FIELD SERVICE CAMPAIGN – 16133
21 February 2017
SUBJECT:
Hose Tender Slide Bar
MODELS INVOLVED:
ProStar®
DEFECT DESCRIPTION:
Hose Tender Slide Bar on certain ProStar® 122 Daycab models may contact the
exhaust shield when the cab air bag is deflated; this could result in damage to the
exhaust shield.
ELIGIBILITY:
This procedure applies ONLY to vehicles marked in the International® Service PortalSM
with FSC 16133. Also complete any other open campaigns listed on the Service Portal
at this time.
TOOLS REQUIRED:
No special tools are required for this procedure.
PARTS REQUIRED:
Part Number
Description
2517346C1
Support, Slide Bar
Table 1 Parts Information

Quantity
1

WORK INSTRUCTIONS
WARNING! To prevent property damage, personal injury, and / or death, park
vehicle on hard flat surface, turn the engine off, set the parking brake, and install
wheel chocks to prevent the vehicle from moving in both directions.
WARNING! To prevent personal injury and / or death, always wear safe eye
protection when performing vehicle maintenance.
WARNING! To prevent property damage, personal injury, and / or death, keep
flames or sparks away from vehicle and do not smoke while servicing the
vehicle’s batteries. Batteries expel explosive gases.

© 2017 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.

Page 1

1. Park vehicle on flat surface.
2. Shift transmission to Park or Neutral and set parking brakes.
3. Install wheel chocks.

Figure 1. Hose Tender Slide Bar
1. Slide bar

4. Access slide bar (Figure 1, Item 1) on rear of vehicle.
5. Remove air line from air line support springs.
6. Remove slide bar.
7. Transfer air line support springs to new slide bar.
8. Install new slide bar. Using a torque wrench, tighten bolts to 9 - 11 lb-ft (12 - 14.9
N∙m).
9. Reattach air lines to springs.
10. Remove wheel chocks.

© 2017 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.

Page 2

LABOR INFORMATION
Operation number must appear on all claims.

Table 2 Labor Information
Operation Number
A40-16133-1

Description

Time

Replace Hose Tender Slide Bar

0.4 hr

WARRANTY CLAIMS

Warranty claim expense is to be charged to Warranty. Claims are to be submitted in the
normal manner, making reference to Field Service Campaign 16133.
Section 7 of the Warranty Policy and Procedures Manual contains further information
related to the submission and processing of AFC / Recall claims.
As with all claim submissions, items acquired locally must be submitted in the “Other
Charges” tab. The cost of any bulk items (such as a bag of cable tie straps, roll of wire,
barrel of oil, or tube of silicone) should be prorated for the cost of the individual pieces /
amount used during each repair.
To make sure this important improvement is made in a timely manner, all claims for
16133 activity must be submitted by 21 February 2018 or within the normal warranty
period for the component, if after 21 February 2018.

© 2017 Navistar, Inc. All rights reserved. All marks are trademarks of their respective owners.

Page 3