct Installation |
2 | Grommets

© 2016 Toyota Motor Sales, USA
wsSsciom S-SB-0007-15 Rev1 May 13, 2015 Page 3 of 13

Floor Mat Installation During PDS

Installation Procedure: Hook Style (Continued)

3. Verify proper installation.

NOTE

If applicable, DO NOT remove the beige “Caution” tag from the floor mat. This should only be
removed by the customer.

Figure 2.

A Caution / Precaucién / Attention / 435 A

NOTICE: THIS TAG TO BE REMOVED BY CUSTOMER ONLY.
To avoid interference with pedal operation:

= Each mat must be secured with retantion hooks (clips)

= Da not install a floor mat on top of an existing floor mat

AVISO: SOLAMENTE EL CLIENTE DEBE REMOVER ESTA ETIQUETA.
Para evitar interferencia con la operacién del pedal:

oO - Cada tapete debe sujetarse con seguros de retencién (broches}

- No instale un tapete de piso encima de un tapete de piso existente

REMARQUE ; CETTE ETIQUETTE NE PEUT ETRE ENLEVEE QUE PAR LE CLIENT,
Pour éviter des interférences avec le fonclionnement de la pédale:

+ Chaque tapis doil éire fixé a l'aide des crochets de rétention (agrafes)
- N'installez pas un taps pamdessus un tapis déja en place

wind Srant) $u8 Cpe ABU) ode & 55 Gay 1nd]
Seria! ites 5 hall GLB Cant Cane hate al iby je Guia
ale CS pe Gd Gd Bola UA SY

TFMT0001-REVT [1]

© 2016 Toyota Motor Sales, USA

oS Sscion S-SB-0007-15 Rev1 May 13, 2015 Page 4 of 13

Floor Mat Installation During PDS

Installation Procedure: Hook Style with Locking Clip

1. Verify that the driver and passenger side (if applicable) floor mats are for the correct model
and model year they are being installed in.

2. Attach the retention clip to the floor by inserting the retention clip claws into the floor eyelet.

Figure 3.
XN
1 Retention Clip 5 Cross-sectional Diagram
2 | Front of Vehicle A | Retention Clip Claw
3 Retention Clip Eyelet on Vehicle Floor B | Locking Clip
4 Seat

© 2016 Toyota Motor Sales, USA
SH Scion S-SB-0007-15 Rev1 May 13, 2015 Page 5 of 13

Floor Mat Installation During PDS

Installation Procedure: Hook Style with Locking Clip (Continued)

3. To lock the retention clip in place, insert the Figure 4.
locking clip of the retention clip into the
designated hole.

1 | Locking Clip

4. Align the floor mat holes with the retention clip Figure 5.
hooks and place the floor mat holes onto the
retention clip hooks. (1)
Oe
E>

1 Retention Clip Eyelet on Floor Mat

2 | Retention Clip

3 Front of Vehicle

© 2016 Toyota Motor Sales, USA

HSSscion S-SB-0007-15 Rev1 May 13, 2015 Page 6 of 13

Floor Mat Installation During PDS

Installation Procedure: Hook Style with Locking Clip (Continued)

5. Verify proper installation.

NOTE

If applicable, DO NOT remove the beige “Caution” tag from the floor mat. This should only be
removed by the customer.

Figure 6.

A Caution / Precaucién / Attention / i334 A

NOTICE: THIS TAG TO BE REMOVED BY CUSTOMER ONLY.
To avoid interference with pedal operation:

= Each mat must ba secured with retention hooks (clips)

+ Do not install a floor mat on top of an existing floor mat

AVISO: SOLAMENTE EL CLIENTE DEBE REMOVER ESTA ETIQUETA.
Para evitar interferencia con la operacién del pedal:
oO - Cada tapeie debe sujstarse con seguros de retencién (broches}

- No instale un tapete de piso encima de un tapete de piso exisiente

REMARQUE : CETTE ETIQUETTE NE PEUT ETRE ENLEVEE QUE PAR LE CLIENT,
Pour aviter des interlérences avec le fonclionnement de la pédale:

- Chaqua tapis doil étre fixe & l'aide des crochets de rétention (agrafes)
- N'installez pas un tapis pamdessus un tapis déja en place

wind Spaad) Sad Cpe ABU! om £35 Gay 1lled!
lead Akay Soloed) GHA CaS Gang © kell igh pe aig
Nike OS yo GA Gd hell Ud oY