Detroit Assurance Lane Departure Warning Camera
Installation
FLA COE
FLB COE
FLD Conventional
Business Class
FLC 112 Conventional

Century Class Conventional
Argosy COE
Cargo
Columbia

122SD and Coronado
Business Class M2
> Cascadia
108SD/114SD

54-291
Freightliner
Service Bulletin

Description of Revisions: This bulletin replaces the version dated

September 2015. There are now two possible locations for the
camera base, depending on the parameter setting for the VRDU
camera.

General Information
Use the instructions in this bulletin to replace the Detroit Assurance VRDU camera.

Parts
Refer to Table 1 for camera cover and base part numbers.
Camera Mounting Assembly Parts
Description
Part Number
Cover - Camera, Global Radar
1 8-67 468-000
Cover - Camera Base, Global Radar
A 1 8-67911 -000
Table 1, Camera Mounting Assembly Parts

NOTE: A camera mounting training aid has been designed by "DTNA Custom Built Training Aids" and
is available through the Aftermarket Resource Center (ARC) website. See Fig. 1. The training aid can
be used as an alternative to the mounting procedure described in this bulletin. Connect the vehicle to
Diagnosticlink to verify which parameter is programmed on the vehicle. The order form for the tool
can be accessed by clicking the "Training Aids" link located on the lower right-hand side of ARC's
home page, then clicking "Detroit Camera Mounting Tool Order Form" on the right-hand side of the
page. It is still necessary to order the camera mounting assembly parts described in Table 1 before
the camera can be mounted using this tool.
Check the parameter setting for the VRDU camera in Diagnosticlink before using the training aid. If
the training aid is being used on a vehicle programmed with parameter 000 447 36 51, position the
training aid on the passenger-side windshield, so the left edge is mounted 4 inches (100 mm) from
the center rubber seal and the top edge sits against the windshield upper rubber seal.

Freightliner Service Bulletin, September 2016

Page 1

54-291
Freightliner
Service Bulletin

Detroit Assurance Lane Departure Warning Camera
Installation
FLA COE
FLB COE
FLD Conventional
Business Class
FLC 112 Conventional

Century Class Conventional
Argosy COE
Cargo
Columbia

122SD and Coronado
Business Class M2
> Cascadia
108SD/114SD

A The training aid is used to position the camera
base on the windshield.
1. Camera Base
2. Windshield
3. Camera Mounting Training Aid
Fig. 1, Camera Mounting Training Aid

Installing the Detroit VRDU camera
1.

Park the vehicle and apply the parking brakes.

2.

Run the engine until the air system is fully charged, then shut down the engine and chock the tires.

NOTE: Components installed on the windshield may interfere with the mounting template. It may be
helpful to remove them before installing the VRDU camera.
IMPORTANT: Completely clean the area where the camera will be mounted. If the windshield is not
clean and free of grease and dust, the camera may not properly adhere to the windshield surface.
3.

Clean the windshield mounting surface with IPA wipe (50/50 mix of isopropyl alcohol and water) or
equivalent cleaner. Use a clean towel, and make sure the windshield surface is completely clean and free of
grease and dust.

4.

Create the template included with this bulletin.
IMPORTANT: When printing the template, make sure that the "Actual Size" radio button is
selected under the "Size" tab, the "Auto portrait/landscape" radio button is selected under the
"Orientation" heading, and that the "1-sided" radio button is selected on the properties screen.
See Fig. 2 and Fig. 3.
4.1

Page2

Print the template provided on the last page of this bulletin.

Freightliner Service Bulletin, September 2016

Detroit Assurance Lane Departure Warning Camera
Installation
FLA COE
FLB COE
FLD Conventional
Business Class
FLC 112 Conventional

Century Class Conventional
Argosy COE
Cargo
Columbia

54-291
Freightliner
Service Bulletin

122SD and Coronado
Business Class M2
> Cascadia
108SD/114SD

...,,

•

..

!I!!!!

'>tttll'l Help

Prmter. [\\c:GfJ1 p4l.Z\WRP RTA

co,;«

, ,.~Lir,w. [r..,. I PnCb!tr ]oo.itc,tima '

p l;.

Copies

P.iigc,; te- Print

·)
j

(Ufrttltp
~" ~' - - - - - -

It, P-11gcs
~

.g

MortO pt1(h"t1

j

P119e1SiDf19&~
~·

r

_ _ ._,..._.._,.,,._

54.N1

~

--C
.

~

~

.R'

'>

6J

I

rG3

Pwtlad.1>9l'm

-

2-sidedpnntJng
~mi;:idd:ior+J

r

~·-

< Uw--

,JI ~

@ Acti.11)ri2t : - : - - - _

______
r===.·;- - ---

3

LlJ r ....,::::::------_ 1

~

00

EJ P,111t on both SldH of PIP8

:::06;:,uli.ndiu~ - - - -

'

u.. ..-- -...

.......,..

Qr :l-med1~WJ1J

-,

O