Page 1 of 4

192058

TECHNICAL SERVICE BULLETIN
5.0L - Excessive Oil Consumption

01 March
2019

Model:
Ford
2018 F-150
Issue: Some 2018 F-150 vehicles equipped with a 5.0L engine may exhibit excessive oil consumption
with no visible oil leaks.
Action: Follow the Service Procedure steps to correct the condition on vehicles that meet all of the
following criteria:
• 2018 F-150
• 5.0L engine
Parts
Part Number

Description

Quantity

JL3Z-6006-A

Long Block Assembly

1

JL3Z-6006-B

Long Block Assembly - Gaseous Fuel Prep Pack

1

W520113-S440

Stabilizer Bar Bracket Nuts

4

7L1Z-4B496-C

Front Driveshaft CV Joint To Pinion Flange Bolts

2

7L1Z-4B496-D

Front Driveshaft CV Joint To Transfer Case Bolts

3

W520514-S440

Catalytic Converter To Exhaust Manifold Nuts

4

W714689-S437

Torque Converter To Flex Plate Nuts

4

W716530-S440

Right Hand Engine Mount Nuts

2

JL3Z-9439-A

Intake Manifold Gasket Kit

1

JR3Z-9J323-A

High Pressure Fuel Tube

1

JR3Z-9J323-B

High Pressure Fuel Tube

1

W715211-S439

Left Hand Engine Mount Bolt

1

W713244-S439

Left Hand Engine Mount To Frame Bolts

3

Flex Plate Bolts

8

W714735-S439

Engine Mount To Cylinder Block Bolts

6

W714870-S430

Exhaust Manifold Nuts

16

FR3Z-9448-A

Exhaust Manifold Gasket

2

FT4Z-9E583-A

High Pressure Fuel Pump O-ring

1

JL3Z-6379-A

HL3Z-19B596-A A/C Compressor Line Seal Kit

1

N808684-S101

Steering Shaft Bolt

1

W718644-S439

Body Mount Bolt

6

http://www.fordservicecontent.com/Ford_Content/vdirsnet/TSB/EU/~WTSB19-2058/US/E...

4/1/2019

Page 2 of 4

W718645-S900

Body Mount Bolt

2

7L3Z-6A666-A

PCV Valve

1

AA5Z-6714-A

Oil Filter

1

XO-5W20-Q1SP Motorcraft® SAE 5W-20 Synthetic Blend Motor Oil (All Markets Except
Canada)
CXO-5W20LSP12
VC-13-G
CVC-13-G
VC-3-B
CVC-3-B2

9
9

Motorcraft® SAE 5W-20 Super Premium Motor Oil (Canada)
Motorcraft® Yellow Concentrated Antifreeze/Coolant (All Markets Except
Canada)

4

Motorcraft® Yellow Concentrated Antifreeze/Coolant (Canada Only)

4

Motorcraft® Orange Concentrated Antifreeze/Coolant (All Markets Except
Canada)

4

Motorcraft® Orange Concentrated Antifreeze/Coolant (Canada Only)

4

Warranty Status: Eligible Under Provisions Of New Vehicle Limited Warranty Coverage. Warranty/ESP
coverage limits/policies are not altered by a TSB. Warranty/ESP coverage limits are determined by the
identified causal part and verified using the OASIS part coverage tool. For repairs covered by the New
Vehicle Limited Warranty, completion of the procedure outlined in this TSB does not require obtaining
Prior Approval or completion of a Cost Cap.
Labor Times
Description

Operation
No.

Time

2018 F-150 5.0L: Visual Inspection For Oil Leaks, Replace The PCV Valve,
Change The Engine Oil And Filter, And Mark The Oil Level Stick Following The
Service Procedure Includes Time To Check And Record Engine Oil Level On
Return Visits (Do Not Use With Any Labor Operations Outside Of This Article)

DR192058A

0.8
Hrs.

2018 F-150 4X2 5.0L: Replace The Engine Long Block Assembly Includes Time
To Remove And Install Cab Assembly (Do Not Use With Any Labor Operations
Outside Of This Article)

DR192058B

11.8
Hrs.

2018 F-150 4X4 5.0L: Replace The Engine Long Block Assembly Includes Time
To Remove And Install Cab Assembly (Do Not Use With Any Labor Operations
Outside Of This Article)

DR192058C

12.3
Hrs.

Additional Time If Equipped With Cruise Control Module (CCM) (Can Be Claimed
With B Or C)

DR192058D

0.3
Hrs.

Additional Time Front End Sheet Metal Cage Nut Spun One Side (Can Be
Claimed With B Or C)

DR192058E

0.1
Hrs.

Additional Time Front End Sheet Metal Cage Nut Spun Both (2) Sides (Can Be
Claimed With B Or C)

DR192058F

0.1
Hrs.

Additional Time Body Support No. 1 Cage Nut Spun One (1) Side (Can Be
Claimed With B Or C)

DR192058G

0.6
Hrs.

Additional Time Body Support No. 1 Cage Nut Spun Both (2) Sides (Can Be
Claimed With B Or C)

DR192058H

1.1
Hrs.

Additional Time Body Support No. 2 Cage Nut Spun One (1) Side (Can Be
Claimed With B Or C)

DR192058J

0.7
Hrs.

Additional Time Body Support No. 2 Cage Nut Spun Both (2) Sides (Can Be
Claimed With B Or C)

DR192058K

1.2
Hrs.

Additional Time Body Support No. 3 Cage Nut Spun Right (Can Be Claimed With
B Or C)

DR192058L

1.1
Hrs.

http://www.fordservicecontent.com/Ford_Content/vdirsnet/TSB/EU/~WTSB19-2058/US/E...

4/1/2019

Page 3 of 4

Additional Time Body Support No. 3 Cage Nut Spun Left (Can Be Claimed With B
Or C)

DR192058M

1.2
Hrs.

Additional Time Body Support No. 3 Cage Nut Spun Both (Can Be Claimed With
B Or C)

DR192058N

1.5
Hrs.

Additional Time If Equipped To Remove Rear Inflatable Seatbelts If The No. 3
Cage Nut Spun (Can Be Claimed With B Or C)

DR192058O

0.1
Hrs.

Additional Time If Equipped To Remove Subwoofer If The No. 3 Cage Nut Spun
(Can Be Claimed With B Or C)

DR192058P

0.1
Hrs.

Additional Time If Equipped To Remove Audio Digital Signal Processing (DSP)
Module If The No. 3 Cage Nut Spun (Can Be Claimed With B Or C)

DR192058Q

0.1
Hrs.

Repair/Claim Coding
Causal Part:

6006

Condition Code: 42

Service Procedure
For repairs covered by the New Vehicle Limited Warranty, completion of the procedure outlined in
this TSB does not require obtaining Prior Approval or completion of a Cost Cap.
1. Visually inspect for engine oil leaks. Are any visible leaks present?
(1). Yes - this article does not apply. Refer to the Workshop Manual (WSM), Section 303-01D.
(2). No - proceed to Step 2.
2. Replace the positive crankcase ventilation (PCV) valve. Refer to WSM, Section 303-08D.
3. Drain the engine oil and remove the oil filter. Install a new manufacturer-specified oil filter. Make sure
the vehicle is positioned on a level surface and, using oil specified by the manufacturer, refill the oil pan
to a level 1L (1 quart) less than the specified fill level.
4. Run the engine for 3 minutes if hot or 10 minutes if cold. Allow for a minimum 15 minute drain back
period and then record the oil level shown on the oil level indicator. Place a mark on the backside of the
oil level indicator noting the oil level location.
5. Add the final 1L (1 quart) to complete the normal oil fill. Restart the engine and allow it to idle for 2
minutes. Turn off the engine.
6. After a 15 minute drain back period, record the location of the oil level. Mark the oil level indicator with
the new oil level location.
NOTE: Both marks should be very close to the MIN-MAX upper and lower limits or the upper and
lower holes on the oil level indicator. These marks will exactly measure the engine's use of oil,
with a one quart differential between the new marks.
7. Demonstrate to the customer the factory-calibrated marks on the oil level indicator are where the oil
should fall after an oil change with the specified fill amount. Explain this may vary slightly between MINMAX or the upper and lower holes on the oil level indicator.
8. Record the vehicle mileage.
9. Advise the customer that oil level indicator readings must be taken every 320 km (200 mi) or weekly,
using the revised marks as drawn. Remind the customer the engine needs a minimum 15 minute drain
back for an accurate reading and the oil level indicator must be firmly seated in the tube prior to taking
the reading.
10. When the subsequent indicator readings demonstrate a full liter (quart) has been used, record the
vehicle mileage. The mileage driven should not be less than 4,800 km (3,000 mi). The drive cycle the
vehicle has been operated under must be considered when making this calculation. It may be necessary

http://www.fordservicecontent.com/Ford_Content/vdirsnet/TSB/EU/~WTSB19-2058/US/E...

4/1/2019

Page 4 of 4

to have the customer bring the vehicle in for a periodic oil level indicator reading to closely monitor oil
usage.
11. Does the measured oil consumption exceed 4,800 km (3,000 mi) per liter (quart)?
(1). Yes - proceed to Step 12.
(2). No - vehicle is operating normally, no repairs are necessary. Repair is complete.
12. Replace the engine long block assembly. Refer to WSM, Section 303-01D.

© 2019 Ford Motor Company
All rights reserved.
NOTE: The information in Technical Service Bulletins is intended for use by trained, professional technicians with the knowledge,
tools, and equipment to do the job properly and safely. It informs these technicians of conditions that may occur on some vehicles, or
provides information that could assist in proper vehicle service. The procedures should not be performed by "do-it-yourselfers". Do
not assume that a condition described affects your car or truck. Contact a Ford or Lincoln dealership to determine whether the
Bulletin applies to your vehicle. Warranty Policy and Extended Service Plan documentation determine Warranty and/or Extended
Service Plan coverage unless stated otherwise in the TSB article. The information in this Technical Service Bulletin (TSB) was
current at the time of printing. Ford Motor Company reserves the right to supersede this information with updates. The most recent
information is available through Ford Motor Company's on-line technical resources.

http://www.fordservicecontent.com/Ford_Content/vdirsnet/TSB/EU/~WTSB19-2058/US/E...

4/1/2019