17 MIL on or noises from the crankcase breather, DTC P052E00 is stored in the ECM
17 21 16 2060033/3 May 6, 2021. Supersedes Technical Service Bulletin Group 17 number 20-10 dated August
26, 2020 for reasons listed below.
Model(s)

Year

VIN Range

Vehicle-Specific Equipment

A6

2009 - 2018

All

3.0

Q5

2013 - 2017

All

3.0

S4

2009 -2015

All

3.0

S5

2013 - 2016

All

3.0

S5 Cabriolet

2010 - 2017

All

3.0

SQ5

2014 - 2017

All

3.0

A7, A8, and
Q7

2012 - 2018

All

3.0

Condition
REVISION HISTORY
Revision

Date

Purpose

3

-

Revised Service (Updated instructions for the new repair kit)
Revised Warranty (Updated Labor Operations)
Revised Required Parts and Tools (Updated part availability)

2

08/27/2020

Revised Service (Updated Step 2)
Revised Required Parts and Tools (Updated Parts)

1

07/21/2020

Initial publication

Customer states:
 Noises from engine compartment.
Or
 MIL on.
Workshop findings:
 Noises from the crankcase breather.
The following DTC may be stored in the engine control module (ECM), J623 (address word 0001):
 DTC P052E00 (valve for crankcase ventilation, malfunction).

Page 1 of 6
© 2021 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Technical Background
Fuel additives can cause the membrane to crack.

Production Solution
Not applicable.

Service
1. Using the hand vacuum pump VAS 6213 check the membrane of the crankcase breather for leaks; a leak
can mean a faulty membrane or elbow piece (see TSB 2060259: 17 MIL on or noises from the engine
compartment, DTC P052E00 is stored in the ECM for the elbow piece repair).
2. Remove the compressor/intake manifold and check
the membrane for leaks directly on the crankcase
breather. Remove the crankcase breather and
check the two metal plates for damage (Figure 1).
If a plate is defective, please use the repair kit 06E
103 772H.

Figure 1. Metal plates.

Page 2 of 6
© 2021 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

3. Replace the membrane of the pressure regulating
valve (Figures 2-3) (Included in the repair kit 06E
103 772H).

Figure 2. Membrane example.

Page 3 of 6
© 2021 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Figure 3. Replacing the membrane.

Warranty
Claim Type:

 110 up to 48 Months/50,000 Miles.
 G10 for CPO Covered Vehicles – Verify Owner.
 If the vehicle is outside any warranty, this Technical Service Bulletin is informational
only.

Service Number:

1050

Damage Code:

0050

Labor Operations:

Remove and install compressor

2114 19XX

See SRT with
associated labor
operations

Check crankcase breather

1050 0199

20 TU

Remove and install elbow piece (only if faulty)

1050 1999

10 TU

Diagnostic Time:

Remove and install crankcase breather (only if 1050 19XX
membrane or plate is faulty)

See SRT with
associated labor
operations

Replace membrane and plate (only if faulty)

1050 5599

20 TU

GFF – Checking and clearing fault codes
included in existing labor operations

0150 0000

Time stated on
the diagnostic
protocol (Max 30
TU)

Page 4 of 6
© 2021 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Claim Comment:

Road test prior to the service procedure

No allowance

0 TU

Road test after the service procedure

No allowance

0 TU

As per TSB #2060033/3

All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures
Manual. Claims are subject to review or audit by Audi Warranty.

Required Parts and Tools
Always check with your Parts Department and/or ETKA for the latest information and parts bulletins.
Part Number

Part Description

Quantity

See ETKA

Fasteners, Bolts, Nuts, and Screws as needed per the
Repair Manual

See ETKA/ELSA

06E103772H

Pressure regulating valve repair kit with plate

01

06E103547*

Crankcase breather (vent trim in ETKA)

01

Tool Number

Tool Description

VAS 6213

Hand vacuum pump

VAS 6160/VAS 6150
(Windows 10 with current
version of ODIS)

ODIS Service with VAS tester

Additional Information
The following Technical Service Bulletin(s) will be necessary to complete this procedure:
 TSB 2060259, 17 MIL on or noises from the engine compartment, DTC P052E00 is stored in the ECM.
All parts and service references provided in this TSB (2060033) are subject to change and/or removal.
©2021 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes
at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may

Page 5 of 6
© 2021 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

these materials be modified or reposted to other sites without the prior expressed written permission of the
publisher.

Page 6 of 6
© 2021 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.