Technical Bulletin
Model(s)

Year

All

2008 - 2011

Eng. Code

Trans. Code

VIN Range From

VIN Range To

All

All

All

2.0T
(CCTA,CBFA)

Condition
24 15 01 January 23, 2015 2038161 Supersedes Technical Bulletin V241403 dated September 22, 2014 to
include fuel injector seal installation.
MIL ON, DTCs P2014 or P2015 Intake Manifold Faults Stored in ECM Fault Memory
MIL ON and 1 or more of the following fault codes stored in the ECM fault memory:

DTC

Description

P2014

Intake manifold runner position sensor / switch
circuit

P2015

Intake manifold runner position sensor / switch
circuit range / performance

Technical Background
Failure of Intake manifold causing fault codes to be stored in the ECM.

Production Solution
Improved intake manifold design.

Page 1 of 4
© 2015 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Bulletin
Service
1. Perform the Intake Manifold Limited Warranty Extension (see Repair Manual Group 24 Multiport Fuel Injection,
Removal and Installation Intake Manifold with Fuel Rail in Elsa).
Note:
During intake manifold replacement, all fuel injector seals must be replaced, see Elsa for installation instructions.
2. After performing Intake Manifold Limited Warranty Extension, add fuel additive G 001780M3 to the fuel tank.
Also, refer the customer to brochure 2014 VW Top Tier Fuel (VWTOPTIERJAN14) and explain the benefits of
using Top-Tier fuels as indicated in Technical Bulletin 2014815.

Warranty
To determine if this procedure is covered under Warranty, always refer to the Warranty Policies and
1)
Procedures Manual
Model(s)

Year(s)

Eng. Code(s)

All

2008 - 2011

2.0T

Trans. Code(s)

VIN Range From

VIN Range To

All

All

All

(CCTA,CBFA)
SAGA Coding
Claim Type:

Use applicable Claim Type

1)

Damage
Service Number:

HST

Damage Location (Depends on
Service No.)

--

Use applicable when indicated
in ElsaWeb (L/R)

Code
2447

0010

Parts Manufacturer

Tiguan, EOS, CC, Passat, Golf,
GTI

WWO

Jetta

3ME

2)

2)

Tiguan
Labor Operation

3) :

Remove and Install

24471940 = 250 TU

Labor Operation

3) :

Intake Manifold Replace

24475590 = 40 TU
Page 2 of 4

© 2015 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Bulletin
Labor Operation

3) :

Install Fuel Injector Seals

24402090 = 30 TU

Jetta, Eos, Passat, CC, Golf
Labor Operation

3) :

Remove and Install

24471918 = 250 TU

Labor Operation

3) :

Intake Manifold Replace

24475568 = 40 TU

Labor Operation

3) :

Install Fuel Injector Seals

24402068 = 30 TU

Causal Part:

06J133185**
Diagnostic Time

4)

GFF Time expenditure

01500000 = 20 TU max.

YES

Road Test

01210004 = 10 TU

YES

Technical Diagnosis

01320000 = 00 TU max.

NO

Claim Comment: Input “As per Technical Bulletin 2038161” in comment section of Warranty Claim.
1)

Vehicle may be outside any Warranty in which case this Technical Bulletin is informational only

2)

Code per warranty vendor code policy.

3)

Labor Time Units (TUs) are subject to change with ELSA updates.

4)

Documentation required per Warranty Policies and Procedures Manual.

Page 3 of 4
© 2015 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.

Technical Bulletin
Required Parts and Tools
Part Description

Part Number

Quantity

Intake Manifold

06J 133 201 BD

1

Injector Cleaner

G 001780M3

1

Fuel Injector Seal kit

06J 998 907 B

4

2014 VW Top Tier Fuel Brochure

VWTOPTIERJAN14

1

Tool Description

Tool No:

Midtronics Battery Tester/Charger

InCharge 940 (INC-940)
or
GRX3000VAS

VAS Diagnostic Tool

VAS 6150/X & VAS 6160/X with
ODIS Service with: current online updates

Additional Information
All part and service references provided in this Technical Bulletin are subject to change and/or removal.
Always check with your Parts Dept. and Repair Manuals for the latest information.

Page 4 of 4
© 2015 Volkswagen Group of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other
intellectual property rights of Volkswagen Group of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice.
No part of this document may be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or
otherwise, nor may these materials be modified or reposted to other sites, without the prior expressed written permission of the publisher.