Service Information
Offboard Diagnostic Information System Service (ODIS Service)

Number: AOS-14-15

Subject: ODIS Service Installation Phase 2 – Software Installation Date: June 10, 2014
& Configuration Instructions
Supersedes AOS-14-12: Windows® XP & VAS-PC references deleted.

Table of Contents
Page

Section
1.0

Introduction - Must Read!

2

1.1

New Installations - Overview

2

1.2

Reinstallations - Overview

2

Preparation

3

2.0
2.1

Device and License Request Checklists

3

2.2

Hardware Prerequisites – All Installations

4

2.3

Reinstallations - Uninstall ODIS Service

4

2.4

Note the DVD-ROM Drive Letter

5

3.0

Installation

5

3.1

Application Software & License Installation

5

3.2

Post-Setup - Diagnostic Data Installation

12

4.0

Post-Setup Configuration

15

4.1

Administration - General

15

4.2

Administration - Support

18

4.3

Administration - Connections

19

Post-Installation File Management & Back-Up

21

5.1

General Information

21

5.2

Backup Device Folder on USB Flash Drive

22

Online Updates

22

General Information

22

5.0

6.0
6.1

Page 1 of 22
© 2014 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual
property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may
be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be
modified or reposted to other sites, without the prior expressed written permission of the publisher.

Service Information
Notes:
• The following procedures must be performed by qualified personnel only!
• Please read these instructions in their entirety before performing these procedures. If you do not
have previous experience loading software or do not understand these instructions, arrange
to have a qualified person perform these procedures.
• Heed all prerequisite requirements and notes, and follow all instruction steps in the Section
order given, including instructions cross-referenced in documents posted on ServiceNet.
• Perform the procedures in an area that is quiet, clean and without distraction or interruption.
• Discard all printed copies of this document after use. Revised versions may be issued at any
time. Always check ServiceNet for the latest version.

1.0 – Introduction
This document describes the complete installation and configuration processes of ODIS Service
Installation DVD Version 2.1.0 on VAS diagnostic devices with Windows 7 operating systems. The
installation options covered here are:
• New installations
• Reinstallations.
Separate instructions for each installation option are covered throughout this document. Refer to
Subsections 1.1, 1.2 and 1.3 below for information on how to use these instructions.
In all cases, important preparations and prerequisites must be fulfilled prior to proceeding!

1.1 - New Installations
New Installations are defined as installations on:
•

New devices where ODIS Service was not previously installed.

•

Existing devices that have been updated from Windows XP to Windows 7 using the AoAsupplied DVD.

In both cases, ALL ODIS Service Installation Phases (1, 2 and 3) must be completed, in phase order, on
all new or updated devices prior to using ODIS Service. All phase documents are posted on ServiceNet.
Look for the New Installations subsection titles and references throughout this document.

1.2 – Reinstallations
Reinstallations are defined as installations on existing VAS diagnostic devices where ODIS Service was
previously installed.
Reinstallations may be necessary whenever new “installation version” DVDs are issued, or to resolve
application malfunctions on an existing version.
Look for the Reinstallations subsection titles and references throughout this document.

Page 2 of 22
© 2014 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual
property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may
be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be
modified or reposted to other sites, without the prior expressed written permission of the publisher.

Service Information
2.0 – Preparation
2.1 – Device and License Preparation Checklists
Complete the device and license checklist for the installation option that applies:



New Installations – Device and License Preparation Checklist
New device where ODIS Service was not previously installed:



VAS 6150C laptop

or



VAS 6160A tablet

Existing device updated from Windows XP to Windows 7 using the AoA-supplied DVD:







VAS 6150A laptop
VAS 6150B laptop
VAS 6150C laptop
VAS 6160 tablet
VAS 6160A tablet

All devices: ODIS Service Installation Phase 1 - Preparation & License Request Instructions (eShop)
completed:




License requested from eShop and license request approval email received

License file downloaded from eShop to a folder on the diagnostic device desktop
DO NOT proceed without the license file intended for the device!
New Installations checklist completed. Proceed to Section 2.2 - Page 4.



Reinstallations – Device and License Preparation Checklist
Existing device where ODIS Service was previously installed:








VAS 6150A laptop
VAS 6150B laptop
VAS 6150C laptop
VAS 6160 tablet
VAS 6160A tablet
Existing license file saved in a folder on the diagnostic device desktop*

or



Existing license file backed-up on USB flash drive*

*If the existing license file is not available, request a replacement license from eShop > Phase 1 Instructions

Reinstallations checklist completed. Proceed to Section 2.2 - Page 4.

Page 3 of 22
© 2014 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual
property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may
be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be
modified or reposted to other sites, without the prior expressed written permission of the publisher.

Service Information
2.2 – Hardware and Network Prerequisites – All Installations






ODIS Service Version 2.1.0 DVD - Order No. 009.5002.02.21 on hand.



Device disconnected from dealership network: Ethernet cable disconnected, device wireless
operation switch in the OFF position where applicable.



A Windows 7 update MUST NOT be in the process of being downloaded or installed. Go to:
Control Panel > Windows Update to confirm!

Diagnostic device with functioning CD/DVD drive and USB.
Diagnostic device plugged in to A/C power adapter and booted to Windows desktop.
VAS Diagnostic Tablets: Device mounted in base station with USB mouse and keyboard
connected.

2.3 – Reinstallations – Uninstall ODIS Service
ODIS Service must always be uninstalled along with additional files prior to reinstallations. Use the
procedures specified below.
Reinstallation Tips:
• If you are unaware of, or have not recorded the Email Outbox Server configuration settings,
please note them now! Go to: ODIS Service > Admin > Support > E-mail outbox server …and
record the various settings on a separate piece to use during the post-reinstallation configuration.
• If the license file was not saved in a folder on the Windows desktop, or if the USB flash drive
containing the backup license file is not available, copy the installed license to the Windows
desktop prior to uninstallation as follows:
1. From the Windows desktop, go to: Windows (Start) > Computer > Local Disc (C:) > Program
Files (x86) > Offboard_Diagnostic_Information_System_Service > license
2. Right click the license (.dat) file.
3. Select Copy, and then close all windows.
4. Paste the license on the Windows desktop (for retrieval during the installation routine) and revisit
the Phase 1 instructions, Section 3.5 for a suggested method to save the license file in a
desktop folder.
Uninstall ODIS Service and Softing D-PDU API files:
1. Go to: Windows (Start) > All Programs > (ODIS Service) > ODIS Service Uninstallation Program
or uninstall ODIS Service using the applicable Windows “Add or Remove Programs” utility.
2. When prompted, check the boxes to remove all licenses, MCD projects, diagnostic logs etc. Scroll
down in the prompt window and check all boxes as necessary.
3. Restart the diagnostic device when prompted.
4. Go to: Windows (Start) > All Programs > Softing D-PDU API for VCIs > 1.X0.0XX > Uninstall (Be
aware that more than one Softing D-PDU API file may be listed under Programs).
5. Follow the uninstallation routine for ALL available D-PDU API 1.X0.0XX files.
6. Restart the diagnostic device.
Continued …5/
Page 4 of 22
© 2014 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual
property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may
be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be
modified or reposted to other sites, without the prior expressed written permission of the publisher.

Service Information
2.4 – Note the DVD-ROM Drive Letter
The installation routine directs you navigate to a content folder on the installation DVD.
As DVD-ROM drive letter assignments may not be consistent between devices, they may or may not
match the examples illustrated in these instructions. Please note YOUR drive letter as follows:
1. From the Windows desktop, go to: Windows (Start) > Computer
2. Note the letter assigned to the DVD RW Drive ( _ 🙂
3. Close the Computer Window.
All Preparation steps completed. Proceed to Section 3.0 below.

3.0 – Installation
3.1 – Application Software & License Installation
1. Insert ODIS Service Version 2.1.0 DVD into the DVD-ROM drive. The DVD should AutoPlay.
2. Select Open folder to view files:

If the DVD does not AutoPlay, go to: Windows (Start) > Computer and open the DVD-ROM directory.
3. Wait while the directory contents are read.
4. Click on OffboardDiagSetup-Service_2_1_0-RC.…:

Continued …6/
Page 5 of 22
© 2014 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual
property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may
be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be
modified or reposted to other sites, without the prior expressed written permission of the publisher.

Service Information
5. Wait while the Install4j wizard prepares the installation:

6. Confirm English (US) is highlighted. Click OK.

7. Click Next:

8. No action needed. Click Next:

Page 6 of 22
© 2014 Audi of America, Inc.
All rights reserved. Information contained in this document is based on the latest information available at the time of printing and is subject to the copyright and other intellectual
property rights of Audi of America, Inc., its affiliated companies and its licensors. All rights are reserved to make changes at any time without notice. No part of this document may
be reproduced, stored in a retrieval system, or transmitted in any form or by any means, electronic, mechanical, photocopying, recording, or otherwise, nor may these materials be