10/5/2020

61 13 20_SERVICE ACTION: CHECKING THE DUAL STORAGE SYSTEM AND REPLACE IF NECESSARY

SIB 61 13 20
SERVICE ACTION: CHECKING THE DUAL STORAGE SYSTEM AND
REPLACE IF NECESSARY

2020-09-14

This Service Information Bulletin (Revision 1) replaces SI B61 13 20 dated April 2020.
What’s New (Specific text highlighted):
• Part number updated
Please perform the procedure outlined in this Service Information on all affected vehicles before customer
delivery. In the event the customer has already taken delivery of the vehicle, please perform the procedure
the next time the vehicle is in the shop.

MODEL
E-Series
G05
G06
G07
G12
G20
G29

Model Description
X5 Sports Activity Vehicle
X6 Sports Activity Vehicle
X7 Sports Activity Vehicle
7 Series Sedan
3 Series Sedan
Z4 Roadster

Production Date
April 10th, 2019 to August 20th, 2019

SITUATION
In the event of an accident, the two-battery Dual Storage System (DSS) is disconnected from the electrical
system via an internal relay. In some cases, the relay is stuck closed and a fault is set. In these
circumstances:

A crash shutdown of the DSS does not occur
The power distribution box is supplied with power until the DSS is fully discharged

AFFECTED VEHICLES
Vehicles which require this Service Action to be completed will show it as “Open” when checked either in
AIR, the "Service Menu" of DCSnet (Dealer Communication System) or with ISPA NEXT.

CAUSE
Failure of the DSS internal relay.

CORRECTION

Check the DSS with ISTA 4.20.x (released October 25th 2019) or higher.
Only replace the battery if it is stated to do so by the test plan.
Note: The battery replacement rate is estimated at 1%.

PROCEDURE
1. Connect a battery charger to the vehicle.
2. Perform a vehicle test using ISTA 4.20.x or higher.
3. Perform the following test plan “ETS test of lithium-ion storage”. The test plan will activate the relay 100
times and then display the results.
4. The test plan can be accessed via the following path:
Vehicle management / Service functions / Body / Voltage supply / Dual storage system ETS check

Copyright ©2020 BMW of North America, Inc.
1/3

10/5/2020

61 13 20_SERVICE ACTION: CHECKING THE DUAL STORAGE SYSTEM AND REPLACE IF NECESSARY

5. The results of the test plan will either state “ETS functional, test concluded successfully” which means
the battery is good and no further action is needed, or the “ETS functional, test failed” which means the
battery needs to be replaced.
6. If the results of the test plan state the test failed and the battery needs to be replaced, replace the DSS
as per repair instructions 61 21 004.
7. Register the replacement DSS with ISTA.
Always connect a BMW-approved battery charger/power supply (SI B04 23 10) when performing diagnosis.

PARTS INFORMATION
Only use and invoice the part numbers below that apply when applicable.
Performing a part number look-up in ETK (EPC) by VIN or model in place of using/invoicing the
applicable part number below may result with the wrong part number being invoiced and installed,
this could delay the payment of claim.
Part Number
61 21 5A078B0

Description
12-V lithium dual storage battery

Quantity
1

Additionally, other small parts that are not specified above, such as one-time use screws, nuts and seals,
which must be replaced according to the ISTA repair instructions/ETK, must be selected from the Electronic
Parts Catalogue according to the respective vehicle type and invoiced under the special defect code.

WARRANTY INFORMATION
Reimbursement for this Service Action will be via normal claim entry utilizing the applicable work package
information below and when necessary the part number listed above that applies:
Defect Code:

0061380500

G0x G1x G2x Checking and if required,
replacing dual storage

Completion before the first vehicle delivery to a customer or the vehicle is already in the workshop.
Work Pkg

Labor Operation

Description (Plus work)

Labor Allowance

#1

00 69 567

Checking 12V dual storage system (Auxiliary
battery) (No replacement is necessary)

6 FRU

Checking and replacing 12V dual storage
system (Auxiliary battery) (Including battery
change registration)

9 FRU (G20);
14 FRU (G22);
15 FRU (G07);
17 FRU (G05, G06);
18 FRU (G29);
19 FRU (G11, G12)

Or:

#2

00 69 583

And, for the:
G20 (3 Series Sedan)
Labor Operation

Description (Associated work)

Labor Allowance

00 69 584

Additional work for vehicles with the strut brace

8 FRU

Copyright ©2020 BMW of North America, Inc.
2/3

10/5/2020

61 13 20_SERVICE ACTION: CHECKING THE DUAL STORAGE SYSTEM AND REPLACE IF NECESSARY

Or:
The vehicle arrives at your center and this Service Action shows open (No other Main work will be
performed/claimed during this workshop visit)
Work Pkg

Labor Operation

Description (Main work)

Labor Allowance

#3

00 69 063

Checking 12V dual storage system (Auxiliary
battery) (No replacement is necessary)

8 FRU

Checking and replacing 12V dual storage
system (Auxiliary battery) (Including battery
change registration)

11 FRU (G20);
16 FRU (G22);
17 FRU (G07);
18 FRU (G05, G06);
20 FRU (G11, G12,
G29)

Or:

#4

00 69 079

And, for the:
G20 (3 Series Sedan)
Labor Operation

Description (Associated work)

Labor Allowance

00 69 584

Additional work for vehicles with the strut brace

8 FRU

Claim Repair Comments
Only reference the SIB number and the work package (Pkg) number performed in the RO technician notes
and in the claim comments (For example: B61 13 19 WP 1), unless otherwise required by State law.
And, as applicable:
Alternative Mobility Solution (AMS) for Vehicle Owners (RO and Claim Comments Required)
This Service Action repair qualifies for Alternative Mobility Solution (AMS) expense reimbursement, claim
this item under the Defect Code noted above as follows:

Sublet Code 2 - Itemize the AMS sublet amount on the repair order and in the claim comment
section.
Please refer to SI B01 29 16 for additional information.

Copyright ©2020 BMW of North America, Inc.
3/3