11/27/2018

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx

LT B 0 1 2 5 1 N A S 1

TECHNICAL BULLETIN
01 NOV 2018

© Jaguar Land Rover North America, LLC
NOTE: The information in Technical Bulletins is intended for use by trained, professional Technicians
with the knowledge, tools, and equipment required to do the job properly and safely. It informs these
Technicians of conditions that may occur on some vehicles, or provides information that could assist in
proper vehicle service. The procedures should not be performed by 'do-it-yourselfers'. If you are not a
Retailer, do not assume that a condition described affects your vehicle. Contact an authorized Land
Rover service facility to determine whether this bulletin applies to a specific vehicle.

I N F O R M AT I O N

SECTION:
307-02

S U B J E C T/ C O N C E R N :
Leak From Transmission Fluid Cooler Pipe(s)

AFFECTED VEHICLE RANGE:
MODEL:
Range Rover Velar (LY)

MODEL YEAR:
2018 Onwards

VIN:
700310 Onwards

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

APPLICABILITY:
INGENIUM I4 2.0L Petrol/INGENIUM I4 2.0L Diesel

1/14

11/27/2018

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx

MARKETS:
NORTH AMERICA

CONDITION SUMMARY:

SITUATION:
A transmission fluid leak may be seen coming from below the vehicle and/or the customer may
express concern of a lack of acceleration and/or a 'juddering' from the vehicle while driving with a
transmission warning message displayed on the Instrument Cluster (IC). Upon further diagnosis, the
fluid may be found leaking from the transmission fluid cooler pipe(s).
CAUSE:
This may be caused by excessive vibration transmitted through the transmission fluid cooler pipes
while the engine is running, causing the weld joints to fracture.
ACTION:
Should a customer express this concern, refer to the Service Information and then follow the
Workshop Procedure below.

PA RTS :
PART NUMBER

DESCRIPTION

QUANTITY

LR113362

Transmission fluid cooler pipes - With bracket assembly
installed - Ingenium I4 2.0L Diesel

1

LR092830

Transmission fluid cooler pipes - Ingenium I4 2.0L Petrol

1

LR124572

Bracket - Ingenium I4 2.0L Petrol

1

LR124573

Bracket clip - Ingenium I4 2.0L Petrol

1

FS108166

Bracket bolt

1

LR092703

Front driveshaft bolts

4

LR023288

Transmission fluid (1 Liter)

1

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

2/14

11/27/2018

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx

TOOLS:
Refer to Workshop Manual for any required special tools.

WARRANT Y:

NOTES:
Repair procedures are under constant review, and therefore times are subject to change;
those quoted here must be taken as guidance only. Always refer to JLR claims submission
system to obtain the latest repair time.
The JLR Claims Submission System requires the use of causal part numbers. Labor only claims
must show the causal part number with a quantity of zero.
DESCRIPTION

SRO

TIME
(HOURS)

CONDITION
CODE

CAUSAL PART

Transmission Fluid Cooler Pipes - Inspect - No
further action

05.10.50

0.5

01

LR092827 /
LR092830

Transmission Fluid Cooler Pipes - Renew

44.24.15

1.3

01

LR092827 /
LR092830

Transmission fluid level inspect - Top up if required

44.24.06

1.0

01

LR092827 /
LR092830

NOTE:
Normal Warranty procedures apply.

S E R V I C E I N F O R M AT I O N :

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

3/14

11/27/2018
1

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx



Ingenium I4 2.0L Petrol vehicles: bracket-to-bracket clip installation.

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

4/14

11/27/2018
2

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx



Ingenium I4 2.0L Diesel vehicles: the bracket from the NEW Transmission fluid cooler pipes
(LR113362) must be removed.

NOTE:
Some components are shown removed to provide extra clarity.
1

Raise and support the vehicle on a ramp (see TOPIx Workshop Manual section 100-02:
Description and Operation - Lifting).

2

NOTE:
The undershield may also be referred to as an air deflector.

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

5/14

11/27/2018

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx

Remove the engine undershield (see TOPIx Workshop Manual section 501-02: Removal and
installation - Engine Undershield).
3

Inspect the condition of the transmission fluid cooler pipes.
If the transmission fluid cooler pipes do not show signs of leaking, do not
continue with this Technical Bulletin Workshop Procedure.
Raise a Technical Assistance (TA) for further assistance if required.
If the transmission fluid cooler pipes do show signs of leaking, go to Step 4.

4

Remove the front driveshaft (See TOPIx workshop manual section 205-01: Removal and
Installation - Front Driveshaft).

5

CAUTION:
Be prepared to collect escaping fluids.



Release the transmission fluid cooler pipes.

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

6/14

11/27/2018
6

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx



Remove the bolt securing the transmission fluid cooler pipes to the oil pan.
7

CAUTION:
The transmission fluid cooler assembly must remain supported at all times.



https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

7/14

11/27/2018

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx

Release the transmission fluid cooler assembly from the front subframe.
8

CAUTION:
The transmission fluid cooler assembly must remain supported at all times.



Remove and discard the transmission fluid cooler pipes.
9

CAUTION:
The transmission fluid cooler assembly must remain supported at all times.

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

8/14

11/27/2018

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx



Install the new transmission fluid cooler pipes to the transmission fluid cooler.

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

9/14

11/27/2018
10

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx



Install the transmission fluid cooler assembly to the front subframe.
Torque: 9 Nm
11



Install the bolt securing the transmission fluid cooler pipes to the oil pan.
Torque: 11 Nm
https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

10/14

11/27/2018
12

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx



Install the transmission fluid cooler pipes.
Torque: 22 Nm
13



Bracket location for Step 14.
Ingenium I4 2.0L Petrol vehicles: go to Step 15.
https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

11/14

11/27/2018

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx

Ingenium I4 2.0L Diesel vehicles: go to Step 14.
14



Ingenium I4 2.0L Diesel vehicles: install the bracket using the following method:
1 Position the bracket clip over the transmission fluid cooler pipes.
2 Make sure the bolt hole in the bracket aligns with the threaded bolt hole in the
transmission.
3 Close the bracket clip.
4 Install the bolt.
Torque: 22 Nm

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

12/14

11/27/2018
15

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx



Ingenium I4 2.0L Petrol vehicles:install the bracket using the following method:
1 Position the bracket clip over the transmission fluid cooler pipes in the position shown.
2 Make sure the bolt hole in the bracket aligns with the threaded bolt hole in the
transmission.
3 Close the bracket clip.
4 Install the bolt.
Torque: 22 Nm
16

Install the front driveshaft (See TOPIx workshop manual section 205-01: Removal and
Installation - Front Driveshaft)

17

Inspect and top up (if required) the transmission fluid level (see TOPIx Workshop Manual
section 307-01: General Procedures - Transmission Fluid Level Inspect).

18

Install the engine undershield. (see TOPIx Workshop Manual section 501-02: Removal and
installation - Engine Undershield).

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

13/14

11/27/2018
19

LTB01251NAS1 - Leak From Transmission Fluid Cooler Pipe(s) | TOPIx

Lower the vehicle (see TOPIx Workshop Manual section 100-02: Description and Operation Lifting).

https://topix.landrover.jlrext.com/topix/content/document/view?id=938857

14/14