NHTSA ID Number: 11027554
Manufacturer Communication Number: T-SB-0089-25
TSB/Document Date: 2026-01-09
Summary
Some 2021 – 2025 model year RAV4 Plug-in Hybrid
and RAV4 Prime vehicles may exhibit a MIL ON condition with Diagnostic Trouble Code (DTC) P019064 (Fuel Rail Pressure Sensor “A” Signal Plausibility Failure) present. The Engine Control Module (ECM) (SAE term: Powertrain Control Module/PCM) logic has been modified to address this condition.
T-SB-0089-25
December 2, 2025
MIL ON with DTC P019064
Service
Category
Engine/Hybrid System
Section
Engine Control
Market USA
Applicability
YEAR(S)
MODEL(S)
ADDITIONAL INFORMATION
2021 - 2025
RAV4 PHV, RAV4 Prime
Introduction
Some 2021 – 2025 model year RAV4 Plug-in Hybrid and RAV4 Prime vehicles may exhibit a MIL
ON condition with Diagnostic Trouble Code (DTC) P019064 (Fuel Rail Pressure Sensor “A” Signal
Plausibility Failure) present. The Engine Control Module (ECM) (SAE term: Powertrain Control
Module/PCM) logic has been modified to address this condition. Follow the Repair Procedure in
this bulletin to address this condition.
Production Change Information
This bulletin applies to vehicles produced BEFORE the Production Change Effective VINs
shown below.
MODEL YEAR
MODEL
ENGINE
PRODUCTION CHANGE EFFECTIVE VIN
JTMFB3FV#SD258665
JTMEB3FV#SD258665
2021 – 2025
RAV4 PHV,
RAV4 Prime
A25A-FXS
JTMGB3FV#SD258665
JTMAB3FV#SD258665
JTMCB3FV#SD258665
© 2025 Toyota Motor Sales, USA
Page 1 of 5
T-SB-0089-25
December 2, 2025
Page 2 of 5
MIL ON with DTC P019064
Warranty Information
OP CODE
DESCRIPTION
TIME
OFP
T1
T2
EL2519
0.7
89661-4A###*
8A
74
*Warranty claim MUST be submitted with the correct 10-digit OFP. Choose the correct OFP for the vehicle being
repaired by searching for the parts in the Electronic Parts Catalog using the VIN filter.
APPLICABLE WARRANTY
This repair is covered under the Toyota Federal Emission Warranty. This warranty is in effect
for 96 months or 80,000 miles, whichever occurs first, from the vehicle’s in-service date.
Warranty application is limited to occurrence of the specified condition described in
this bulletin.
For 2021 – 2025 model year RAV4 Prime vehicles equipped with a California Certified Emission
Control System that are registered and operated in California or any state that adopts California
emission warranty — Partial Zero Emission Vehicle (PZEV) Emission Warranty Coverage is in
effect for 15 years or 150,000 miles, from the vehicle’s in-service date, whichever occurs first.
(Please reference Warranty Policy Bulletin POL14-09, Warranty Policy 4.7, and/or the Owner’s
Warranty & Maintenance Guide for additional information.)
Parts Information
PART NUMBER
PREVIOUS
NEW
89661-4AU80
89661-4AU81
89661-4AQ01
89661-4AQ02
89661-4AT80
89661-4AT81
89661-4AF12
89661-4AF13
89661-4AU50
89661-4AU51
89661-4AU20
89661-4AU21
89661-4A873
89661-4A874
PART NAME
QTY
Computer, Engine Control
1
NOTE
The ECM (PCM) should NOT be replaced as part of the Repair Procedure.
© 2025 Toyota Motor Sales, USA
T-SB-0089-25
December 2, 2025
Page 3 of 5
MIL ON with DTC P019064
Required Tools & Equipment
SPECIAL SERVICE TOOLS (SST)
PART NUMBER
QTY
DCA-8000 Battery Diagnostic Tool*
DCA-8000P-T
1
*Essential SST.
NOTE
Additional SSTs may be ordered by calling 1-800-368-6787 or by visiting:
Home – Service Resources – Toyota Special Service Tools (SSTs).
REQUIRED EQUIPMENT
SUPPLIER
Techstream ADVi*
Techstream Lite
PART NUMBER
QTY
TSADVUNIT
ADE
Techstream Lite (Green Cable)
TSLITEPDLR01
TSLP2DLR01
*Essential SST.
NOTE
Only ONE of the Techstream units listed above is required.
GTS+ software version 2025.03.004.02 or later is required.
Additional Techstream units may be ordered by calling Approved Dealer Equipment (ADE) at
1-800-368-6787 or by visiting TIS – Diagnostics – Tools & Equipment – Techstream Order Portal.
Use Techstream or an approved J2534 interface to perform flash reprogramming updates. Visit
techinfo.toyota.com for more information regarding J2534 reprogramming
© 2025 Toyota Motor Sales, USA
1
T-SB-0089-25
December 2, 2025
Page 4 of 5
MIL ON with DTC P019064
Calibration Information
CALIBRATION ID
MODEL YEAR
MODEL
ENGINE
PREVIOUS
NEW
8966342S7300
8966342S7200
8966342S7400
8966342S7100
8966342S7000
2021 – 2025
RAV4 PHV,
RAV4 Prime
A25A-FXS
896634AS2000
896634AS2100
896634AS5000
896634AS5100
8966342Z1200
8966342Z1100
8966342Z1300
8966342Z1000
896634AR8000
896634AJ7100
896634AJ7000
896634AT1000
© 2025 Toyota Motor Sales, USA
896634AR8100
896634AJ7200
896634AT1100
T-SB-0089-25
December 2, 2025
Page 5 of 5
MIL ON with DTC P019064
Repair Procedure
1. Confirm the condition exists.
Does the vehicle exhibit a MIL ON condition with DTC P019064 (Fuel Rail
Pressure Sensor “A” Signal Plausibility Failure) present?
YES — Continue to step 2.
NO — This bulletin does NOT apply. Continue diagnosis using the applicable
Repair Manual.
2. Use GTS+ to confirm if the ECM (PCM) calibration has been updated.
Is the calibration ID listed in GTS+ the latest ECM (PCM) calibration?
YES — This bulletin does NOT apply. Continue diagnosis using the applicable
Repair Manual.
NO — Continue to step 3.
3. Flash reprogram the ECM (PCM).
NOTE
The battery diagnostic tool MUST be used in ECU Reflash Mode to maintain battery voltage
at 13.5V while flash reprogramming the vehicle.
For details on how to use the battery diagnostic station, refer to the DCA-8000 Instruction Manual
located at TIS – Diagnostics – Tools & Equipment – Battery Diagnostics.
Follow the procedures outlined in T-SB-0021-25, GTS+ ECU Flash Reprogramming
With Security Signature, and flash reprogram the ECM (PCM) with the NEW calibration
file update.
4. Using GTS+, clear ANY DTC(s) and test-drive the vehicle to confirm the condition
is no longer present.
© 2025 Toyota Motor Sales, USA
- 6X better wear protection on critical engine parts than...
- 1.3X better sludge protection than industry standards*
- 3X Stronger against viscosity breakdown than leading full...
- Protection for 10,000 miles between oil changes
- Meets or exceeds the following specifications: API SP/SN...
- Formulated for engines with 75,000 miles or more, Valvoline...
- Delivers 20% better wear protection and 15% better sludge...
- Extra detergents safeguard against friction, corrosion and...
- Advanced friction-fighting additives help maximize...
- Provides performance benefits for high mileage, new and...
Last update on 2026-06-23 / Affiliate links / Images from Amazon Product Advertising API
If the PDF is very large, it may not load in the preview below.
Some older TSBs had multiple PDFs — visit the NHTSA Website to view all PDFs.
If the TSB PDF does not show, download or view it on the NHTSA Website.
Click on the (+) Plus Sign
Then Click on Associated Document(s)
Search NHTSA Database for Recalls
Search NHTSA Database for Vehicle Investigations
View Latest Vehicle Investigations
Search NHTSA Database for Vehicle Complaints
View Latest Vehicle Complaints
TSB/Document ID: T-SB-0089-25
Replacement Service Bulletin Number:
MFR Communication Date: 2025-12-02
MFR Internal Campaign ID/Software Version: T-SB-0089-25
Communication Type: Service Bulletin/Repair Instructions
NHTSA Components: ENGINE
MFR Component System:
MFR Component Subsystem:
Previous TSB | Next TSB |
- 🎉[OTOFIX D1 Lite, Perfect Cost-effective Diagnostic Tool]: OTOFIX D1 Lite, a newest bidirectional scan tool from OTOFIX company, is a great choice for DIYers and repair shops. 👉This obd2 scanner diagnostic tool packs all practical functions: OE level all systems diagnoses, Bi-Directional Control, 38+ reset services fixing 99% of common problems, support DoIP & CANDF protocols and FCA
AutoAuth, high-end hardware configuration. Worldwide vehicles and 🔥2 Years Free Updating🔥 covered. - 🎉[Bi-Directional Scan Tool, Active Test]: OTOFIX D1 Lite bluetooth obd2 scanner can also command ECUs and monitor the operation of the actuators to track down the problems of certain parts, like windows, sunroof, wipers, fuel pumps, etc., saving repair time & trouble. This makes OTOFIX D1 Lite the most cost-effective bidirectional scan tool.
- 🎉[2026 Newest, 38+ Hot Reset Functions]: Equipped with 38+ reset functions in one, the OTOFIX D1 lite automotive scanner diagnostic tool allows you to troubleshoot 99% of common vehicle problems. You can use this car diagnostic scanner holding enough functions to easily repair common vehicle models in your repair shops. Including Oil Reset, Injector Coding, Throttle, DPF Reset, SCR Reset, Gear Learning, Clutch Learning, Suspension, etc. Note* Reset functions vary by model.
- 🎉[OE Level Full Systems Diagnostics]: Unlike the 2-system and 4-system diagnostic tools, the OTOFIX auto scan tool can complete comprehensive system diagnostics within 5 minutes. It accesses and scans all available onboard systems like for Engine /AT /ABS /EPB /BMS /TPMS /SRS /SAS /Audio System /BCM /Air Conditioning / etc., to read & clear codes, view live data, and check ECU information. Note: Active test is not involved.
- 🎉[Powerful Hardware Configuration]: Designed with a fashion appearance & a 7” touchscreen and a weight of 463g, this OTOFIX D1 Lite OBD2 diagnostic scanner scan tool is convenient for everywhere and easy to use & store. Android9.0 OS and 2+64GB memory enhance multi-task smoothness and diagnostic operation, no more wasting too much time. 5800mAh battery allows hours-lasting use. WiFi & VCI1 also bring faster communication for your diagnostics.
- 🏆【2026 TOP OBD2 Scanner Diagnostic Tool】OTOFIX D1 Lite wireless obd2 scanner has upgraded hardware configuration and car coverage. The newly upgraded D1 Lite with 🔥OS Android 9.0🔥1.5Ghz 4 core high efficiency processor🔥2GB RAM+64GB ROM large storage🔥5800mAh large battery, more stable and longer lasting diagnostics🔥 38+ Reset🔥action tests🔥full system diagnostic🔥Supports MV105 endoscope🔥21+ Language Supports🔥100000+ vehicle coverage to meet all your daily maintenance needs.
- 👍【Bi-Directional Control / Active Test】D1 Lite obd2 scanner has bidirectional control(worth $300+), which is the most beloved feature among mechanic. If your headlights or car windows are broken, going to a repair shop will cost a lot of money. You can use D1 Lite to send execution commands to the ECU module and identify the repair status. Such as ABS, car windows, doors, valves, wipers, headlights, etc., effectively shorten diagnostic time and reduce diagnostic costs.
- 🔥【All Systems Diagnostics, In-depth Checking】This advanced OBD2 Scanner D1 Lite can perform OE-level diagnosis of all systems including engine, transmission, airbag, ABS, ESP, TPMS, gateway, steering, radio, and air conditioning for more than 100 brands. This diagnostic scanner supports essential functions, such as reading ECU version info, reading and clearing fault codes, and reading data streams.With just a simple click, it provides you with accurate and in-depth diagnostics.
- 🏆【38+ Reset Hot Functions】For repair workshops, holding an OTOFIX D1 Lite Auto scanner is a strong advantage over others. Its 38+ maintenance functions provide various solutions for all module repairs, including Oil Reset, TPMS Reset, Injector Coding, Suspension, Throttle Matching, etc., which will usher your repair business to a new pinnacle. Continuously updating will never make the functionality & compatibility out-of-date.
- 🏆【150+ Models, 10000+ Car Coverage & 16 Languages】D1 Lite is a comprehensive car diagnostic scan tool, help you to troubleshoot car issues fast for 95% US, European, Asian auto makes. ✅ With frequent updates and optimizations allow D1 Lite to cover more vehicles to meet your needs. ✅ Multilingual menu allows auto mechanics around the world to use it without language barriers. 🚩Note: Kindly send us the S/N of the device to authorize new language updates before changing the menu language.
- 2026 Newest Wireless Bluetooth Scan Tool D1: OTOFIX D1 Diagnostic scanner is upgraded version with Enhanced Hardwares & Newest Functions, FASTER and SMARTER! ✅Alternative Bluetooth 5.0 +USB connect✅2G+64GB✅Android 9.0 OS✅5G & 2.4 GHz Dual WiFi✅5800mAh battery👍VAG Guided Function👍ECU Online Coding👍CANFD&DOIP👍40+ Services👍Bi-Directional Control👍Full Systems Diagnose👍2 Years Free Update👍150+ Vehicle Coverage🎁Contact to get gift: otofixaftersales-amz@ outlook.com
- ECU Coding to Unlock the Hidden Features: OTOFIX D1 obd2 scanner diagnostic tool newly adds ECU Coding which can Online Coding(ONLY for VW/Au.di/Sk0da), Variant Coding/Offline Programming, Flash Hidden Functions, Reset Adaptive Data, Match Replaced Components, Customize OE-Settings. Such as: halogen fog lamps retrofitted with xenon fog lamps, different capacity battery retrofit, disbale auto start-stop, sunroof initialization, injector calibration, etc. PS: Coding functions vary by model&year.
- Full Bidirectional Control for Active Car Tests: The D1 OTOFIX scanner also offers bi-directional control, allowing you to perform powerful active tests on car subsystems. This means that you can check the working status and functionality of open & close solenoids, energize injectors, turn cooling fan on & off, and more, all from the device itself.🚩The D1 bi-directional obd2 scanner can quickly help you to check if a system or component goes well,Improving 200% Efficiency.**Note that Active Tests available depend on the make/model/year of your car.
- 40+ Popular Maintenance Functions: OTOFIX D1 obd scanner for car performs 40+ hot services, including Oil Reset, EPB, TPMS, BMS, E.GR, G.PF, D.PF, SAS Calibration, ABS Bleeding, Injector Coding, Gearbox Match, Suspension, Crankshaft Relearn, Power Balance, etc., still growing. Great choice for DIYers, technician, repair shop. 🚩Get MORE special functions from "Car Brand>System>Service". Check compatibility before purchase via 📧 otofixaftersales-amz@ outlook.com.
- OE-Level All Systems Diagnostic + One-Click AutoVIN & AutoSCAN: OTOFIX D1 scanner automotriz gives you the ability to troubleshoot entire car systems including engion system,transmission system,body system,chassis,etc. 🚩One of the standout features of the D1 obd2 scanner diagnostic tool is the one-click AutoVIN & AutoScan function. This feature allows you to quickly and easily scan all diagnosable ECUs with just one click, and identify any problems hidden in your vehicle's systems.
Last update on 2026-06-23 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.