equivalent). Allow bonding
agent to thoroughly dry (Figure
14).

Figure 14. Area of glass panel ‘skirt’ where bonding agent is to be
applied.

12. Using 251 201 525 packing cut 2
x 10mm x 10mm pads (Figure
15).

Figure 15. Preparing 2 – 10mm x 10mm pads of 251 201 525 packing.
13. Bond each pad to the front
areas of the sunroof glass panel
‘skirt’ as shown in figure 15. A
cut away drawing is included to
illustrate the precise positioning
of each pad from the inside
(Figure 16).

Figure 16. Positioning and application of the 10mm x 10mm pads.

Page 11 of 17
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

14. Using a 3356 roller tool (or
equivalent), apply firm pressure
(~50 Nm) to the newly adhered
pads to enhance the strength of
adhesion (Figure 17).

Figure 17. Applying pressure to bonded area with 3356 roller (or
equivalent).

Warranty
Claim Type:

 110 up to 48 Months/50,000 Miles.
 G10 for CPO Covered Vehicles – Verify Owner.
 If the vehicle is outside any warranty, this Technical Service Bulletin is
informational only.

Service Number:

 Check and/or repair or replace sunroof drain hose(s): 6048.
 Check and/or replace the roof opening seal: 6042.
 Check and/or adjust the front and / or rear sunroof glass panel: 6039.
 Perform sunroof frame modifications: 6039.

Damage Code:

0050

Page 12 of 17
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Labor Operations:

Check and, if necessary, repair or replace

Use the

See SRT with

sunroof drain hoses.

appropriate labor

associated

operation(s)

operations

consistent with
the necessary
repair
Check and, if necessary, replace the roof

Use the

See SRT with

opening seal.

appropriate labor

associated

operation(s)

operations

consistent with
the necessary
repair
Check and, if necessary, adjust the front

Use the

See SRT with

sunroof glass panel.

appropriate labor

associated

operation(s)

operations

consistent with
the necessary
repair
Check and, if necessary, adjust the rear

Use the

See SRT with

sunroof glass panel.

appropriate labor

associated

operation(s)

operations

consistent with
the necessary
repair
Check and, if necessary, replace the sunroof Use the

See SRT with

wind deflector.

appropriate labor

associated

operation(s)

operations

consistent with
the necessary
repair

Page 13 of 17
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Diagnostic Time:

Claim Comment:

Perform sunroof frame modifications.

6039 9999

50 TU

GFF

No allowance

0 TU

Road test prior to the service procedure

0121 0002

10 TU

Road test after the service procedure

0121 0004

10 TU

As per TSB #2056944/5

All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and

Procedures Manual. Claims are subject to review or audit by Audi Warranty.

Required Parts and Tools
Always check with your Parts Department and/or ETKA for the latest information and parts bulletins.
Part Number

Part Description

Quantity

D 00940104

0.2

or equivalent
surface
preparation
solvent (e.g.
isopropyl
alcohol or
adhesion
promoter).

All Purpose Cleaner

Page 14 of 17
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

D 355205A2

0.2

Bonding Agent
D 00950025

02

(or equivalent)

Primer Applicator
AKL45000505

0.1

Butyl Adhesive / Sealing Cord

Page 15 of 17
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

251201525

0.5

Packing
4M8877651

Wind Deflector

01

See ETKA

Fasteners, Bolts, Nuts, and Screws as needed per the Repair Manual

See ETKA/ELSA

Tool Number

Tool Description

3356 (or equivalent tool)

Roller Tool

Additional Information
All parts and service references provided in this TSB (2056944) are subject to change and/or removal.
©2020 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual
property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to

Page 16 of 17
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval
system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites without the prior expressed written
permission of the publisher.

Page 17 of 17
© 2020 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.