GROUP

($?/) HYUnDRI I nEWTHlnKlnG.
nEW POSSIBILITIES.
-

Technical Service Bulletin

NUMBER

AUTOMATIC
TRANSMISSION
DATE

MODEL

MARCH 2013
SUBJECT:

13-AT-006

Tucson (LM), Santa Fe (CM/AN/NC),
Sonata (YF/YF HEV), Elantra
(UD/MD/GD/JK), Accent (RB), Azera
(TG/HG), Veloster Turbo (FS)

AUTOMATIC TRANSAXLE (6-SPEED)
ATF FLUID LEVEL CHECK

This TSB supersedes TSB 11-AT-004 to include 2013 models
Description: The following veh icles are equipped with a 6-speed automatic transmission. The ATF
level can be checked by the following procedure :

*NOTE
Use only ATF meeting the SP-IV specification approved by Hyundai. DO NOT use SP-Ill
or other ATF which may result in degradation of shift quality or transaxle durability.

Model

Model Years

Applicable Vehicles:

2010-

Tucson (LM) & Santa Fe (CM)

2011-

Sonata (YF)/HEV, Elantra (UD/MD) & Azera {TG)

2012-

Accent (RB) , Azera (HG)

2013-

Veloster Turbo (FS) , Elantra Coupe (JK) , Elantra GT
(GD) and Santa Fe (AN/NC)

PARTS INFORMATION:

Hyundai SPH-IV

SP-IV Automatic Transmission Fluid

00232-19045

WARRANTY INFORMATION: Normal warranty applies

Circulate To : Service Manager, Warranty Manager, Service Advisors , Technicians , Fleet Repair

SUBJECT:

ATM OIL TEMPERATURE SENSOR OTC P0711, P0712 & P0713

SERVICE PROCEDURE:

1.

If the ATF has been completely drained , add approximately 5 quarts of SPH-IV ATF .

2.

Attach a GOS and select:
• Vehicle and AfT menu .
• Cu rrent Data
• Oil temperature sensor.

Value Unit

fli

0
§I General Information

l"1 OTC Information
Si Soeciflcation
~

OTC Inspection
~ Wiring lnsoection
~ Component lnspectio
13 Verification of Reoair

13 Component Location
§JETM

O

Input Speed(PG..A)
Output Speed(PG.B)

0

Shift lever Swt1ch

RPt.1
RPt.1
p

D Current Gear
D
0
D
0
D
0

PIH
0
0
0.0
0
0
0
0
OFF
OFF
0
0
OFF
0
0
2.0
OFF
OFF
OFF
3.9
0.0
OFF

Next Ge a r Position

Engine RPM
Gear Ratio
Shift Control Solenoid Valve A(UOIB)

Shift Control Solenold Valve 6(2-0/B)

Shift Control Solenoid Valve C(35R/C)
D Shift Control Solenoid Valve 0(00/Q

0 Shift Control Solenoid Valve E(SS.A)
D Shlf1 Control Solenoid Valve F(SS-8)
0 Pressure Control Solenoid Valve(VFS) '"A"'

0
0
D
0

Torque Converter Outch So lenoid Valve

Torque Conve rter Outch Control State
Torque Converter Outch Slip
Vehicle Speed
D Engine Torque
0 Sports Mode Select
0 Sports Mode Up Switd1
D Sports Mode Down Switch
D Throttle Position Senso r Angle
0 Acce lerator Peda l Position Senso r
Brake Switch

n

Cue Analysis

OTC

DVOM

RPM

mA
mA
mA
mA

mA

mA
RPt.1
fAPH
ll

ll
ll

Oscinoscope

SimUlatiOn

Test

3.

Drive the vehicle until the fluid temperature is at the low end of the range of 122-140°F
(50-60°C).

4.

Step on the brake and then shift into "R", "N"
and "D" and back, pausing 2-3 seconds in
each range . Repeat two times .
Move the shift lever to P, leave the engine
running (Sonata Hybrid in "EV Ready" mode)
and lift the vehicle on a hoist.

5.

Remove the splash shield under the transmission.

TSB #: 13-AT-006

Page 2 of 3

SUBJECT:
6.

ATM OIL TEMPERATURE SENSOR OTC P0711 , P0712 & P0713

Remove the oil level plug. The oil level is
correct if ATF flows out in a thin steady stream .
If no oil flow occurs , go to Step 7.

ATF Temperature= 122-140F (50-GOC)
Shift lever in " P" and engine running

HEV in " EV Ready" mode

7.

If no oil flow occurs, add SPH-IV ATF through
the fill plug opening or use a suction gun to
add ATF through the level checking plug.
Reinstall the plug.

Filling and checking of flu id level is
done through va lve body s ide cover

Start the engine and shift to Park. When the
ATF is 122°F-140°F (50-60 °C) , remove the
level checking plug . The level is correct when
oil flows out of the level checking plug in a thin
steady stream .

*NOTE
Collect and dispose of any excess fluid
in accordance with local regulation.
8.

I Fill Plug shown

I Level Checking Plug

ATF TEMPERATURE = 122 - 140F (50- 60C)
SHIFT LEVER IN " P" AND ENGINE RUNNING

Reinstall the overflow plug and torque to specification .
Steel pan : Torque: 25-32 lb-ft (3.5-4 .5 kgf.m)
Plastic pan : Turn plug past detent.

TSB # : 13-AT -006

Page 3 of 3