Bulletin No.: 13395
Date: December 2014

Service
Bulletin

Service Update
SUBJECT:

Service Update for Inventory and Customer Vehicles
Contact between the Fuel Feed Line and the A/C Pipe
Expires with Base warranty

MODELS:

2013 – 2014 Chevrolet Trax with 1.4L Turbo engine

This service update includes vehicles in dealer inventory and customer vehicles that return to
the dealership for any reason. This bulletin will expire at the end of the involved vehicle's New
Vehicle Limited Warranty period.

CONDITION
Certain vehicles may have been produced with insufficient clearance between the fuel feed line
and the A/C pipe. Should these lines contact one another, the AC line may wear, possibly
resulting in a refrigerant leak.
CORRECTION
Dealers are to inspect the A/C pipe for wear and if present, replace the AC line. In addition,
dealers are to install a swivel clip to maintain clearance between fuel feed line and A/C pipe
VEHICLES INVOLVED
All involved vehicles are identified by VIN in the Global Warranty Management System Investigate Vehicle History Application. Dealership technicians should always check this site to
confirm vehicle involvement prior to beginning any required inspections and/or repairs. It is
important to routinely use this tool to verify eligibility because not all similar vehicles may be
involved regardless of description or option content.
Additionally, a list of involved vehicles currently in dealer inventory is attached to the
GlobalConnect message used to release this bulletin

Copyright 2013 General Motors. All Rights Reserved.

Page 2

December 2014

Bulletin No.: 13395

PART INFORMATION
Parts required to complete this recall are to be obtained from General Motors Customer Care
and Aftersales (GMCC&A). Please refer to your “involved vehicles listing” before ordering parts.
Normal orders should be placed on a DRO = Daily Replenishment Order. In an emergency
situation, parts should be ordered on a CSO = Customer Special Order.
Part
Number

Description

Quantity /
vehicle

15034183

Swivel Clip

1

95299470

A/C Evaporator hose assembly

1

SERVICE PROCEDURE
1. Air conditioner pipe inspection
a. Open the hood of the vehicle.

4004602

b. Locate the A/C pipe (1) for inspection.
c. Inspect the A/C pipe section (1) that is adjacent to the fuel hose (2):
i. If the A/C pipe does not show any sign of wear or damage, proceed to step 2.
ii. If the air conditioner pipe is worn or damaged, replace the A/C line, refer to Air
Conditioning Evaporator Hose Assembly Replacement Procedure in SI.

Page 3

December 2014

Bulletin No.: 13395

2. Swivel Clip Installation

4004608

a. Install the swivel clip (1) underneath fuel hose quick connector (2) as pictured above.
WARRANTY TRANSACTION INFORMATION
Submit a transaction using the table below. All transactions should be submitted as a ZFAT
transaction type, unless noted otherwise.
Labour
Code

Description

Labour
Time

9101026

A/C pipe inspection and swivel clip installation

0.2

9101027

A/C pipe inspection - replacement and swivel clip installation

0.5

DEALER PROGRAM RESPONSIBILITY
Whenever a vehicle subject to this service update enters your vehicle inventory, or is in your
facility for service in the future, and the vehicle is still covered under the New Vehicle Limited
Warranty, you must take the steps necessary to be sure the service update correction has been
made before selling or releasing the vehicle.

GM bulletins are intended for use by professional technicians, NOT a "do-it-yourselfer". They are written to inform these technicians of conditions that
may occur on some vehicles, or to provide information that could assist in the proper service of a vehicle. Properly trained technicians have the tools,
equipment, safety instructions, and know-how to do a job properly and safely. If a condition is described, DO NOT assume that the bulletin applies to
your vehicle, or that your vehicle will have that condition. See your dealer for information on whether your vehicle may benefit from the information.

We Support
Voluntary Technician
Certification