GLOBAL SAFETY FIELD INVESTIGATIONS
DCS5126
URGENT - DISTRIBUTE IMMEDIATELY
Date:

August 30, 2019

Subject: N192266090-01 Service Update
Charge Air Cooler Duct Disconnect at Throttle Body – Inventory Only
Important Parts Pre-Ship Information
Models: 2019 Chevrolet Equinox
2019 Chevrolet Malibu
2019 GMC Terrain
Equipped with 1.5L Engine (RPO LYX or LFV)
To:

All General Motors Dealers

This bulletin has been revised to include important information regarding the
pre-shipment of parts to dealers. Please discard all copies of bulletin
N192266090.
An initial supply of 13434668 required to complete this recall will be pre-shipped
to all impacted dealers of record for 100% of impacted VINs in the US. This preshipment is scheduled to begin Friday, August 30, 2019 and will be shipped as
an OVN for delivery on Saturday, August 31, 2019. All orders placed during this
pre-shipment will be cancelled. Dealers will need to file a freight claim for any
pre-shipped parts.
Additional parts, if required, are to be obtained from GMCCA, when ordering
opens. Order parts on a CSO = Customer Special Order only. DRO’s may be
cancelled. All orders may be reviewed prior to being filled. Parts may have
quantity limiters in effect.
To avoid the potential for a Dealer to receive more parts then needed, orders
received prior to the pre-ship that were written to Plant 76 (Lansing) were
cancelled where possible prior to shipment. Please refer to your Answerback for
confirmation.

END OF MESSAGE
GLOBAL SAFETY FIELD INVESTIGATIONS

Service Update
N192266090 Charge Air Cooler Duct Disconnect at Throttle Body
Release Date:
Revision Description:
Attention:

August 2019

Revision:

01

This bulletin has been revised to include important information regarding the preshipment of parts to dealers. Please discard all copies of bulletin N192226090.

This service update involves vehicles in dealer inventory only and will expire September 30, 2020.

Make
Chevrolet
Chevrolet
GMC

Model
Equinox
Malibu
Terrain

Model Year
From
To
2019
2019
2019
2019
2019
2019

RPO
LYX
LFV
LYX

Description
1.5L 4 Cyl. Engine
1.5L 4 Cyl. Engine
1.5L 4 Cyl. Engine

This service update should be performed on vehicles in dealer inventory only. Involved vehicles are marked “open” on
the Investigate Vehicle History screen in GM Global Warranty Management system. This site should always be checked
to confirm vehicle involvement prior to beginning any required inspections and/or repairs.
Condition

Correction

On certain 2019 model year Chevrolet Equinox, Malibu, and GMC Terrain vehicles, the charge air cooler
outlet may become disconnected from the throttle body. A malfunction indicator light (MIL) will set on
the instrument panel and a reduced engine power message will illuminate followed by reduced engine
power. One or more of the following diagnostic trouble codes may be present: P0172, P0299, P0101,
P1101, P0506. The vehicle may also run rough and could stall at low speed or idle conditions.
Dealers are to install a charge air cooler retainer kit.

Parts
Quantity
1

Part Name

Part No.
13434668

Retainer Chrg Air

Important: An initial supply of 13434668 required to complete this recall will be pre-shipped to all impacted dealers of
record for 100% of impacted VINs in the US and a minimum of 25% of all impacted VINs in Canada. This pre-shipment
is scheduled to begin Friday, August 30, 2019 and will be shipped as an OVN for delivery on Saturday, August 31,
2019. All orders placed during this pre-shipment will be cancelled. Dealers will need to file a freight claim for any preshipped parts.
Additional parts, if required, are to be obtained from GMCCA, when ordering opens. Order parts on a CSO = Customer
Special Order only. DRO’s may be cancelled. All orders may be reviewed prior to being filled. Parts may have quantity
limiters in effect.
Note: To avoid the potential for a Dealer to receive more parts then needed, orders received prior to the pre-ship that
were written to Plant 76 (Lansing) were cancelled where possible prior to shipment. Please refer to your Answerback
for confirmation.
Warranty Information
Labor
Operation
9104643

Description
Replace Charge Air Cooler Outlet Tube Spring/Clips
(Includes time to replace CAC Outlet Tube Seal if required)

Labor
Time
0.2

Trans.
Type
ZFAT

Net
Item
N/A

Service Procedure
1.

Disconnect the Charge Air Cooler Outlet Tube from the throttle body. Refer to Charge Air Cooler Outlet Air Tube
Replacement in SI. It is not necessary to remove the entire Charge Air Cooler Outlet Tube for this procedure, only to
disconnect it from the throttle body.

2.

Cover the throttle body with a shop towel to prevent debris from entering the engine.

Copyright 2019 General Motors. All Rights Reserved.

Page 1 of 5

Service Update
N192266090 Charge Air Cooler Hose

5400378

3.

Remove the charge air cooler outlet air tube retainer clip.

5400379

4.

While pulling back on the spring, lift the leg of the spring over the notch, removing the spring/clips from the notch they
sit in in the Charge Air Cooler Outlet Tube. Discard the spring and clips that were removed.

5.

Check the inside of the Charge Air Cooler Outlet Tube for the presence of the rubber seal that seals to the throttle
body. If the rubber seal is missing, replace the seal.

Page 2 of 5

Service Update
N192266090 Charge Air Cooler Hose

5400381

6.

Place black clip with the groove facing up on a flat, hard surface.

5400382

7.

Place the spring (legs pointing up) into the groove of the clip as shown.

8.

Press down with two fingers until you feel the spring snap into place in the clip.

9.

Repeat on the other side of the spring with the second clip.

Page 3 of 5

Service Update
N192266090 Charge Air Cooler Hose

540084

10. Insert the spring/clip assembly straight into the duct with the legs of the spring pointing down towards the elbow and
the clips facing up towards the throttle body connection.
•

The spring will catch on the notches on the sides of the part as shown in the graphic.

11. Pull the spring apart just enough to lift the leg over the notch of the duct for each side.

5400385

12. Verify the spring and clips are present and oriented correctly, as shown.
13. Remove shop towel from throttle body and install the tube. There should be an audible click when it is seated. Refer
to Charge Air Cooler Outlet Air Tube Replacement in SI if required.
Dealer Responsibility
Dealers must take the steps necessary to ensure that the service update correction has been made to all involved vehicles
in dealer inventory before selling or dealer-trading the vehicle, but no later than September 30, 2020.
All new, used, GM Certified Used, courtesy transportation vehicles, dealer shuttle vehicles, etc. in dealers' possession
and subject to this bulletin must be held and inspected/repaired per the service procedure of this bulletin before customers
Page 4 of 5

Service Update
N192266090 Charge Air Cooler Hose
take possession of these vehicles. Involved vehicles must be held and not delivered to customers, dealer-traded,
released to auction, used for demonstration, or any other purpose.
All GM Certified Used vehicles currently in the dealers’ inventory within the Certified Pre-Owned Inventory System
(CPOIS) will be de-certified and must be held and remedied per the service procedure in this bulletin. Upon submitting
an accepted/paid warranty transaction in the Global Warranty Management (GWM) system, the vehicle can be re-certified
for sale within the CPOIS system, or once again be used in the CTP program.

GM bulletins are intended for use by professional technicians, NOT a "do-it-yourselfer". They are written to inform these technicians of
conditions that may occur on some vehicles, or to provide information that could assist in the proper service of a vehicle. Properly trained
technicians have the tools, equipment, safety instructions, and know-how to do a job properly and safely. If a condition is described, DO NOT
assume that the bulletin applies to your vehicle, or that your vehicle will have that condition. See your dealer for information on whether your
vehicle may benefit from the information.

We Support
Voluntary Technician
Certification

Page 5 of 5