-Activate customers satellite radio subscription if applicable
-Connect / pair the customers Bluetooth phone if available

27

Confirm operation of audio system speakers. Check volume, balance and fade

Acceptable

Not Acceptable

28

Check and confirm operation of glove box switch and valet mode

Acceptable

Not Acceptable

29

Check operation of front / rear auxiliary power sockets and USB

Acceptable

Not Acceptable

30

Check and record any system faults registered on touch-screen

Acceptable

Not Acceptable

UNDERHOOD (check as completed)
1

Verify VIN is identical on base of windshield, shock tower and B pillar label

Acceptable

Not Acceptable

2

Check / top-up engine oil level

Acceptable

Not Acceptable

3

Check / top-up brake fluid level

Acceptable

Not Acceptable

4

Check / top-up engine coolant level

Acceptable

Not Acceptable

5

Check / top-up battery coolant level

Acceptable

Not Acceptable

6

Check / top-up electric drive coolant level

Acceptable

Not Acceptable

7

Check / top-up washer fluid

Acceptable

Not Acceptable

8

Check / top-up power steering fluid

Acceptable

Not Acceptable

9

Check headlamp alignment (refer to workshop manual, set at a 25 ft (7.6m) distance from optical center of headlamp)

Acceptable

Not Acceptable

10

Check security and routing of all harnesses, cables and hoses

Acceptable

Not Acceptable

11

Attach a print out from a 12 volt Conductance Battery Tester, e.g. Midtronics, Snap-on, OTC, etc.

Acceptable

Not Acceptable

12

Record HV battery State Of Charge and the State of Health (SOC & SOH ) using Karma Sync, report in TSS case

SOC %

SOH

C1810ASD001 ver.9

4 of 5

%

Pre-Delivery Inspection

PDI Checklist

VIN__________________________________________________________

UNDER VEHICLE (Vehicle on a two post lift, check when complete)
1

Check for fluid leaks from engine bay, and all systems under vehicle (Coolant, Fuel, Oil, etc.)

Acceptable

Not Acceptable

2

Inspect underside of vehicle for signs of damage or corrosion

Acceptable

Not Acceptable

3

Check security and routing of all harnesses, cables, hoses and brake lines to calipers

Acceptable

Not Acceptable

4

Check security of fuel system components, hoses and pipes

Acceptable

Not Acceptable

5

Check security of exhaust system, mountings and heat shields

Acceptable

Not Acceptable

6

Check security of steering and suspension components

Acceptable

Not Acceptable

7

Inspect wheel arch liners for signs of damage and wheel rub

Acceptable

Not Acceptable

8

Inspect tire condition for wear, alignment, and correct mounting for directional tires (“outside” face is marked)

Acceptable

Not Acceptable

RECORD OF TIRE IDENTIFICATION NUMBERS
Check and adjust all cold tire pressures to specification, record identification numbers.
1

Front Left

PSI

DOT

2

Front Right

PSI

DOT

3

Rear Left

PSI

DOT

4

Rear Right

PSI

DOT

ROAD TEST (check when complete)
Stealth
1

Check selection and operation of all drive modes

Sport

2

Check operation of ADAS (lane departure warning)

Acceptable

Not Acceptable

3

Check low-speed steering (parking maneuver) for excessive effort

Acceptable

Not Acceptable

4

Check alignment of steering wheel and vehicle tracking

Acceptable

Not Acceptable

5

Listen for noise / vibration / harshness / clunks

Acceptable

Not Acceptable

6

Check operation of heating and air conditioning system (both zones)

Acceptable

Not Acceptable

7

Measure and record ambient temperature (specify degrees in Celsius or Farenheit)

Sustain

8

Measure and record air temperature from out of center vents with A/C on MAX (specify °C or °F)

9

Check operation of cruise control system

Acceptable

Not Acceptable

10

Check operation of rear view camera and Park Distance Control (PDC)

Acceptable

Not Acceptable

11

Check operation of Touch Panel, Navigation and Radio system

Acceptable

12

Check for Diagnostic Trouble Codes present or pending using Karma Sync, provide to TSS.

Acceptable

13

Create a Technical Services Support (TSS) case and attach the PDI form

Acceptable

14

Record odometer on the first page of this form.

Acceptable

Not Acceptable

FINAL DELIVERY PREPARATION (check when complete 24 hours prior to customer delivery)
1

Check for open Bulletins, Service Campaigns and Recalls

Acceptable

Not Acceptable

2

Check correct vehicle literature pack is in the glove box

Acceptable

Not Acceptable

3

Verify vehicle has a fully charged HV Battery and full fuel level

Acceptable

Not Acceptable

4

Remove all internal and external transit protection

Acceptable

Not Acceptable

5

Clean the vehicle interior and exterior

Acceptable

Not Acceptable

6

Recheck tire pressures

Acceptable

Not Acceptable

Karma Automotive Technician (PRINT)________________________Signature __________________________

Date:____/____/___

Service Manager (PRINT) _________________________________Signature ___________________________

Date:____/____/___

C1810ASD001 ver.9

5 of 5