ATTENTION:
GENERAL MANAGER
PARTS MANAGER
CLAIMS PERSONNEL
SERVICE MANAGER

q
q
q
q

IMPORTANT - All
Service Personnel
Should Read and
Initial in the boxes
provided, right.

SERVICE BULLETIN
APPLICABILITY:

NUMBER:

2014MY Subaru Vehicles

SUBJECT: 2014 Exchange Component Identification
and Procedures

DATE:

15-168-13
08/09/13

INTRODUCTION
This bulletin contains illustrations of exchange components and their manufacturer as well
as a description of the proper exchange procedure. The exchange program policy can also be
found in Sections 8.4.9 and 11.2.10 of your Service Policies and Procedures Manual found in
subarunet.

INDEX
•

8.4.9.1

Audio/Face Plate Exchange Program (pg. 1)

•

8.4.9.2

Rear Seat Entertainment Exchange Program (pg. 6)

•

8.4.9.3

Navigation System Exchange Program (pg. 8)

•

8.4.9.4

eturn of CD/DVD’s Lodged in an In-Dash CD Changer or Rear Seat
R
Entertainment Unit (pg. 11)

•

8.4.9.5

Satellite Radio Exchange Program (pg. 12)

•

11.2.10 Out of Warranty Exchange / Repair Program (pg. 15)

8.4.9.1 AUDIO/FACE PLATE EXCHANGE PROGRAM

Within the terms of the Basic New Car Warranty and one year Replacement Part Warranty, the
Exchange Program provides for replacement of a defective audio chassis and/or faceplate with
an exchange unit from the manufacturer. The manufacturer will supply an exchange unit, or a
new unit in the case of a “New” and “In-stock” vehicle.
Note: DO NOT disassemble an In-Dash CD Changer to retrieve any lodged CD(s) prior to
returning to the manufacturer. See Section 8.4.9.4 for the policy on returning the CD(s) to the
customers.
Genuine Subaru audio systems are manufactured by Panasonic and Clarion. Audio visual
navigation units are manufactured by Kenwood Corporation and Fujitsu Ten Corporation. In
the event an audio chassis/faceplate requires an exchange, it is not necessary to remove the
unit from the vehicle. The procedures listed below should be followed:
(1) The defective chassis should remain in the vehicle until the exchange unit is installed.
(2) The applicable Service Center should be contacted.
continued...

CAUTION: VEHICLE SERVICING PERFORMED BY UNTRAINED PERSONS
COULD RESULT IN SERIOUS INJURY TO THOSE PERSONS OR TO OTHERS.
Subaru Service Bulletins are intended for use by professional technicians ONLY. They
are written to inform those technicians of conditions that may occur in some vehicles, or
to provide information that could assist in the proper servicing of the vehicle. Properly
trained technicians have the equipment, tools, safety instructions, and know-how to
do the job correctly and safely. If a condition is described, DO NOT assume that this
Service Bulletin applies to your vehicle, or that your vehicle will have that condition.

Bulletin Number: 15-168-13; Date: 08/09/13

SUBARU OF AMERICA, INC. IS “ISO
14001 COMPLIANT”
The international standard for excellence
in Environmental Management Systems.
Please recycle or dispose of automotive
products in a manner that is friendly to our
environment and in accordance with all
local, state and federal laws and regulations.

Page 1

The Panasonic Service Center may be contacted either by phone or by faxing a legible copy
of the Panasonic Exchange Form (Section 17.15). The on-line Exchange Form is also found
on Subarunet, under “Service then Forms”. The Panasonic Service Center is open from 8AM
to 8PM Eastern Time.
PANASONIC
SERVICE CENTER TELEPHONE
1-800-228-0473

FAX TELEPHONE
1-800-682-8056

The Clarion Service Center may be contacted by phone. The Service Center is open from
8AM to 6PM Eastern.
CLARION
1-800-347-8933

The Kenwood Service Center should be contacted, preferably through their website or by
faxing a legible copy of the Kenwood Exchange Request Form (Section 17.9). The on-line
Exchange Form is found in Subarunet, under Service, then Forms. The Service Center is open
from 9AM – 5:30PM Pacific Time. Requests arriving after 2:00PM PST are processed the
following business day.
KENWOOD CORPORATION
ON-LINE EXCHANGE FORM
FAX TELEPHONE
SERVICE CENTER TELEPHONE
www.fthgroupinc.com
1-626-333-2407
1-626-333-2435

The Fujitsu Ten Service Center may be contacted by phone, fax or e-mail. The Subaru
Advance Exchange Fax Form is found in Subarunet, under Service, then Forms. The Service
Center is open from 7AM – 5PM Pacific Time. Exchange Units will be shipped to the dealer
via 2nd-day service.
NOTE: Activation of all XM subscription based services is the responsibility of the vehicle
owner.
E-MAIL ADDRESS
[email protected]

FUJITSU TEN
FAX TELEPHONE
1-800-438-5410

SERVICE CENTER TELEPHONE
1-800-237-5413

SPECIAL NOTE: Audio/Navigation Unit SD (memory) cards must be returned along
with the complete unit itself for all exchange transactions made with Fujitsu Ten. Please
confirm the correct SD card part number is included with the unit. The correct part number
combinations of SD card and head units are provided below with the illustrations.
NOTE: In the event the vehicle is “New” and “In-stock”, inform the Service Center. A new
unit will be supplied rather than an exchange unit. If the Service Center is unable to provide
a new unit, immediately contact a Subaru of America, Inc. Dealer Claims Specialist at
1-866-SUBARU2 for further instructions.
continued...
Bulletin Number: 15-168-13; Date: 08/09/13

Page 2

Vehicles that have been placed in demo service should use exchange units only.
Replacement of an audio chassis/faceplate with a new unit, other than units supplied
through the exchange program, requires authorization from Subaru of America, Inc. Dealer
Claims Specialist. An authorization code will be provided and must be included upon claim
submission.
(3) Provide the Service Center with the following information:
Dealer Code
Dealer Name and Address
VIN - All 17 Characters
Date of Vehicle Sale
Vehicle Mileage
Caller’s Name and Telephone Number
Dealer RO Number
Chassis Model Number, ID Code and/or the Subaru Part Number (Clarion requires the
front faceplate ID number)
Customer Complaint
Customer Last Name
At this time, the Service Center will issue an exchange number. It is required that this number
be provided upon claim submission.

Panasonic Exchange Number Example..................................... SUS0000001

Clarion Exchange Number Example… (ERS#)........................ 0000000001

Kenwood Exchange Number Example… (RM#)...................... 0000(0)

Fujitsu Ten Exchange/Claim Id Number Example................... 4YB000000

Please note that the Fujitsu Ten Exchange Number is known as their Claim Number which is located
at the bottom of the returned Exchange Fax Form.

An exchange chassis along with an exchange form will be shipped within 72 hours. If the
exchange chassis is not received within 5 days, call the Service Center. Provide the operator
with the exchange number when making inquiries.
(4) Install the exchange unit as soon as possible upon receipt. Return the defective chassis
to the manufacturer within 30 days. Return freight charges may be claimed as sublet,
provided the repair was performed under the terms of the Basic New Car Warranty or one
year Replacement Part Warranty. Copies of the freight invoice should be attached to the
repair order.
If the exchange unit has not been installed or the failed chassis returned within 30 days,
contact the Service Center. Reference the exchange number and explain the circumstances
causing the delay. An extension will be granted or the dealer will be instructed to return the
exchange unit. Failure to comply will result in a “charge back” to the dealer for the cost of the
exchange unit and/or the SD Card.
continued...
Bulletin Number: 15-168-13; Date: 08/09/13

Page 3

ILLUSTRATION

DESCRIPTION

MANUFACTURER

PART NUMBER

Legacy / Outback
Type A AM/FM
Single disc
CD player

Clarion

86201AJ61A
Audio Unit Only

Legacy / Outback
Type B AM/FM
Single Disc CD
Player (Display
Type) SAT

Legacy / Outback
Type B AM/FM
Single Disc CD
Player
(Display Type)
SAT

Legacy/Outback
Navigation &
Audio Complete
Head Unit (AVN)
w/Aha &
Harman Kardon

Panasonic

Return of Assembly
Includes Harness

Panasonic

86201AJ66A
*Audio/Faceplate
Assembly (See note
at bottom)
Return of Assembly
Includes Harness

Fujitsu Ten

Face Plate ID No.
FE688US

Legacy/Outback
Navigation &
Audio Complete
Head Unit (AVN)
w/Aha

86201AJ65A
*Audio/Faceplate
Assembly (See note
at bottom)

Fujitsu Ten

Face Plate ID No.
FE699US

886271AJ80A
Audio with SD Card
SD Card Part No.
86283AJ66A

886271AJ81A
Audio with SD Card
SD Card Part No.
86283AJ69A

* For either Audio or Face Plate failures, order the assembly
continued...
Bulletin Number: 15-168-13; Date: 08/09/13

Page 4

ILLUSTRATION

DESCRIPTION
BRZ Audio &
NavigationUnit
Assembly w/XM
built-in and Aha

MANUFACTURER

Black plate (265,1)

Fujitsu Ten

Face Plate ID No.5-5
The audio set will operate only when the
ignition switch
is in the “ACC” or “ON”
FA632US
position.
Audio/Audio set

& Type A audio set (if equipped)

. Power and audio controls: refer to page
5-10
. Radio operation: refer to page 5-13
. CD (compact disc) player operation:
refer to page 5-20
. Auxiliary input jack: refer to page 5-26
®
. USB storage
device/iPod
operation:
Black plate
(265,1)
refer to page 5-28
. Bluetooth® audio: refer to page 5-36
. Hands-free system: refer to page 5-39

Forester Type A
AM/FM Single
Disc CD Player,
Bluetooth, USB 5-5

PART NUMBER
86271CA630
Audio with SD Card
SD Card Part No.
86283CA630

5

Clarion

86201SG600

Clarion

86201SG620

Audio/Audio set

& Type A audio set (if equipped)

The audio set will operate only when the
ignition switch is in the “ACC” or “ON”
position.
. Power and audio controls: refer to page
5-10
. Radio operation: refer to page 5-13
. CD (compact disc) player operation:
refer to page 5-20
. Auxiliary input jack: refer to page 5-26
. USB storage device/iPod® operation:
refer to page 5-28
. Bluetooth® audio: refer to page 5-36
. Hands-free system: refer to page 5-39

Forester Type A
AM/FM Single
Disc CD Player,
Bluetooth, USB

– CONTINUED –

5