T-SB-0116-20

Rev2

December 7, 2020

Peeling Panoramic Roof Center Glass Weatherstrip
Service
Category

Vehicle Exterior

Section

Sliding Roof/Convertible

Market USA

Applicability
YEAR(S)

MODEL(S)

2018 - 2022

Camry, Camry HV

ADDITIONAL INFORMATION

REVISION NOTICE
April 13, 2022 Rev2:
 Applicability has been updated to include 2022 model year Camry and Camry Hybrid vehicles.
September 16, 2021 Rev1:
 Applicability has been updated to include 2021 model year Camry and Camry Hybrid vehicles.
Any previous printed versions of this bulletin should be discarded.

Introduction

Some 2018 – 2022 model year Camry and Camry Hybrid vehicles may exhibit the weatherstrip on
the panoramic roof center glass peeling on the edges of the glass. Follow the Repair Procedure in
this bulletin to address this condition.

Warranty Information
OP CODE

DESCRIPTION

TIME

OFP

T1

T2

BD2004

R & R Sliding Roof Weatherstrip

1.0

63251-06100

62

15

APPLICABLE WARRANTY
 This repair is covered under the Toyota Basic Warranty. This warranty is in effect for
36 months or 36,000 miles, whichever occurs first, from the vehicle’s in-service date.
 Warranty application is limited to occurrence of the specified condition described in
this bulletin.

© 2021 Toyota Motor Sales, USA

Page 1 of 5

T-SB-0116-20

Rev2

December 7, 2020

Page 2 of 5

Peeling Panoramic Roof Center Glass Weatherstrip
Parts Information
PART NUMBER

PART NAME

QTY

63251-06100

Weatherstrip, Sliding Roof

1

Required Tools & Equipment
REQUIRED TOOLS & MATERIAL

QTY

3MTM 94 Primer

1

180-grit Sandpaper

1

Isopropyl Alcohol 70%

1

Repair Procedure

1. Confirm the condition exists.
Does the vehicle exhibit the weatherstrip
on the panoramic roof center glass peeling
on the edges of the glass?


YES — Continue to step 2.



NO — This bulletin does NOT apply.
Continue diagnosis using the
applicable Repair Manual.

Figure 1.

© 2021 Toyota Motor Sales, USA

T-SB-0116-20

Rev2

December 7, 2020

Page 3 of 5

Peeling Panoramic Roof Center Glass Weatherstrip
Repair Procedure (continued)

2. Place tape on the glass near the left-hand
side AND right-hand side corners to avoid
scratching the glass (at least one-fourth the
width of the glass). The left-hand side
corner is shown; repeat the process for the
right-hand side.

Figure 2. Left-hand Side Corner

1
c

2
c

1

Place Tape Here

2

Back of the Vehicle

3. Remove the existing weatherstrip.

Figure 3.

4. Clean the rims using 180-grit sandpaper.

Figure 4.

1
c

1

© 2021 Toyota Motor Sales, USA

Rim Area

T-SB-0116-20

Rev2

December 7, 2020

Page 4 of 5

Peeling Panoramic Roof Center Glass Weatherstrip
Repair Procedure (continued)

5. Clean the rim with isopropyl alcohol until the surface is smooth and black.

6. Apply 3MTM 94 Primer and let it dry for AT LEAST 90 seconds. Make sure the shine is gone
BEFORE proceeding.
Figure 5. Wet Primer

Figure 6. Dry Primer

1
c

1

1
c

1

Rim Area

Rim Area

7. Line up the ends of the weatherstrip to the edges and make sure both ends align properly.
Figure 7.

8. Press the mechanical lock on the ridges on
both ends as shown.

Figure 8.

NOTE
The ridge is the point where the rim ends on
the inside.

© 2021 Toyota Motor Sales, USA

T-SB-0116-20

Rev2

December 7, 2020

Page 5 of 5

Peeling Panoramic Roof Center Glass Weatherstrip
Repair Procedure (continued)

9. Once the edges are secured, engage the center of the weatherstrip and continue toward the
ends. Verify the entire length of the weatherstrip is engaged in the mechanical lock.
NOTE
The entire middle area has mechanical locking to secure the weatherstrip.
Figure 9.

10. Remove the cover tape on the ends of the weatherstrip and push the ends onto the rims on
both sides. Press firmly on the rim area of the weatherstrip to ensure proper adhesion.
Hold and press firmly for five to seven seconds.
Figure 10.

Figure 11.

11. AFTER the repair is complete, allow the adhesive to cure for AT LEAST 24 hours.
NOTICE
 Allow the adhesive to cure for 24 hours.
 Do NOT wash the vehicle for 24 hours.
 Keep the vehicle away from water and rain for 24 hours.

© 2021 Toyota Motor Sales, USA