SERVICE PROCEDURE
19517
NOVEMBER 2019
SUBJECT:

EMISSIONS RECALL
Navistar has decided that a defect which relates to
engine emissions exists in certain International®
CV™ Series trucks built 03 August 2018 thru 02
August 2019 with 2019 model year International®
6.6 diesel engines

DEFECT DESCRIPTION
This Emissions Recall applies to truck models that were built with 2019 model
year International® 6.6 diesel engines. Under certain conditions, functionality of
the Exhaust Gas Temperature 5 (EGT5) and Selective Catalyst Reduction (SCR)
Conversion Efficiency Monitors may potentially result in an increase in NOx
emissions. An Engine Control Module (ECM) calibration update to correct EGT5
and Conversion Efficiency Monitors will mitigate a potential increase of NOx
emissions.

MODELS INVOLVED
This Emissions Recall involves certain International® CV™ Series trucks built 03
August 2018 thru 02 August 2019 with 2019 model year International® 6.6 diesel
engines.

ELIGIBILITY
This procedure applies ONLY to vehicles marked in the International® Service
PortalSM with Emissions Recall 19517. Also complete any other open campaigns
listed on the Service Portal at this time.

PARTS INFORMATION
There are no required parts for this campaign.

VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

1

TOOLS INFORMATION
Part Number

Tool Description
Service Programming System
(SPS) and Global Diagnostic System 2 (GDS 2)
installed
MDI 2 Kit
Battery Charger 55 Amp

Quantity

EZ-Tech® with
N/A
EL-52100
PSC550CC

1
1
1

SERVICE PROCEDURE
WARNING! To prevent personal injury and / or death, or damage to
property, park vehicle on hard flat surface, turn the engine off, set the
parking brake and install wheel chocks in front of and behind the wheels to
prevent the vehicle from moving in either direction.
WARNING! To prevent personal injury and / or death, always wear safe eye
protection when performing vehicle maintenance.
WARNING! To prevent personal injury and / or death, or damage to
property, allow engine / vehicle components to cool before servicing.
WARNING! To prevent personal injury and / or death, or damage to
property, keep flames, sparks or other heat sources away from vehicle and
do not smoke while servicing the vehicle’s batteries. Batteries expel gases
which may cause an explosion resulting in personal injury / death, or
damage to property, avoid contact with any heat sources.

1. Park vehicle on a flat surface with the wheels straight ahead.
2. Shift transmission to Park or Neutral and set parking brake.
3. Turn vehicle ignition to Key OFF position.
4. Install wheel chocks.
5. Connect battery charger / maintainer to vehicle battery.

VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

2

6. Program ECM.
NOTE: All programming and troubleshooting information can be
accessed from the articles listed in the chart below, Dealer EZ-Tech®, or
clicking the link below to access the Dealer EZ-Tech and Diagnostic
Software Support Resource Center.
Dealer EZ-Tech and Diagnostic Software Support Resource Center
NOTE: These articles contain general information about each
reprogramming method and software, with links to specific instructions.
Programming Method
SPS (Service Programming System)
7.

Programming and Troubleshooting
Instructions
4328663

If assistance is needed, contact Vehicle Programming by creating an
iKNow case file or calling 1-800-336-4500, options 3, 1, 1.

NOTE: Clear all inactive / previously active faults after programming.
Only perform diagnostics or procedures on ACTIVE faults.
8.

If any inactive / previously active faults are found after programming, clear
them from ECM. Only perform diagnostics or procedures on active faults.

9.

Remove battery charger / maintainer from vehicle battery.

10. Remove wheel chocks.

Additional Requirements for Dealers and Customers Operating in
California.
NOTE: The following step is required only for dealers and customers
operating in the state of California.
11. After completing this recall, dealer must print salmon-colored Proof of
Correction certificate on white paper, fill out certificate and provide a copy
to customer.

VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

3

Figure 1. DMV Certificate, Salmon (Print on 8.5 x 11 inch White Paper).
VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

4

END OF SERVICE PROCEDURE

LABOR INFORMATION
Operation Number

A40-19517-1

Description

Reprogram ECM

Time

0.5 hr

CAMPAIGN IDENTIFICATION LABEL
Each vehicle corrected in accordance with this
campaign must be marked with a CTS-1075
Campaign Identification Label.
Complete the label and attach on a clean surface
next to the vehicle identification number (VIN) plate.

ADMINISTRATIVE / DEALER RESPONSIBILITIES
WARRANTY CLAIMS
Warranty claim expense is to be charged to Warranty. Claims are to be
submitted in the normal manner, making reference to Safety Recall 19517.
Section 7 of the Warranty Policy and Procedures Manual contains further
information related to the submission and processing of AFC / Recall claims.
As with all claim submissions, items acquired locally must be submitted in the
“Other Charges” tab. The cost of any bulk items (such as a bag of cable tie
straps, roll of wire, barrel of oil, or tube of silicone) should be prorated for the
cost of the individual pieces / amount used during each repair.

VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

5

UNITED STATES AND POSSESSIONS
The National Traffic and Motor Vehicle Safety Act, as amended, provides that
each vehicle that is subject to a vehicle recall campaign must be adequately
repaired within a reasonable time after the owner has tendered it for repair. A
failure to adequately repair within 60 days after a tender of a vehicle is prima
facie evidence of failure to repair within a reasonable time. If the condition is not
adequately repaired within 60 days, the owner may be entitled to replacement
with an identical or reasonable equivalent vehicle at no charge, or to a refund of
the purchase price less a reasonable allowance for depreciation.
Dealers must correct all vehicles subject to this campaign at no charge to the
owner, regardless of mileage, age of vehicle, or ownership, from this time
forward.
Dealers should proceed immediately to make necessary correction to units in
inventory. All inventory vehicles subject to this recall campaign must be
corrected prior to sale, transfer or delivery. If vehicles have been sold or
transferred and you are in receipt of Customer Notification Letters and
Authorization for Recall Service cards for those vehicles, the transfer location or
customer must be notified immediately from your dealer location.
Dealers must make every effort to promptly schedule an appointment with each
owner to repair his or her vehicle as soon as possible. However, consistent with
the customer notification, dealers are expected to complete the repairs on the
mutually agreed upon service date.

VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

6

Dealers involved in the recall process will be furnished a listing of owner names
and addresses to enable them to follow up with owners and have the vehicles
corrected. Use of this listing must be limited to this campaign because the list
may contain information obtained from state motor vehicle registration records,
and the use of such motor vehicle registration data for purposes other than this
campaign is a violation of law in several states.
CANADA
Dealers must correct all vehicles subject to this campaign at no charge to the
owner, regardless of mileage, age of vehicle, or ownership, from this time
forward.
Dealers should proceed immediately to make necessary correction to units in
inventory. All inventory vehicles subject to this recall campaign must be
corrected prior to sale, transfer or delivery. If vehicles have been sold or
transferred and you are in receipt of Customer Notification Letters and
Authorization for Recall Service cards for those vehicles, the transfer location or
customer must be notified immediately from your dealer location.
Dealers must make every effort to promptly schedule an appointment with each
owner to repair his or her vehicle as soon as possible. However, consistent with
the customer notification, dealers are expected to complete the repairs on the
mutually agreed upon service date.
Dealers involved in the recall process will be furnished a listing of owner names
and addresses to enable them to follow up with owners and have the vehicles
corrected. Use of this listing must be limited to this campaign because the list
may contain information obtained from state motor vehicle registration records,
and the use of such motor vehicle registration data for purposes other than this
campaign is a violation of law in several states.
EXPORT
Export Distributors should proceed immediately to make necessary correction to
units in inventory. All inventory vehicles subject to this recall campaign must be
corrected prior to sale, transfer or delivery. If vehicles have been sold or
transferred and you are in receipt of Customer Notification Letters and
Authorization for Recall Service cards for those vehicles, the transfer location or
customer must be notified immediately from your distributor location.
Export Distributors are to submit warranty claims in the usual manner making
reference to this recall number.

VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

7

Export Distributors are expected to provide full cooperation and follow-up with
respect to this important subject matter. If you have any questions or need
further assistance, please contact the Regional Service Manager at your regional
office.

NAVISTAR, INC.

VEHICLE RECALL 19517
© 2019 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.
Public

8