91 Rearview camera intermittently inoperative, DTC 02203 is stored in the rearview camera control
module
91 19 03 2041430/7 October 22, 2019. Supersedes Technical Service Bulletin Group 91 number 19-92 dated
September 27, 2019 for reasons listed below.
Model(s)

Year

VIN Range

Vehicle-Specific Equipment

Q3

2015 - 2018

All

With rearview camera

A4

2013 - 2016

All

With rearview camera

A6, A7

2011 - 2015

All

With rearview camera

A5, A5
Cabriolet,
and Q5

2013 - 2017

All

With rearview camera

Condition
REVISION HISTORY
Revision

Date

Purpose

7

-

Revised header (Added model years)

6

09/27/2019

Revised title
Revised header (Added model years)

5

02/01/2019

Revised header (Removed A8 and Q7)

Customer states:
 The rearview camera image is not displayed on the MMI display.
Workshop findings:
The following DTC is logged in the rearview camera system control module, J772 (address word 006C):
 DTC 02203 (audio/video input 1) with one of the following fault symptoms:
 11 open circuit.
 8 implausible signal.

Technical Background
An issue with the wiring harness may cause the condition.

Page 1 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Production Solution
Not applicable.

Service
1. Before proceeding, confirm that the DTC and one of the fault symptoms listed in the Condition are logged in
the rearview camera system control module, J772 (address word 006C). If the DTC is not listed with one of
the fault symptoms, this bulletin does not apply.
2. Check the wiring of the R189 reverse camera at connector T2az and T1y (Figure 1). Repair any loose
connectors or pins, corrosion, or any other physical damage.

Figure 1. Check the wiring of the R189 reverse camera at connector T2az and T1y.

Page 2 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

If no problems are found with the wiring
or connections of the rearview camera,
continue to step 3 to replace the rearview
camera harness (Figure 2).

Figure 2. Reverse camera harness to be replaced.
3. Remove the original reverse camera from the vehicle. Follow applicable steps in the Elsa repair manual for
the specific vehicle.

Page 3 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

4. Remove the original harness from the
reverse camera (Figure 3):
 First, locate the locking tab on the
reverse camera harness.
 Next, using a small flat head
screwdriver, lift up on the locking tab.
 Finally, snap the old locking tab off the
defective harness to prevent reuse.

Figure 3. Locate locking tab (1), lift up on the tab with a
screwdriver (2), snap tab off (3).

Page 4 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

5. Carefully install the new reverse camera
harness onto the camera assembly, as
the harness can only be installed one
way. The connector is keyed on both the
camera and the electrical harness to
prevent incorrect installation. Ensure they
are correctly aligned during installation
(Figure 4).

Figure 4. When installing the new reverse camera harness onto
the camera assembly, ensure that the connectors are correctly
aligned.
6. When the harness is fully secured to the camera, there will be an audible click sound. The sound is caused
when the locking tab falls into place.
7. Reinstall the completed reverse camera
assembly, following instructions as
outlined in the Elsa repair manual for the
specific vehicle (Figure 5).

Figure 5. Completed reverse camera assembly with a new
electrical harness.

Page 5 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Warranty
Claim Type:

 110 up to 48 Months/50,000 Miles.
 G10 for CPO Covered Vehicles – Verify Owner.
 If the vehicle is outside any warranty, this Technical Service Bulletin is
informational only.

Service Number:

9143

Damage Code:

0040

Labor Operations:

All vehicles:
Central wiring harness repair

9709 41XX

See SRT

Rear trunk lid trim remove + reinstall

7087 1900

See SRT

Back-up camera remove + reinstall

9143 1950

See SRT

Back-up camera adjust

9143 1550

See SRT

Tailgate trim panel remove + reinstall

7092 1900

See SRT

Back-up camera remove + reinstall

9143 1951

See SRT

Back-up camera adjust

9143 1550

See SRT

Rear trunk lid trim remove + reinstall

7087 1900

See SRT

Back-up camera remove + reinstall

9143 1950

See SRT

Back-up camera adjust

9143 1550

See SRT

Rear trunk lid trim remove + reinstall

7087 1900

See SRT

Back-up camera remove + reinstall

9143 1950

See SRT

Back-up camera adjust

9143 1550

See SRT

A4 and A5:

allroad:

A5 Cabriolet:

A6:

A7:

Page 6 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Back-up camera remove + reinstall

9143 1900

See SRT

Back-up camera adjust

9143 1550

See SRT

Tailgate trim panel remove + reinstall

7092 1900

See SRT

Back-up camera remove + reinstall

9143 1950

See SRT

Back-up camera adjust

9143 1550

See SRT

Tailgate trim panel remove + reinstall

7092 1900

See SRT

Back-up camera remove + reinstall

9143 1950

See SRT

Back-up camera adjust

9143 1550

See SRT

GFF

0150 0000

Time stated on
the diagnostic
protocol (Max
100 TU)

Road test prior to service procedure

No allowance

0 TU

Road test after service procedure

No allowance

0 TU

Q3:

Q5:

Diagnostic Time:

Claim Comment:

As per TSB #2041430/7

All warranty claims submitted for payment must be in accordance with the Audi Warranty Policies and Procedures
Manual. Claims are subject to review or audit by Audi Warranty.

Required Parts and Tools
Always check with your Parts Department and/or ETKA for the latest information and parts bulletins.
Part Number

Part Description

Quantity

8K0971086D

Harness

01

See ETKA

Fasteners, Bolts, Nuts, and Screws as needed per the
Repair Manual

See ETKA/ELSA

Page 7 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.

Additional Information
All parts and service references provided in this TSB (2041430) are subject to change and/or removal.
©2019 Audi of America, Inc. All rights reserved. The information contained in this document is based on the
latest information available at the time of printing and is subject to the copyright and other intellectual property
rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes
at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or
transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may
these materials be modified or reposted to other sites without the prior expressed written permission of the
publisher.

Page 8 of 8
© 2019 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual property rights of Audi of
America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may be reproduced, stored in a retrieval system, or transmitted
in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the
publisher.