Warranty Policies and Procedures Bulletin
Audi Warranty

Number: AWA-17-12

Subject: “Extended Emissions Warranty” Limited Warranty
Extension for 3.0L TDI vehicles Gen 2.1 SUV

Date: June 18, 2018

Dealers: U.S., Puerto Rico

This document modifies the
Audi Warranty Policies and
Procedures Manual.

For Audi 3.0 L TDI Generation 2.1 SUV vehicles repaired by the emissions modification recall, the
following warranty extension is applicable.
“Extended Emissions Warranty” Limited Warranty Extension
The Limited Warranty Extension is applicable to 3.0L TDI vehicles Generation 2.1 SUV with engine code
CNRB.
Warranty Period
The warranty period for the “Extended Emissions Warranty” limited warranty extension shall be the
greater of:
1) 10 years or 120,000 miles, whichever occurs first, from the vehicle’s original in-service date; or
2) 4 years or 48,000 miles, whichever occurs first, from the date and mileage of the emissions
modification.
The vehicle's original in-service date is defined as the date the vehicle was delivered to either the original
purchaser or the original lessee; or if the vehicle was first placed in service as a "demonstrator" or
"company" car, on the date such vehicle was first placed in service.
Transferability
This limited warranty extension is fully transferable to subsequent owners.
What is Covered Under this Limited Warranty Extension
The "Extended Emissions Warranty" limited warranty extension consists of two parts, the Emission Control
System Warranty and the Engine Long Block Warranty.
Emission Control System Warranty
The emissions control system warranty covers all components that are replaced as part of the emissions
modification and any component that can reasonably be impacted by effects of the emissions modification,
including the OBD System and any malfunctions detected by the OBD systems. A detailed list of parts or
systems included in the warranty are listed in the table below.

©2018 Audi of America

Page 1 of 5

All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise; nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the publisher.

Warranty Policies and Procedures Bulletin

Engine Long Block Warranty
The engine long block warranty shall cover the engine sub-assembly that consists of the assembled block,
crankshaft, cylinder head, camshaft, and valve train. A complete list of parts included in the warranty is
provided in the table below.
What is Not Covered Under this Limited Warranty Extension
This extension will not cover:
► Any damage or malfunctions caused by installation of non-EPA or non-CARB certified emissions
related parts, including such damage or malfunction to parts needed for proper diagnosis of a covered
part.
► Damage or malfunctions caused by outside influence, such as damage due to an accident, or vehicle
misuse or neglect, but only if the damage or malfunction is causally related to the accident or vehicle
misuse.
Warranty Extension Coverage Limitations
The warranty and maintenance information that came with the owner's vehicle contains information on the
limited warranties applicable to their Audi model. Owners should read these limited warranties carefully to
determine their warranty rights and obligations, as this information also applies to the coverage provided
to them in this warranty extension.
Vehicle Eligibility
To determine if a vehicle repaired by the emissions modification recall is eligible for the “Extended
Emissions Warranty” limited warranty extension, check the VIN in ElsaPro > Vehicle Data. If the warranty
extension is applicable to the vehicle, the "Enhanced Coverage" section of the "Vehicle Data" screen in
ElsaPro will be populated with the warranty extension parameters.
Loaner Vehicle Applicability
The cost or provision of a loaner vehicle for this warranty extension is applicable for warranty service
lasting longer than 3 hours.
SAGA Warranty Claim Type
Dealers must use claim type G14 when submitting warranty claims for the “Extended Emissions Warranty”
limited warranty extension.
Important Information
For conditions that illuminate the MIL and are not listed as a Service Number or Component below, submit
the extended emissions warranty claim using Service Number S656. Ensure that a Guided Fault Finding log
showing the DTC is uploaded to GFF Paperless before the claim is submitted through SAGA. If you have any
question or doubt about whether a component is covered under this warranty, contact Audi Warranty.

©2018 Audi of America

Page 2 of 5

All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Audi of America, Inc., its affiliated companies, and its licensors. All rights are reserved to make changes at any time without notice. No part of this
document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise; nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the publisher.

Warranty Policies and Procedures Bulletin

Component Description
Long block/crankcase
Core plug

Service
Number
1009
1011

Piston

1310

Piston rings

1319

Piston pin
Connecting rod bearing (upper
& lower)

1326
1330

Component Description
Return line
Fuel pump relay (J17)

2065

Electric fuel pump
Fuel pump control module
(J538)

2066

Pedal position sender

2078

Accelerator pedal

2080
2130

Connecting rod

1340

Turbocharger

Crankshaft
Crankshaft bearing (upper &
lower)
Crankshaft oil seal, flywheel
end

1348

Crankshaft oil seal, pulley end

1374

Balance shaft

1385

Boost pressure actuator (VTG
J724) (contained within
turbocharger)
EGR connecting pipe (EGR
cooler to turbocharger)
Turbo pressure pipe (pressure
hose to turbocharger)

Balance shaft chain

1390

Camshafts

1505

Camshaft bearing

1510

Camshaft oil seal

1516

Intake valve

1560

Exhaust valve

1562

Cylinder head (cyl 1-3 & cyl 4-6)

1570

Cylinder head gasket

1571

Cylinder head fasteners

1572

Cylinder head cover

1582

Oil pressure switch
Oil level/temperature sensor
(G266)

1705

Oil pump/gasket

1720

Oil pressure regulator (N428)

1726

Oil pan (upper)

1745

Oil pan (lower)

1750

Engine coolant temp sender

1978

Fuel tank

2010

Fuel temperature sensor (G81)

2036

Supply line

2038

©2018 Audi of America

1350
1359

1711

Service
Number
2039

Pressure hose
Air pipe (left charge air cooler
to pressure hose)
Turbo pressure pipe (air pipe to
pressure hose)
Turbo pressure pipe (left
charge air cooler to charge air
tube)
Turbo pressure pipe (charge air
tube to right charge air cooler)
Turbo pressure pipe (right
charge air cooler to pressure
hose)
Turbo pressure pipe (charge air
tube to turbo pressure hose)

2070

2130
2141
2141
2141
2141
2141
2141
2141
2141
2141

Charge air cooler (left or right)

2143

Connecting pipe

2157

Turbo charge air tube

2157

Boost pressure sensor

2168

Charge air pressure & intake air
temperature sensor (G31 &
G42) (contained within boost
pressure sensor)
Turbo pressure hose (turbo
pressure hose to throttle valve)