ISX15/12 CM2250 TRP for DPF Service Event

TRP Number
T1354

Revision Level
A

Page 1 of 4

Date
28-MAR-2014

Expiration Date (U.S. and Canada)
31-DEC-2014
Engine Family

Fuel System

Group Number

Expiration Date (International)
31-DEC-2014
Plant

Build Date
From

To

ISX, QSX15ISX15

Temporary Repair Practice
ISX15/12 CM2250 TRP for DPF Service Event
Attention




Worldwide distr./ branches and Div./Reg Offices
U.S / Canadian Distr./Branches and Div. Offices
U.S / Canadian Dealers

This is to revise and replace TRP 1354, dated 11-Jun-2013. This revision is to:
1. Extend the expiration date to 31-Dec-2014, and
2. Update the ESN list.
If additional information is required, contact your Cummins Warranty Operations Group
Leader.

Description
This TRP is being issued to clean/replace a Diesel Particulate Filter (DPF) on ISX15/12
CM2250 and QSX15/11.9 CM2250 engines which experience Fault Codes 3375, 3376, 1981,
or 1922. In order to qualify for this TRP, troubleshooting must have been completed and there
is not an assignable failure upstream of the DPF causing the excessive filter restriction. The
TRP may be filed one time only for an applicable ESN.

mhtml:file://C:\Users\mm656\Desktop\TSB Submissions\2014TSB\2014-03 TSB Resubmi... 9/15/2016

ISX15/12 CM2250 TRP for DPF Service Event

Page 2 of 4

This TRP is retroactive through 01-Jan-2014.

Action
In order to qualify for repair under this field action, an engine:
1. will be covered in the Base Engine Warranty period OR will be covered if the engine has
CAP aftertreatment coverage (Cummins Aftertreatment Coverage for EPA 2010 Products
(ATX,ATM)) up to 480,000 km (300,000 mi), and
2. must be on the attached ESN list, and
3. must have accumulated 320,000 km (200,000 miles) or 4500 hours with the original DPF
or since replacement of the DPF, and
4. troubleshooting of the applicable Fault Codes 3375, 3376, 1981, or 1922 must have
been completed and there is not an assignable failure upstream of the DPF causing the
excessive filter restriction, and
5. must be within the following mileage/hr range:
 For ISX15/12 CM2250 engines in the Base Warranty period, the mileage must be
within the following range: (320,000 km [200,000 miles] and 400,000 km [250,000
miles]), OR
 For ISX15/12 CM2250 engines with CAP aftertreatment Coverage, the mileage
must be within the following range: (400,000 km [250,000 miles] and 480,000 km
[300,000 miles]), OR
 For QSX15/11.9 CM2250 engines, the operating hours must be within the following
range: (4500 and 6000 hours).
After verifying that the engine meets the above requirements, perform the following actions:
1. Clean/Replace the DPF as described in the troubleshooting procedure step that was
performed in the repair within this TRP. Perform the Procedure for R&I of the
aftertreatment DPF as described in Procedure 11-041 of the appropriate Service Manual
for the ESN.

Material Disposition
Materials removed as a result of this field action must be sent to ReCon®.

Reimbursements
Parts
NOTE: If required, only 1 Diesel Particulate Filter (DPF) will be authorized per claim.
Please refer to QuickServe® Online or contact the OEM to determine the correct DPF
part number for the aftertreatment system.
NOTE: This TRP will cover up to four 2871453 gaskets if published troubleshooting is
followed and the DPF is cleaned and, in a later step, fails the restriction test. Most
repairs will only require two 2871453.

mhtml:file://C:\Users\mm656\Desktop\TSB Submissions\2014TSB\2014-03 TSB Resubmi... 9/15/2016

ISX15/12 CM2250 TRP for DPF Service Event

Page 3 of 4

NOTE: Gaskets required to perform the Snap Acceleration-Aftertreatment Disconnected
Test Procedure can be claimed if needed.
The following parts are covered under this field action:
Part Number

Quantity

Description

287145300

4

GSK,ADP

287157800RX

1

FIL,PTC

287158100RX

1

FIL,PTC

NOTE: SRTs to gain access that are required to complete the repair, that are sufficiently
explained in the claim narrative, may also be claimed on this action.
NOTE: If Troubleshooting was performed using QuickServe Online (QSOL), only 1 FCSRT for Troubleshooting will be authorized per claim. If Troubleshooting was performed
using the Expert Diagnostic System (EDS), FC SRT's do not apply and cannot be used.
Please refer to the troubleshooting SRT's provided by EDS.
NOTE: *Use for Fault Code 1981.
NOTE: **Use for Fault Code 1922.
NOTE: ***Use for Fault Codes 3375 and 3376.

Labor using applicable Access Code and Time:
SRT
Code
00-400
00-724
00-90X
11-037
11-039
11-041
11-087
14-708
FC-003
FC-012
FC-044
FC-045

Description

Time
(hrs)

Steam Clean - Single Component Repair* and ** and ***
INSITE - Use During Troubleshooting* and ** and ***
Administrative Time - Open and Close Repair Order (Shop Repairs)*
and ** and ***
Aftertreatment Diesel Particulate Filter - Remove and Install* and ** and
***
Aftertreatment Stationary Regeneration**
Aftertreatment Diesel Particulate Filter Cleaning* and **
Aftertreatment Diesel Particular Filter Restriction Test - After Cleaning*
and **
Aftertreatment Testing - Snap Acceleration Test* and **
Troubleshoot - Active Fault Codes 1981*
Troubleshoot - Active Fault Codes 1922**
Troubleshoot - Fault Code 3375 (CM2250)***
Troubleshoot - Fault Code 3376 (CM2250)***

mhtml:file://C:\Users\mm656\Desktop\TSB Submissions\2014TSB\2014-03 TSB Resubmi... 9/15/2016

ISX15/12 CM2250 TRP for DPF Service Event

Page 4 of 4

Travel
Travel is not covered under this field action. Towing is not covered under this field action.

Other Claimables
Consumables are covered under this field action.

Claim Instructions
For Cummins Dealers, claims for this TRP must be filed via RAPIDSERVE™ Web
(rsw.cummins.com). For information regarding RAPIDSERVE™ Web, please reference the
"Warranty" tab in QuickServe Online. If there are additional questions, please contact your
local Cummins Distributor.
Claim Codes
Description
Account Code:
Pay Code:
Pay Code:
Pay Code:
Failure Code:

Code
65
Distributor = X
Dealer = D
International = I
WNYPFM

Attachments
Click here to see t1354_esn-list.xls
Last Modified: 28-Mar-2014
Copyright © 2000-2010 Cummins Inc. All rights reserved.

mhtml:file://C:\Users\mm656\Desktop\TSB Submissions\2014TSB\2014-03 TSB Resubmi... 9/15/2016