2007 FLUID CAPACITY CHART updated July 23, 2013
1

Vehicle
Touareg
US Only

Engine Oil
approx. qty.
w/filter change
4.2L (BAR)
9.1L (9.6 qt)
5.0L (BWF)
11.5L (12.1 qt)

US &
Canada

3.6L (BHK)
6.9L (7.3 qt)

Manual Trans
N/A

Automatic
2
Trans
O9D
(6 spd AWD)
Approx.
9.0L (9.5 qt)
See RM for
filling after
repairs

Differential
Automatic
3
Trans
OAA
Front Final Dr.
1.0L (1.1 qt)

Cooling
4
System

Power
5
Steering

Windshield
Washer

9.0L (9.5 qt)

Fluid Capacity
N/A

6.0L (6.3 qt)

OAD
Transfer Box
0.85L (0.9 qt)

A/C
Refrigerant R134a
Dual Zone
700+50 g
(24.7 + 1.8 oz)
Four Zone
1050 + 50g
(37 + 1.8 oz)

A/C Refrigerant
6
Oil
(See RM for oils)
Denso
Dual Zone
140cc ± 10cc
(4.7 ± .34 fl oz)
Four Zone
240cc (8.1 oz)

OAB/OAC
Rear Final Dr.
GLR
1.25L (1.3 qt)
HLV
1.6L (1.7 qt)
1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. TDI-PD: Use only oil meeting VW oil quality standard VW 504 00 / 507 00 low ash oil. Use oil viscosity
5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than
capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual
for details. Turbo engines only: After changing oil and filter, start and run engine at idle until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the
turbocharger.
2) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM
for details for refills.
3) Differential Automatic Trans: See ETKA for fluid specifics. Lifetime fill (new fill) quantity for reference only. Only replace after repair. See RM for new fill capacity - varies by
differential code/engine.
4) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12
(pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to
o
o
o
o
approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost
protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up
o
o
to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness
will be reduced.
5) Power Steering: Hydraulic oil G 002 000. Do not use ATF.
6) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 300 A2, with R-134a w/Denso compressor.
Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information.

Page 1 of 6
© 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be
reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to
other sites, without the prior expressed written permission of the publisher.

2007 FLUID CAPACITY CHART updated July 23, 2013
1

Vehicle
Eos

Engine Oil
approx. qty.
w/filter change
2.0T (BPY)
4.6L (4.9 qt)
3.2L (BUB)
5.5L (5.8 qt)

Manual Trans
2.0T (BPY)
O2Q
2.3L (2.4 qt)

2

Automatic
3
Trans
BPY/BUB
02E
New fill:
7.2L (7.6 qt)
Re-fill:
Approx:
5.2L (5.5 qt)

Differential
Automatic
Trans
With 02E
Capacity
included
w/auto
transmission

Cooling
4
System

Power
Steering

2.0 (BPY)
8.6L (9.1 qt)

Electromechanical
(no fluid)

Brake Fluid

5

1.0L (1.1 qt)

A/C
Refrigerant
R-134a
Zexel
525 + 25 g
(18.5 + 0.9 oz)

A/C Refrigerant
6
Oil
(See RM for oils)
Zexel
120 cc + 15 cc
(4.1 + 0.5 fl oz)

3.2L (BUB)
N/A

See RM for
filling after
repairs

1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause
misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn
OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle
until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger.
2) Manual Trans: 02Q: Use synthetic oil, SAE 75W90, Part No. G 052 171 A2
3) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM
for details for refills. 02E: Use G 052 182 A2.
4) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12
(pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to
o
o
o
o
approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost
protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up
o
o
to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness
will be reduced.
5) Brake Fluid: Use the NEW brake fluid VW Standard VW 501 14 Part No. B 000 750 M3.
6) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 200 A2, with R-134a w/Zexel compressor.
Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information.

Page 2 of 6
© 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be
reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to
other sites, without the prior expressed written permission of the publisher.

2007 FLUID CAPACITY CHART updated July 23, 2013
1

Vehicle
Passat
Passat
Wagon

Engine Oil
approx. qty.
w/filter change
2.0T (BPY)
4.6L (4.9 qt)
3.6L (BLV)
5.5L (5.8 qt)

Manual Trans
BPY
6 Spd FWD
02Q
2.3L (2.4 qt)

2

Automatic
3
Trans
BPY
6 Spd FWD
09G
New fill:
7.2L (7.6 qt)
Re-fill:
Approx:
5.2L (5.5 qt)

Differential
Automatic
Trans
With 09G/09M
Capacity
included
w/auto
transmission

Cooling
4
System

Power
Steering

2.0T (BPY)
7.2L (7.6 qt)

Electromechanical
(no fluid)

3.6L (BLV)
8.0L (8.5 qt)

See RM for
filling after
repairs

Brake Fluid

5

1.15L (1.2 qt)

A/C
Refrigerant
R-134a
600 +25 g
(21 + 0.9 oz)

A/C Refrigerant
6
Oil
(See RM for oils)
Sanden
110 cc + 10 cc
(4.1 + 0.5 fl oz)
Zexel
120 cc + 15 cc
(4.1 + 0.5 fl oz)

BLV
6 Spd AWD
09M
New fill:
7.0L (7.4 qt)

1) Engine Oil: Only use oils meeting VW oil quality standard: VW502 00. Use oil viscosity 5W40 or, if not available, 5W30 or 0W40. Do not overfill! Overfilling engine oil can cause
misfire DTCs to be stored in ECM (J220). To prevent overfill, add approx. 0.5L less than capacity, start engine and let run until engine operating temp is appox. 60ºC (140ºF), turn
OFF ignition, wait approx. 3 minutes, check dipstick, then fill to MAX. See Repair Manual for details. Turbo engines only: After changing oil and filter, start and run engine at idle
until oil pressure light goes out. DO NOT rev engine, this could cause damage/failure of the turbocharger.
2) Manual Trans: See ETKA for fluid specifics. Use Part No. G 052 171 A2.
3) Automatic Trans: Use VW ATF, see ETKA for fluid specifics. Lifetime filling (new fill) quantity is for reference only. Only replace after repair (i.e., when removing oil pan). See RM
for details for refills. 09G/09M: Use G 055 025 A2.
4) Cooling System: Use phosphate-free coolant G 012 A8F A4 [G12+ (purple), Valvoline G12 (purple) is really G12+). Note the following mixing combinations: G11 (green) & G12
(pink) NO; G11 & Valvoline G12 OK; G11 & G12+ OK; G12 & Valvoline G12 OK; G11 & G12 & G12+ NO; G11 & G12 & Valvoline G12 NO. Frost protection is required down to
o
o
o
o
approx. -25 C (-13 F). In countries with arctic climates, frost protection is required down to approx. -35 C (-31 F). The anti-freeze ratio must be a minimum of 40%, otherwise frost
protection is reduced. The recommended mixture ratio is 50:50. If greater frost protection is required (very cold climates), the amount of G 012 A8F A4 can be increased, but only up
o
o
to 60%. This provides frost protection to approx. -40 C (-40 F). Do not reduce the coolant concentration by adding water, even in warmer seasons/countries, as cooling effectiveness
will be reduced.
5) Brake Fluid: Use only the NEW brake fluid VW 501 14 B 000 750 (meeting spec TL 766-Z DOT4). Current brake fluid B 000 700 A must NOT be filled in the Passat brake system.
6) A/C Refrigerant Oil: Use PAG oil, Part No. G 052 154 A2 with R-134a w/Sanden compressor and G 052 200 A2 with Zexel compressor.
Note: Part Nos. are for reference only. Always check with your Parts Dept for the latest parts information.

Page 3 of 6
© 2006 Volkswagen of America, Inc. All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be
reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to
other sites, without the prior expressed written permission of the publisher.

2007 FLUID CAPACITY CHART updated July 23, 2013
1

Vehicle
Rabbit

GTI

City Golf
Canada
Only

Engine Oil
approx. qty.
w/filter change
2.5L
(BGP/BGQ)
5.5L (5.8 qt)

Manual Trans
0A4 5 Speed
1.9L (2.0 qt)

2.0T (BPY)
4.6L (4.9 qt)

02Q
6-Spd AWD
2.3L (2.4 qt)

2.0L (BEV)
4.2L (4.4 qt)

02J 5 Speed
2.0L (2.1 qt)

2

Automatic
3
Trans
09G 6 Speed