Technical Service Bulletin
01 Drive system fault OR no engine start - P019100, P008700, P008800 - 5-cyl. TFSI
01 23 65 2067757/3 July 31, 2023. Supersedes Technical Service Bulletin Group 01 number 23-32 dated January
3, 2023 for reasons listed below.
Model(s)

Year

VIN Range

Vehicle-Specific Equipment

All

Not Applicable

All

Not Applicable

2017 – 2020

RS 3

2022 – 2023

TT RS

2018 – 2022

Condition
REVISION HISTORY
Revision

Date

Purpose

3

-

Revised Condition (Updated Workshop findings)

2

01/03/2023

Revised header (Add MY23)

1

08/23/2022

Initial publication

Customer states:
• The MIL light is illuminated.
• The drive system warning lamp light is on.
• The engine does not start.
Workshop findings:
No DTCs are stored, OR one of the following DTC and symptom code combinations are stored in the Engine
Control Module, J623 (address word 0001):
• P019100: Fuel pressure sensor implausible signal with Symptom code: 5652, or with symptom 5653.
• P008700: Fuel Rail/System Pressure - Too Low with Symptom code: 2838.
• P008800: Fuel Rail/System Pressure - Too High with Symptom code: 2837, or with symptom 17897.

Technical Background
Not applicable.

Production Solution
Not applicable.

© 2023 Audi of America, Inc.

Page 1 of 3

All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Service Bulletin
Service
If Guided Fault Finding in ODIS yields no results for one of the DTC entries specified above, the test G265 –
“Intermediate Shaft Speed Sensor” must also be performed.
Please add the test manually to the test plan and work through it as specified in ODIS.
Try to reproduce the customer complaint (based on the description/cause of the issue), so that it can be clearly
assigned to this TSB. The additional test must only be carried out if all the criteria (model/type, chassis number,
engine/motor and gearbox code, PR number(s), part number, software version, code, etc.) apply exactly.
Otherwise, this additional testing will not help to eliminate the problem, and repeat testing may be necessary. In
such a case, the warranty claim may be rejected.

Warranty
Claim Type:

• 110 up to 48 Months/50,000 Miles.
• G10 for CPO Covered Vehicles – Verify Owner.
• If the vehicle is outside of any warranty, this Technical Service Bulletin is
informational only.

Service Number:

1366

Damage Code:

0010

Diagnostic Time:

GFF

0150 0000

Time stated on the
diagnostic protocol
(Max 50 TU)

Remove and install impulse sender.

2873 1930

70 TU

Road test prior to the service procedure

No allowance

0 TU

Road test after the service procedure

No allowance

0 TU

Claim Comment:
As per TSB 2067757/3
All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures
Manual. Claims are subject to review or audit by Audi Warranty.

Required Parts and Tools
Tool Number

Tool Description

VAS 6160/VAS 6150

VAS tester with the current version of ODIS
(Windows 10)

© 2023 Audi of America, Inc.

Page 2 of 3

All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Service Bulletin
Additional Information
All part and service references provided in this TSB (2067757) are subject to change and/or removal. Always
check with your Parts Department and/or ETKA for the latest information and parts bulletins. Please check the
Repair Manual for fasteners, bolts, nuts, and screws that require replacement during the repair.
©2023 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes
at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the
publisher.

© 2023 Audi of America, Inc.

Page 3 of 3

All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.