Technical Bulletin
Model(s)

Year

Jetta, Jetta
Wagon

2009

Golf

2010-2014

Eng. Code

Trans. Code

VIN Range From

VIN Range To

All

All

All

All

All

All

All

All

All

All

All

All

2.0L TDI
(CBEA)
2.0L TDI
(CJAA)

Jetta Sedan,
Jetta
SportWagen,
Golf Wagon

2010-2014

Beetle, Beetle
Convertible

2013-2014

2.0L TDI
(CJAA)
2.0L TDI
(CJAA)

Condition
01 14 11 April 21, 2014 2034898 Supersedes T.B. V011333 dated October 23, 2013 to include labor operation for
component exchanging between original and replacement part.
MIL ON, DTC P0401 Exhaust Gas Recirculation Flow Insufficient Stored in ECM Fault Memory, Could be
accompanied with Fault P2463 DPF Soot Accumulation

Technical Background
High soot loads prior to regeneration can cause possible restrictions in the EGR filter.

Production Solution
New software implemented in current production.

Page 1 of 5
© 2014 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Bulletin
Service
When diagnosing a vehicle with the fault P0401 perform the following:
• Remove the EGR filter from the DPF and swipe the inside of the exhaust pipe at the EGR filter connection
point using a clean cloth or your finger. See figures 1 and 2 below.

Figure 1

Figure 2

If your finger or the cloth comes out with black soot, replace the DPF & EGR filter together.
If there is no soot on your finger or the cloth, continue with GFF diagnostics, this bulletin does not apply.

Note:
When replacing the DPF for the fault P0401 it is important to replace both the DPF and the EGR filter together, as
soot accumulation in the EGR filter is undesired. It is NOT necessary to replace any other components for this
fault (i.e. NOx Storage Catalyst, Sulfur Catalyst, Exhaust Flap, EGR Cooler), these components should be
reinstalled in the vehicle with the new DPF and EGR filter.
After installing the new DPF and EGR filter, ensure that the ECM has been programmed to the latest version. The
updating of the ECM should be charged to the appropriate UPDATE or Technical Bulletin.

Page 2 of 5
© 2014 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Bulletin
Warranty
To determine if this procedure is covered under Warranty, always refer to the Warranty Policies and
1)
Procedures Manual
Model(s)

Year(s)

Eng. Code(s)

Trans. Code(s)

VIN Range From

VIN Range To

All

All

All

All

All

All

All

All

All

All

All

All

2.0L TDI

Jetta, Jetta
Wagon

2009
(CBEA)
2.0L TDI

Golf

2010-2014
(CJAA)

Jetta Sedan,
Jetta
SportWagen,
Golf Wagon

2010-2014

Beetle, Beetle
Convertible

2013-2014

2.0L TDI
(CJAA)
2.0L TDI
(CJAA)
SAGA Coding

Claim Type:

Use applicable Claim Type
Damage

Service Number:

HST

Damage Location (Depends on
Service No.)

--

Use applicable when indicated
in ElsaWeb (L/R)

Code
2674

0010

Parts Manufacturer

1)

Golf

WWO

Jetta, Jetta SportWagen, Beetle, Beetle
Convertible

3ME

2)

2)

2009 Jetta, Jetta Wagon (CBEA)
3)

26741933 = 290 TU

3)

26745581 = 30 TU

Labor Operation : Remove and Install Particle
Filter (Includes EGR Filter Replacement)
Labor Operation : Exchange components
between original and replacement Particulate
Filter

Page 3 of 5
© 2014 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Bulletin
2009 Jetta, Jetta Wagon (CJAA)
3)

26741931 = 330 TU

3)

26745581 = 30 TU

Labor Operation : Remove and Install Particle
Filter (Includes EGR Filter Replacement)
Labor Operation : Exchange components
between original and replacement Particulate
Filter

2010-2014 Golf
2010-2014 Jetta, Jetta SportWagen (CJAA)
3)

26741931 = 330 TU

3)

26745581 = 30 TU

Labor Operation : Remove and Install Particle
Filter (Includes EGR Filter Replacement)
Labor Operation : Exchange components
between original and replacement Particulate
Filter

2013-2014 Beetle (CJAA)
3)

26741933 = 330 TU

3)

26745581 = 30 TU

Labor Operation : Remove and Install Particle
Filter (Includes EGR Filter Replacement)
Labor Operation : Exchange components
between original and replacement Particulate
Filter

2013-2014 Beetle Convertible (CJAA)
3)

26741933 = 370 TU

Labor Operation : Exchange components
between original and replacement Particulate
Filter

3)

26745581 = 30 TU

Causal Part:

1K0 254 706 LX

Labor Operation : Remove and Install Particle
Filter (Includes EGR Filter Replacement)

Diagnostic Time
GFF Time expenditure

01500000 = 30 TU

Road Test

01210002 = 00 TU

4)

YES
NO

01210004 = 00 TU
Page 4 of 5
© 2014 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Bulletin
Technical Diagnosis

01320000 = 30 TU max.

YES

Claim Comment: Input “As per Technical Bulletin 2034898” in comment section of Warranty Claim.
1)

Vehicle may be outside any Warranty in which case this Technical Bulletin is informational only

2)

Code per warranty vendor code policy.

3)

Labor Time Units (TUs) are subject to change with ELSA updates.

4)

Documentation required per Warranty Policies and Procedures Manual.

Required Parts and Tools
No Special Parts required.

Tool Description

Tool No:

Midtronics Battery Tester/Charger

InCharge 940 (INC-940)

VAS Diagnostic Tool

VAS 5051B, VAS 5052A, VAS 6150/X & VAS 6160/X
with:
ODIS Service 2.0.0 or higher with current online
updates

Additional Information
All part and service references provided in this Technical Bulletin are subject to change and/or removal.
Always check with your Parts Dept. and Repair Manuals for the latest information.

Page 5 of 5
© 2014 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.