OWNER AND OPERATION MANUAL

1

2

3

PLEASURE-WAY INDUSTRIES LTD.
Pleasure-Way Industries Ltd. takes great pride in the quality and excellence that the PleasureWay name represents. We appreciate having you as a customer and welcome you into the
Pleasure-Way family. This manual is provided to introduce you to the many features of your
new Lexor including operation, maintenance and warranties. We strongly advise you to take
time to read this manual, the Dodge Promaster chassis owners manual as well as those of
the motorhome components before you use your new motorhome. It will help you to better
understand the many operational features of this recreational vehicle.
After reading this manual, be sure to keep it in the motorhome as a reference. Your PleasureWay dealer will be glad to answer any further questions about the operation of your motorhome
and the appliances.
All reasonable precautions have been taken in the preparation of this manual. We have been as
accurate as possible at the time of this publication. However, due to our policy of continuous
improvement and refinement to our product, Pleasure-Way reserves the right to make product
changes at any time without prior notice and without incurring obligations. As a result, PleasureWay assumes no responsibility for errors or omissions in the accuracy in the content of this
manual.
We know that you will enjoy your new Pleasure-Way and we wish you many miles of pleasant
and carefree driving. Happy Travels!

4

TABLE Of CONTENTS

Warranties and Polices

7-9

Safety

10 - 13

Motor Home Exterior
Motor Home Size
Appliances
Tire Load
LP fill Valve
Driver side Sewer Dump
Driver side Component Compartment
Driver side Water Heater Vent
Driver side Exterior shower
Driver side Fridge Vent
Passenger side Fresh water fill
Driver side Furnace Vent
Passenger side Exterior 110 volt plug
Passenger side Porch light
Passenger side Awning
Roof top solar panel
Roof top Air Conditioner
Roof top Fantastic Fan
Roof Top Winegard TV Antenna
Roof top Non Capped Sewer Vent Pipes

14-15
14
15
15
16
16
16
17
17
17
18
18
18
18
18
19
19
19
19
20

Maintaining Your Motor Home

20

Travel Preparation

21-22

Motor Home Systems
LP Gas System
LP Regulator
LP system Off/ On Switch
LP Fill/Breather and BBQ quick connect
LP Guage
LP Warning
Fresh Water System
Fresh Water Fill
City Water Connection
Water Tank and Low point Drain
Water Pump
Water Heater
Toilet
Waste System
Winterizing
Living Area Electrical System
Converter and Output Fuses

23 - 39
23
23
23
23
24
24
25
25
25
26
26
27 - 28
28
28 – 29
30 - 31
32 - 40
32

5

12 Volt Fuse Panels Auto Reset Breakers
12-Volt Battery Disconnect Switch
Switch Panels
Monitor Panel
Trouble Shooting DC/12 volt system
External AC Power
Trouble Shooting 120 volt or AC
Auxiliary Battery
Battery Care
Battery Seperator
Generator

Motor Home Interior
Interior Cockpit Map Light
Appliances
Cook Top
Furnace
Refrigerator
Water Heater
Microwave
Table
TV/DVD
Theatre System User Guide
TS Bed Assembly
Tire Safety

33
33
33 - 34
34
34
35
35- 36
37
37 – 38
38
39

40
40
40
40
41
41
42
43
43
44
44- 45
46
47 - 56

6

7



Dodge warranty package and information provided with the coach. Information in the next statement.

8

9

SAFETY
For your safety while travelling with your Pleasure-Way Motorhome, we have provided safety
components throughout the vehicle. In order for your vehicle to maintain the safest possible conditions,
these components must be tested and maintained on a regular basis, according to the detailed
manufacturer’s operating instructions.
All Pleasure-Way Motorhomes in Canada are CSA and CMVSS Certified, and may exceed the approved
installation criteria.
All Pleasure-Way Motorhomes in the United States are FMVSS certified and bear the R.V.I.A. seal of
approval, and may exceed the individual state requirements.
1) Smoke Detector (image 1)
A smoke detector is provided on the ceiling of your unit near the front. Smoke detectors may give you a
warning of fire and smoke, but only if used and maintained in accordance to the manufacturer’s
instructions.
-

This device should be tested after each time your vehicle has been in storage, before each use,
and at least once each week during your travels.

-

Do not block air circulation in the area where the smoke detector is located.

-

Ensure you connect the battery inside the detector upon receiving of your new unit. (9 volt
battery located inside the unit. )

-

Install a fully charged fresh battery at least once a year.

2) Fire Extinguisher (image 2 )
A 3-pound capacity fire extinguisher is provided and located at the side door main entrance for ease of
accessibility from the interior or exterior.
Warning: This fire extinguisher is a type “BC”, which will extinguish flammable liquids and electrical
fires, but not wood, paper and cloth fires. You should inspect the extinguisher at least once a month
according to the manufacturer’s instructions.
Image 1

Image 2

10

3) LP Gas / CO Gas Combination Detector
A liquid propane (LP) gas detector/ Carbon Monoxide (CO) is provided near the floor level at the rear of
the motorhome interior. This detector will operate to detect liquid propane & Carbon Monoxide gasses
as well as other gasses that are heavier than air. Your components that require LP gas are provided with
complete ventilation to the exterior and are sealed off to the interior for your added safety. This
detector is powered by the auxiliary battery and is operating at all times unless the battery is
disconnected or red key disconnect is turned off.
-

The LP/CO gas detector should be tested weekly while vehicle is in use.

-

Do not block air circulation in the area where the LP/CO gas detector is located.

Note: The LP/CO Gas Detector will sound to indicate a low coach battery charge.
(Driver side ottoman)

4) GFCI Outlet
A ground fault circuit interrupter (GFCI) 110-volt receptacle located on the lower Kitchen cabinet
provides protection against line-to-ground electrical shock hazards that could be harmful or even fatal.
The outlets that are on this circuit are the exterior receptacle, the galley receptacle, the kitchen rear
receptacle, outside receptacle and the fridge receptacle. These receptacles are to be tested at least
once a month in accordance with the manufacturer’s instructions.

11

Refueling
When you are refueling your gasoline tank or your propane system, ensure that your vehicle is shut off
and your main LP valve is shut off. Ensure that your pilot lights have been extinguished.
Some appliances in your vehicle have auto ignition ensure the appliances are shut off so ignition will not
activate.


Warning: Even with the main LP valve shut off there is enough gas in the LP gas in the lines for
the ignition process to take place.

Filling the LP Gas Fuel Cylinder
When you are filling the LP Gas Fuel Cylinder, the propane tank valve must be closed, all pilot lights,
appliances, along with their igniters must be turned off during refueling of motor fuel and / or the
propane fuel tank. Only qualified personnel should refuel your propane tank.
Do not refuel the propane tank to more than 80% of its capacity. Liquid will appear at the breather
valve at 80%
Do not store gasoline or other flammable liquids inside your vehicle.
NOTE: Ensure the propane system valve is fully shut when vehicle is in motion. It is not safe to travel
while propane appliances are in use. Propane switch located in the driver Utility Center.

Seat Belts
Only forward-facing seats equipped with factory installed seatbelts are to be occupied while the vehicle
is in motion. All passengers must be seated in these seats only. Seat belts must be fastened while the
vehicle is in motion.

12

Appliances
It is not safe to use cooking appliances to heat the interior of the coach due to the danger of
asphyxiation. It is recommended that you read all of the appliance owners / operating manuals prior to
using the appliances.

TV Flat Screen
When the vehicle is in motion, it is necessary to have the flat screen television locked into travel
position to prevent damage to the flat screen and to the TV cabinet.

Generator
When launching a boat or some form of watercraft with your Pleasure-Way motorhome, it is
imperative to not submerge the generator in water. Please refer to the generator owner /
operating manual for proper use and maintenance information. The generator is located behind
the rear axle.

Clearance
Your motorhome is equipped with underside holding tanks, waste tanks, plumbing lines,
propane lines and other RV related items. Please be careful when driving your motorhome on
uneven or poorly maintained roadways.
Emergency Escape
If the need to make an emergency escape from the interior of your motorhome arises, all
interior doors are equipped with interior access latches. Your choices of escape routes are as
follows, the main entrance at the side door, the driver and passenger side front doors and the
rear doors.
13

MOTORHOME EXTERIOR

Motorhome Dimensions & Capacities
Dimensions
Length Bumper to Bumper
Length bumper to Hitch Receiver
Height with AC
Width with mirrors Extended
Width at Running boards
Towing Capacity

251” - 20’ 11”
251 ¾”- 20’ 11 ¾”
111 ½”- 9’ 3 ½”
98 ½” - 8’ 2 ½”
84 ½” – 7’ ½”
2150 pounds

637.5 cm
639.4 cm
283.2 cm
250.2 cm
214.6 cm
975 kg

Bed Area: 73 “ wide X 76” Kitchen and Fridge partition to the back doors
Capacities
Fuel
Fresh Water / Potable Water
Grey Water ( Sinks and Shower)
Black Water (Toilet)
Liquid Propane (LPG) (at 80%)

Chassis Specs
GVWR
GCWR
GAWR Front
GAWR Rear
Tires (all)
Rims (all)
Tire Pressure Front
Tire Pressure Rear
Tire Pressure Spare

24 USA gallons
29.9 USA gallons
20.4 USA gallons
12 USA Gallons
5.9 USA gallons

9350 lbs
11,500 lbs
4629 lbs
5291 lbs
LT 225/75R 16 E
16 X 6.0
65 psi
80 psi
80 psi

90 litres
113.2 litres
77.2 litres
45.4 litres
22.3 litres

Weight
149.3 pounds
250 pounds
170 pounds
100.1 pounds
24.8 pounds

4242 kg
5216 kg
2100 kg
2400 kg

450 KPA
550 KPA
550 KPA

Power Train (gasoline)
3.6 litre Pentastar V6 featuring 283 HP / 260 LB-FT Torque
6 Speed transmission
159” Wheel Base
2150lbs Towing capacity
14

Appliances
Generator
Fridge 4.94 cu ft.
Convection oven
Air Conditioner
Air Conditioner Lower
Cook Top
Water Pump
Water Heater
Toilet
Furnace
Awning
Solar Panel
TV
DVD
Inverter
Converter
ATS Switch
In dash stereo/nav
Dual Coach Batteries
Roof Vent

Manufacturer
ONAN RV QG 2800
DOMETIC (3 way)
HIGH POINT
DOMETIC
DOMETIC
SMEV/DOMETIC
SHURFLO
GIRARD (instant)
Thetford Aqua Magic II
ATWOOD
Care Free
Carmanah (95 watt)
LG
LG
XANTREX
INTELLI POWER
PROGRESSIVE DYNAMICS
Pro Matser/ Dodge
Interstate
Fantastic Fan

Model
2.8HGJBB-1120A
RML8330
EC028BMR
640312CXX1CO
3310741.016
P18022
4008-101-A65
GSWH-1M
42051
AFSD16121
BY1575823TM
CTI - 95
24 LB 4510
BP340
450
PD9245C
5100
U Connect 5.0
SRM 24
2200

Pleasure-Way reserves the right to make product changes at any time without prior notice and
without incurring obligations.
NOTE: Remember that the height of your Motorhome may vary depending upon the tire
pressure level, and optional components mounted on the roof. The width of your vehicle will
vary with the position of the outside mirrors. In addition, all measurements are
approximations.
Tire and Loading Information (located on the driver door pillar)

15

Passenger Rear Propane Fill, Breather valve and Quick Connect
This fill valve and breather valve allow the on board propane tank to be filled, once fluid
appears from the breather valve the tank is filled to 80%.
The Quick connect for a BBQ is a regulated connection.

Driver’s Side Sewer Dump Compartment
Located on the driver side running board the storage compartment is just behind the driver
door entrance step. This compartment gives ease of access to the Gray and Black dump
handles, as well as the sewer connection. The sewer hose container is to the right hand side of
the black water dump handle mounted below the driver running board.

Driver’s Side Utility Center
Located in the middle of the driver main wall panel, this compartment contains four main
components used in your RV: (1) shore power hook-up; (2) cable TV hook-up; (3) pressurized
city water hook-up; (4) LP electric valve switch

16

Driver’s Side Water Heater Vent
Located on the driver’s side mid body below the fridge vents, this vent door gives access to the
water heater seasonal power switch and the working mechanisms of the water heater.
NOTE: For water heater efficiency, keep this vent free and clear from obstructions at all times.

Driver’s Side Exterior Shower Compartment
Located beside the vehicle fuel fill door, this compartment contains a retractable shower head
and hot and cold water taps.
 When winterizing your Motorhome be sure to winterize this tap and the shower hose.

Driver’s Side Fridge Vents
Located mid body on the driver side of the vehicle. These fridge vent covers house the back side
of the fridge, the fridge electrical connections and the fridge propane system. Keep these vents
free and clear from debris.

17

Passenger’s Side Fresh Water Holding Tank Fill
Located behind the passenger sliding door, this compartment allows you to fill the fresh water
holding tank. It also contains the vent tube for your fresh water holding tank.

Driver’s Side Furnace, Fresh Air and Exhaust Vent (photo 1)
Located in front of the driver rear wheel next to the water heater, this vent gives off the
exhaust of the furnace. NOTE: Ensure this vent is free and clear of obstructions at all times.

1)

2)

3)

Passenger’s Side Exterior 110-Volt Plug (see above photo 2)
Located on the passenger’s side panel behind the rear wheel, this plug will only function if
power is supplied through the generator or shore power. This plug is controlled by the GFI in
the kitchen face frame.
Passenger’s Side Exterior Porch Light (see above photo 3)
Located above the passenger sliding door, this light is controlled by the switch on the kitchen
end gable.
Passenger’s Side Power Awning
Located at the roof line of the passenger side this 12’ awning is controlled by the power switch
located on the kitchen cabinet end panel.

18

Roof top Solar Panel
Your vehicle is equipped with a 95 watt Carmanah solar panel in the center of the roof. The
solar panel is controlled by an automatic charge control system located in the driver ottoman
area.

Roof top Air Conditioner
The vehicle is equipped with the 11,000 BTU Penguin Duo-Therm low profile air conditioner.
From the ground to the top of the air conditioner it is 9’ 3 ½”. Ensure you have enough
clearance before entering areas with height limitations. The control panel for the air
conditioner is located in the rear interior of the vehicle.
Ensure all air conditioner vents are kept clear on the roof of the vehicle.