“This site contains affiliate links for which OEMDTC may be compensated” |
May 13, 2022 NHTSA CAMPAIGN NUMBER: 22V336000
Propane Regulator May Fail and Cause Fire
Increased propane pressure can enlarge the flames in gas appliances, increasing the risk of a fire.
NHTSA Campaign Number: 22V336
Manufacturer Kuntry Kustom RV, LLC
Components EQUIPMENT
Potential Number of Units Affected 172
Summary
Kuntry Kustom RV, LLC (Kuntry) is recalling certain 2017-2020 Rich Specialty Trailers Sanitation, Movie, Office, and Bunk House trailers, equipped with Winntec model 6020 two-stage propane regulators. The regulators may fail, causing an increase in propane pressure.
Remedy
Dealers will replace the regulator, free of charge. Owner notification letters were mailed June 7, 2022. Owners may contact Kuntry customer service at 1-260-593-2208.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.
Certain Winntec model 6020 two-stage propane regulators installed on these vehicles may supply elevated, intermittent or low propane pressure to the appliances due to a second stage valve seat that can fail to regulate propane flow and pressure. An increase in propane pressure, could cause the flame of the appliance to become larger, and under certain rare circumstances, may ignite adjacent materials resulting in a fire.
Appliances that can be affected by an excessive flame are the LP gas stovetop, LP gas oven, LP gas hot water heater, LP gas furnace and LP gas refrigerator. An increase in propane pressure would also cause the regulator to vent propane continuously through the pressure relief valve. In an enclosed area or under certain conditions, the vented propane could accumulate at the front of the specialty trailer and if ignited could result in a fire or explosion.
Remedy consists of removing and replacing the propane regulator with a new regulator and performing standardized LP System Checks. The repair should take less than an hour to perform and this will be done at no labor or parts cost to the customer. Please see attached inspection and replacement procedures.
Chronology :
Jan 4rth 2022-Notified by NHTSA of possible safety defect.
Feb 8th 2022-Reviewed service records and while no reports of injury, no deaths, no field reports of problems and no regulator problems the decision is made to recall.
May 12th 2022- Received notice from supplier that the replacement component/regular is back in stock so can now offer replacement part.
May 13th 2022- Submitted letter and notice to NHTSA
21E081 – Possible LP Regulator Failure – Winntec & WIC Model 6020 LP Regulators
21E081 – Possible LP Regulator Failure – Winntec & WIC Model 6020 LP Regulators
16 Affected Products
Vehicles
MAKE | MODEL | YEAR |
RICH SPECIALITY TRAILERS | BUNK HOUSE | 2017-2020 |
RICH SPECIALITY TRAILERS | MOVIE | 2017-2020 |
RICH SPECIALITY TRAILERS | OFFICE | 2017-2020 |
RICH SPECIALITY TRAILERS | SANITATION | 2017-2020 |
10 Associated Documents
Recall Acknowledgement
RCAK-22V336-1002.pdf 646.508KB
Defect Notice 573 Report
RCLRPT-22V336-5068.PDF 212.658KB
Recall 573 Report – 5/24/2022
RCLRPT-22V336-8213.PDF 212.854KB
Recall 573 Report – 5/24/2022
RCLRPT-22V336-5729.PDF 212.843KB
Recall 573 Report – 5/24/2022
RCLRPT-22V336-5599.PDF 212.864KB
Recall 573 Report – 5/31/2022
RCLRPT-22V336-8487.PDF 212.861KB
ISSUED Owner Notification Letter(Part 577)
RCONL-22V336-4583.pdf 808.243KB
Recall Quarterly Report #1, 2022-2
RCLQRT-22V336-4526.PDF 211.134KB
Recall Quarterly Report #2, 2022-3
RCLQRT-22V336-9259.PDF 211.228KB
Manufacturer Notices(to Dealers,etc)
RCMN-22V336-0185.pdf 807.795KB
Latest Recalls Documents
For the Latest and Most Recent Recalls Information Visit the link below…
https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=22V336&docType=RCL
- Allows removal of the empty cylinder for refill without interrupting propane supply; includes 2 of the 12-inch pigtails to connect the regulator to the propane tank or propane supply
- For RVs with dual propane tanks; it automatically switches from primary to reserve tank when the primary tank is empty
- Pairs well with our 48 Inch Thermo Plastic Hose, item 100383-48
- Inlets are 1/4" SAE inverted flare and outlet is 3/8" NPT female pipe thread; rated for 345,200 BTU
- Double-stage design maintains constant gas pressure under changing demand and conditions
- Allows removal of the empty cylinder for refill without interrupting propane supply; includes 2 of the 12-inch pigtails to connect the regulator to the propane tank or propane supply
- For RVs with dual propane tanks; it automatically switches from primary to reserve tank when the primary tank is empty
- Pairs well with our 48 Inch Thermo Plastic Hose, item 100383-48
- Inlets are 1/4" SAE inverted flare and outlet is 3/8" NPT female pipe thread; rated for 345,200 BTU
- Double-stage design maintains constant gas pressure under changing demand and conditions
- Has integral first and second stages that ensure smoother, more consistent flow of propane gas to all RV appliances Inlet: POL tank connection Outlet: 3/8" Female NPT
- Outlet pressure: 11"WC Horizontal Style with POL
- 160,000 BTU/HR POL valve connection to allow for easy hookup
- Double stage design maintains constant gas pressure under changing demand and conditions
- Durable and easy to use
- Combines both a high pressure first stage and a low pressure second stage regulator into one unit
- Ideally designed for RV applications, these regulators ensure a smooth and continuous flow of gas to all appliances
- 1/4" FPT Inlet
- 3/8" FPT Outlet
- 9:00 Vent Position
- 1/4" FPT Inlet x 1/4" FPT Outlet
- 500,000 BTU/Hr or 30 PSIG based on 100 PSIG inlet
- Primary use, dual bottle with distant separation applications
- Ideal use where PSIG rather than W.C. is needed
- Allows removal of an empty cylinder for refill without interrupting propane supply
- For RVs with dual propane tanks; automatically switches from primary to reserve tank when primary is empty
- Compatible with Flame King's 48-inch Thermo Plastic Hose, item 100383-48, and 12-18 inch Pigtails - E12INPT, E15INPT or E18INPT
- Inlets are 1/4" SAE inverted flare and outlet is 3/8" NPT female pipe thread; rated for 345,200 BTU
- Double-stage design maintains constant gas pressure under changing demand and conditions
- Type: Fixed / PSI
- Max. Inlet Pressure: 250 PSIG (17, 2 bar)
- Inlet Connection: 1/4" FNPT
- Outlet Connection: 1/4" FNPT
- Orifice Diameter: 0. 0625"
- Upgrade Design: The RV propane regulator allows you to hook up 2 propane tanks and automatically switches from the primary to the reserve tank when the primary is empty and vice versa. The indicator will changes color to let you know when a tank has been depleted and needs to be refilled. The regulator ensures that your propane gas is always at the right pressure, providing consistent and efficient performance.
- Propane Hose: The RV pigtail hose with propane tank gauge is made of durable stainless steel braided, with weather resistance, anti-aging, air tightness, heat-resistance, and flexibility features. Can lets you know how much liquid is left without shaking the propane tank and can detect leaks. Our Auto changeover LP propane regulator with hose is the ideal solution for maintaining a safe and reliable propane gas supply for your RV, camper, or other propane-powered appliances.
- Specification & Material: The RV propane regulator with hose is made from high-quality brass material that is built to last. This ensures that the regulator is not only durable but also corrosion-resistant, making it ideal for use in outdoor environments. Master cylinder capacity 210,000BTU/hour; reserve cylinder 130,000BTU/hour, double stage design maintains constant gas Inlets are 1/4"SAE inverted flare and outlet is 3/8 "NPT female pipe thread.
- Wide Application: This 2-Stage auto changeover LP propane gas regulator for RV with two 18-inch pigtails RV propane gauge hoses set, is suitable for RV with dual propane tanks. The regulator can be used with any propane-powered appliance, making it a versatile and cost-effective solution for all your propane needs. Whether you're a weekend warrior or a full-time RV enthusiast, our propane regulator is the perfect tool for your propane-powered lifestyle.
- Precise Control: The propane regulator with gauge features excess flow protection and an automatic shut-off valve, which helps prevent leaks and other safety hazards. With our Auto Changeover LP Propane Regulator, you can easily adjust the pressure of your propane supply to ensure your appliances run smoothly and efficiently. This gives you greater control over your propane usage.
- 🔥【Function Upgrade】Connect two propane tanks at once with Alloxity's 2-Stage regulator,won't stop working because one of them is out of gas, automatically switches from primary to reserve tank when primary is empty.At the same time, you can use the rotary pointer to designate one of the tank to work on, and the indicator changes color to let you know when a tank needs to be refilled.
- 🔥【High-Quality Materials】Made of 100% solid brass, Alloxity's propane hose and regulator are durable and long-lasting. The RV pigtail propane hose is made of stainless steel braided material, ensuring air tightness and stability. All fittings are CSA certified.
- 🔥【Specification & Parameters】Alloxity's RV propane regulator has a primary cylinder capacity of 210,000 BTU/hr and a reserve cylinder capacity of 130,000 BTU/hr. Inlets are 1/4" SAE Inverted Flare, Outlet is 3/8" Female NPT. RV pigtail propane hose has a 1/4" Male Inverted Flare and QCC1 Fitting.
- 🔥【Versatile Application】Suitable for RVs, campers, and travel trailers with dual propane tanks. These 18" RV pigtail propane hoses with 2-stage propane regulator can connect dual 5-40 lb refillable propane tanks or LP gas tanks to your camper's 1/4" inverted male flare. Replace any existing automatic changeover regulator on your current RV, Travel Trailer, Camper, maintains constant and continuous gas.
- 🔥【Package List】Includes 1 PC 2 Stage Auto Changeover RV Propane Regulator, 2 pack 18'' Stainless Braided QCC1 1/4" Inverted Male Flare RV Pigtail Propane Hoses with Gauge, 1 PC Roll Sealing Tape, and 1 PC Wrench. If for any reason you are not satisfied with our products after receiving them within 2 years, simply contact us for a Free Replacement or Refund. Our Customer Service will solve your problems within 24 Hours.
Last update on 2024-04-12 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.
SEOCONTENT-START
IMPORTANT SAFETY RECALL – June 6nd, 2022 This Notice Applies to Your Trailer- NHTSA Recall No. 22V-336 Dear Valued Owner: This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act. Kuntry Kustom RV, LLC dba Rich Specialty Trailers has decided that a defect, which relates to motor vehicle safety, exists in certain model year 2017 to 2020 Rich Specialty Trailers, fifth wheels, or goosenecks built as a specialty trailer, restroom trailer, shower trailer, or movie star trailer. Certain Winntec model 6020 two-stage propane regulators installed on these vehicles may supply elevated, intermittent or low propane pressure to the appliances due to a second stage valve seat that can fail to regulate propane flow and pressure. An increase in propane pressure, could cause the flame of the appliance to become larger, and under certain rare circumstances, may ignite adjacent materials resulting in a fire. Appliances that can be affected by an excessive flame are the LP gas stovetop, LP gas oven, LP gas hot water heater, LP gas furnace and LP gas refrigerator. An increase in propane pressure would also cause the regulator to vent propane continuously through the pressure relief valve. In an enclosed area or under certain conditions, the vented propane could accumulate at the front of the specialty trailer and if ignited could result in a fire or explosion. Remedy consists of removing and replacing the propane regulator with a new regulator and performing standardized LP System Checks. The repair should take less than an hour to perform and this will be done at no labor or parts cost to the customer. Please see attached inspection and replacement procedures. Please submit photo of the regulator to our service department which can be done through email at SERVICE@RichTrailers.com , making certain the date code is clearly visible. Once the regulator is confirmed as part of this recall a replacement regulator will be shipped to you within 5 working days at no charge to you. As soon as you receive the replacement please schedule the replacement at your local RV or trailer repair center. After replacement is complete please submit a photo of the new regulator installed along with the repair invoice to Rich Specialty Trailers. Again, this can be emailed to SERVICE@RichTrailers.com Please contact our office as soon as possible to have this remedy completed. Our contact phone number is 260-593-2279 or you can email our service department at Service@RichTrailers.com. REASON FOR RECALL RECALL REMEDY WHAT WE NEED YOU TO DO If you had this repair completed prior to receipt of this recall notice, you may be eligible to receive reimbursement for the cost of obtaining a pre-notification remedy of the problem associated with this recall. Please provide proof of replacement along with an invoice and email to Service@RichTrailers.com for reimbursement. If you take your vehicle to your chosen service center on the agreed service date and the service center does not remedy this condition on that date or within three (3) days, please contact our Customer Service Department at 260 593 2279. If after contacting your dealer and Customer Service you are not able to have the safety defect remedied without charge and/or within a reasonable time, you may wish to submit a written complaint to the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Avenue, SE., Washington, DC 20590; or call the toll-free Vehicle Safety Hotline at 1-888-327-4236 (TTY: 1-800-424-9153): or go to http://www.safercar.gov. Federal regulations require that any vehicle lessor receiving this recall notice must forward a copy of this notice to the lessee within ten days. We certainly regret this inconvenience; however, your safety is our utmost priority. Sincerely, Rich Specialty Trailers 423 S. Main St. Topeka, IN 46571 1. Only the Winntec Model #6020 – Dual Stage Double Cylinder – Automatic Changeover Regulator with Pigtails is affected. Replace the regulator and pigtails if the manufacturing date code stamped into the regulator is 2017, 2018 or 2019. The regulator year of manufacture can be recognized by the first two numbers. (example: “19” indicates manufactured in 2019) The second two numbers indicate the week of manufacture and not a relevant number for this recall. See figure below. 1. Close the LP bottles and unscrew the pigtails from the LP bottles. 2. Remove the regulator from the unit. 3. Attach the new regulator to the unit. 4. Connect pigtails to LP bottles. 5. Check fittings, regulator, and connections using approved LP leak detection methods. 6. Proceed with a Drop Pressure Test: a. Insert manometer into LP system. b. Turn on both LP tanks. c. Turn off both LP tanks. d. Bleed system down to 8” water column. e. System must hold 8” water column for a minimum of 3 minutes. 7. Ensure system operating pressure is at 11” (+-0.5) water column with 50% load and lockout pressure does not exceed 14” water column. Kuntry Kustom RV, LLC warranty does not cover loss of use of product by Buyer either during production time before delivery by Seller or in loss of use of product due to warranty repairs necessary for operation of product. Additionally, the warranty does not cover Buyers extra expenses such as transportation to and from service center or manufacturing plant location, inconvenience, commercial loss, towing charges, bus fares, vehicle rental, charges such as telephone calls or lodging bills, or other incidental or consequential damages. This limited warranty shall not cover, and Seller shall not under any circumstances be liable for, damages for injuries to persons or property; loss of product; loss of profits; loss of use; expenses of labor, travel or other items relating to the removal, replacement or recall of defective goods; damages resulting from the removal of defective goods or the installation of repaired or replacement goods; expenses relating to the transportation of goods to and from Seller’s facility; damages resulting from any consequential, incidental, contingent or special damages, whether arising in contract, in tort or under statute; or any other damages or expenses not agreed upon in writing by Seller, even if Seller has been advised of the potential for any such damages or expenses. In no event shall Seller’s total liability exceed the specific purchase price of the subject goods. INSPECTION OF WINNTEC MODEL # 6020 LP REGULATOR REPLACING THE WINNTEC MODEL #6020 LP REGULATOR Kuntry Kustom RV, LLC dba Rich Specialty Trailers 423 S. Main St. Topeka, IN 46571
**************************************************************************************************************
IMPORTANT SAFETY RECALL – June 6nd, 2022 NHTSA Recall No. 22V-336 Dear Valued Dealer: This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act. Kuntry Kustom RV, LLC dba Rich Specialty Trailers has decided that a defect, which relates to motor vehicle safety, exists in certain model year 2017 to 2020 Rich Specialty Trailers, fifth wheels, or goosenecks built as a specialty trailer, restroom trailer, shower trailer, or movie star trailer. Certain Winntec model 6020 two-stage propane regulators installed on these vehicles may supply elevated, intermittent or low propane pressure to the appliances due to a second stage valve seat that can fail to regulate propane flow and pressure. An increase in propane pressure, could cause the flame of the appliance to become larger, and under certain rare circumstances, may ignite adjacent materials resulting in a fire. Appliances that can be affected by an excessive flame are the LP gas stovetop, LP gas oven, LP gas hot water heater, LP gas furnace and LP gas refrigerator. An increase in propane pressure would also cause the regulator to vent propane continuously through the pressure relief valve. In an enclosed area or under certain conditions, the vented propane could accumulate at the front of the specialty trailer and if ignited could result in a fire or explosion. Remedy consists of removing and replacing the propane regulator with a new regulator and performing standardized LP System Checks. The repair should take less than an hour to perform and this will be done at no labor or parts cost to the customer. Please see attached inspection and replacement procedures. Our records show the following units are affected by this recall, and is part of the current or sold inventory of your Dealership. (VIN NUMBER LISTING ATTACHED) To verify the regulator is part of this recall, please submit a photo of the regulator to our factory service department which can be done through email at SERVICE@RichTrailers.com , making certain the date code is clearly visible. Once the regulator is confirmed as part of this recall, a replacement regulator will be shipped to you within 5 working days at no charge to you. Please replace as soon as you REASON FOR RECALL RECALL REMEDY WHAT WE NEED YOU TO DO receive the part. After replacement is complete please submit a photo of the new regulator installed along with the repair invoice to Rich Specialty Trailers. Again, this can be emailed to SERVICE@RichTrailers.com Please contact our office as soon as possible to have this remedy completed. Our contact phone number is 260-593-2279 or you can email our service department at Service@RichTrailers.com. Federal law requires the Recall Remedy completed on this unit prior to customer delivery. If you had this repair completed prior to receipt of this recall notice, you may be eligible to receive reimbursement for the cost of obtaining a pre-notification remedy of the problem associated with this recall. Please provide proof of replacement along with an invoice and email to Service@RichTrailers.com for reimbursement. If you sold this unit recently, please contact the owner immediately to inform them of this recall. In addition, please register this unit by submitting the Warranty Registration information. Federal regulations require that any vehicle lessor receiving this recall notice must forward a copy of this notice to the lessee within ten days. We certainly regret this inconvenience; however, our Customers’ safety is our most important priority. Sincerely, Rich Specialty Trailers 423 S. Main St. Topeka, IN 46571 1. Only the Winntec Model #6020 – Dual Stage Double Cylinder – Automatic Changeover Regulator with Pigtails is affected. Replace the regulator and pigtails if the manufacturing date code stamped into the regulator is 2017, 2018 or 2019. The regulator year of manufacture can be recognized by the first two numbers. (example: “19” indicates manufactured in 2019) The second two numbers indicate the week of manufacture and not a relevant number for this recall. See figure below. 1. Close the LP bottles and unscrew the pigtails from the LP bottles. 2. Remove the regulator from the unit. 3. Attach the new regulator to the unit. 4. Connect pigtails to LP bottles. 5. Check fittings, regulator, and connections using approved LP leak detection methods. 6. Proceed with a Drop Pressure Test: a. Insert manometer into LP system. b. Turn on both LP tanks. c. Turn off both LP tanks. d. Bleed system down to 8” water column. e. System must hold 8” water column for a minimum of 3 minutes. 7. Ensure system operating pressure is at 11” (+-0.5) water column with 50% load and lockout pressure does not exceed 14” water column. Kuntry Kustom RV, LLC warranty does not cover loss of use of product by Buyer either during production time before delivery by Seller or in loss of use of product due to warranty repairs necessary for operation of product. Additionally, the warranty does not cover Buyers extra expenses such as transportation to and from service center or manufacturing plant location, inconvenience, commercial loss, towing charges, bus fares, vehicle rental, charges such as telephone calls or lodging bills, or other incidental or consequential damages. This limited warranty shall not cover, and Seller shall not under any circumstances be liable for, damages for injuries to persons or property; loss of product; loss of profits; loss of use; expenses of labor, travel or other items relating to the removal, replacement or recall of defective goods; damages resulting from the removal of defective goods or the installation of repaired or replacement goods; expenses relating to the transportation of goods to and from Seller’s facility; damages resulting from any consequential, incidental, contingent or special damages, whether arising in contract, in tort or under statute; or any other damages or expenses not agreed upon in writing by Seller, even if Seller has been advised of the potential for any such damages or expenses. In no event shall Seller’s total liability exceed the specific purchase price of the subject goods. INSPECTION OF WINNTEC MODEL # 6020 LP REGULATOR REPLACING THE WINNTEC MODEL #6020 LP REGULATOR Kuntry Kustom RV, LLC dba Rich Specialty Trailers 423 S. Main St. Topeka, IN 46571
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-336 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Kuntry Kustom RV, LLC Submission Date : MAY 31, 2022 NHTSA Recall No. : 22V-336 Manufacturer Recall No. : NR Manufacturer Information : Manufacturer Name : Kuntry Kustom RV, LLC Address : 423 S. Main St. Topeka, IN 46571 Company phone : 593-2208 Population : Number of potentially involved : 172 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2017-2020 Rich Specialty Trailers Sanitation, Movie, Office, Bunk House Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : Supplier provided component with possibly defective. Supplier provided dates and serial codes of affected parts. Supplier provided total number of purchased components that could have been installed in the products. 172 possible defective regulators used in LP gas systems in trailers. Production Dates : JAN 01, 2017 – JUN 30, 2020 VIN Range 1 : Begin : 1k9bu2429h1236065 End : 1k9bu2025l1236238 Not sequential Description of Defect : Description of the Defect : LP regulator may fail. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : Failure of the LP regulator may cause an excessive flame in LP appliance and in certain conditions may ignite adjacent materials resulting in a fire. Description of the Cause : Failure of installed component Winntec model 6020 two stage propane regulators. Identification of Any Warning that can Occur : NR Involved Components : Part 573 Safety Recall Report 22V-336 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : Winntec model 6020 regulator Component Description : LP regulator Component Part Number : 6020 Regulator Supplier Identification : Component Manufacturer Name : UFP Distribution Address : 2701 ADA Dr Elkhart Indiana 46514 Country : United States Chronology : Jan 4rth 2022-Notified by NHTSA of possible safety defect. Feb 8th 2022-Reviewed service records and while no reports of injury, no deaths, no field reports of problems and no regulator problems the decision is made to recall. May 12th 2022- Received notice from supplier that the replacement component/regular is back in stock so can now offer replacement part. May 13th 2022- Submitted letter and notice to NHTSA Description of Remedy : Description of Remedy Program : Identify, confirm, and replace possible defective part at no charge and reimburse labor costs for replacement. How Remedy Component Differs from Recalled Component : Possible defective part will be replaced with new LP regulator from a different component manufacturer. Identify How/When Recall Condition was Corrected in Production : Stopped use of this defective component approximately two years ago. Recall Schedule : Description of Recall Schedule : NR Planned Dealer Notification Date : JUN 06, 2022 – JUN 10, 2022 Planned Owner Notification Date : JUN 06, 2022 – JUN 10, 2022 * NR – Not Reported
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-336 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Kuntry Kustom RV, LLC Submission Date : MAY 24, 2022 NHTSA Recall No. : 22V-336 Manufacturer Recall No. : NR Manufacturer Information : Manufacturer Name : Kuntry Kustom RV, LLC Address : 423 S. Main St. Topeka, IN 46571 Company phone : 593-2208 Population : Number of potentially involved : 172 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2017-2020 Rich Specialty Trailers Sanitation, Movie, Office, Bunk House Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : Supplier provided component with possibly defective. Supplier provided dates and serial codes of affected parts. Supplier provided total number of purchased components that could have been installed in the products. 172 possible defective regulators used in LP gas systems in trailers. Production Dates : JAN 01, 2017 – JUN 30, 2020 VIN Range 1 : Begin : 1k9bu2429h1236065 End : 1k9bu2025l1236238 Not sequential Description of Defect : Description of the Defect : LP regulator may fail. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : Failure of the LP regulator may cause an excessive flame in LP appliance and in certain conditions may ignite adjacent materials resulting in a fire. Description of the Cause : Failure of installed component Winntec model 6020 two stage propane regulators. Identification of Any Warning that can Occur : NR Involved Components : Part 573 Safety Recall Report 22V-336 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : Winntec model 6020 regulator Component Description : LP regulator Component Part Number : 6020 Regulator Supplier Identification : Component Manufacturer Name : UFP Distribution Address : 2701 ADA Dr Elkhart Indiana 46514 Country : United States Chronology : Jan 4rth 2022-Notified by NHTSA of possible safety defect. Feb 8th 2022-Reviewed service records and while no reports of injury, no deaths and no regulator problems the decision is made to recall. May 12th 2022- Received notice from supplier that the replacement component/regular is back in stock so can now offer replacement part. May 13th 2022- Submitted letter and notice to NHTSA Description of Remedy : Description of Remedy Program : Identify, confirm, and replace possible defective part at no charge and reimburse labor costs for replacement. How Remedy Component Differs from Recalled Component : Possible defective part will be replaced with new LP regulator from a different component manufacturer. Identify How/When Recall Condition was Corrected in Production : Stopped use of this defective component approximately two years ago. Recall Schedule : Description of Recall Schedule : NR Planned Dealer Notification Date : MAY 17, 2022 – MAY 24, 2022 Planned Owner Notification Date : MAY 17, 2022 – MAY 24, 2022 * NR – Not Reported
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-336 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Kuntry Kustom RV, LLC Submission Date : MAY 24, 2022 NHTSA Recall No. : 22V-336 Manufacturer Recall No. : NR Manufacturer Information : Manufacturer Name : Kuntry Kustom RV, LLC Address : 423 S. Main St. Topeka, IN 46571 Company phone : 593-2208 Population : Number of potentially involved : 172 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2017-2020 Rich Specialty Trailers Sanitation, Movie, Office, Bunk House Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : Supplier provided component with possibly defective. Supplier provided dates and serial codes of affected parts. Supplier provided total number of purchased components that could have been installed in the products. 172 possible defective regulators used in LP gas systems in trailers. Production Dates : JAN 01, 2017 – JUN 30, 2020 VIN Range 1 : Begin : 1k9bu2429h1236065 End : 1k9bu2025l1236238 Not sequential Description of Defect : Description of the Defect : LP regulator may fail. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : Failure of the LP regulator may cause an excessive flame in LP appliance and in certain conditions may ignite adjacent materials resulting in a fire. Description of the Cause : Failure of installed component Winntec model 6020 two stage propane regulators. Identification of Any Warning that can Occur : NR Involved Components : Part 573 Safety Recall Report 22V-336 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : Winntec model 6020 regulator Component Description : LP regulator Component Part Number : 6020 Regulator Supplier Identification : Component Manufacturer Name : UFP Distribution Address : 2701 ADA Dr Elkhart Indiana 46514 Country : United States Chronology : Jan 4rth 2022-Notified by NHTSA of possible safety defect. Feb 8th 2022-Reviewed service records and while no reports of injury, no deaths and no regulator problems the decision is made to recall. May 12th 2022- Received notice from supplier that the replacement component/regular is back in stock so can now offer replacement part. May 13th 2022- Submitted letter and notice to NHTSA Description of Remedy : Description of Remedy Program : Identify, confirm, and replace possible defective part and reimburse labor costs for replacement. How Remedy Component Differs from Recalled Component : Possible defective part will be replaced with new LP regulator from a different component manufacturer. Identify How/When Recall Condition was Corrected in Production : Stopped use of this defective component approximately two years ago. Recall Schedule : Description of Recall Schedule : NR Planned Dealer Notification Date : MAY 17, 2022 – MAY 24, 2022 Planned Owner Notification Date : MAY 17, 2022 – MAY 24, 2022 * NR – Not Reported
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-336 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Kuntry Kustom RV, LLC Submission Date : MAY 24, 2022 NHTSA Recall No. : 22V-336 Manufacturer Recall No. : NR Manufacturer Information : Manufacturer Name : Kuntry Kustom RV, LLC Address : 423 S. Main St. Topeka, IN 46571 Company phone : 593-2208 Population : Number of potentially involved : 172 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2017-2020 Rich Specialty Trailers Sanitation, Movie, Office, Bunk House Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : Supplier provided component with possibly defective. Supplier provided dates and serial codes of affected parts. Supplier provided total number of purchased components that could have been installed in the products. 172 possible defective regulators used in LP gas systems in trailers. Production Dates : JAN 01, 2017 – JUN 30, 2020 VIN Range 1 : Begin : 1k9bu2429h1236065 End : 1k9bu2025l1236238 Not sequential Description of Defect : Description of the Defect : LP regulator may fail. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : Failure of the LP regulator may cause an excessive flame in LP appliance and in certain conditions may ignite adjacent materials resulting in a fire. Description of the Cause : Failure of installed component Winntec model 6020 two stage propane regulators. Identification of Any Warning that can Occur : NR Involved Components : Part 573 Safety Recall Report 22V-336 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : Winntec model 6020 regulator Component Description : LP regulator Component Part Number : 6020 Regulator Supplier Identification : Component Manufacturer Name : UFP Distribution Address : 2701 ADA Dr Elkhart Indiana 46514 Country : United States Chronology : Jan 4rth 2022-Notified by NHTSA of possible safety defect. Feb 8th 2022-Reviewed service records and while no reports of injury, no deaths, no field reports of problems and no regulator problems the decision is made to recall. May 12th 2022- Received notice from supplier that the replacement component/regular is back in stock so can now offer replacement part. May 13th 2022- Submitted letter and notice to NHTSA Description of Remedy : Description of Remedy Program : Identify, confirm, and replace possible defective part at no charge and reimburse labor costs for replacement. How Remedy Component Differs from Recalled Component : Possible defective part will be replaced with new LP regulator from a different component manufacturer. Identify How/When Recall Condition was Corrected in Production : Stopped use of this defective component approximately two years ago. Recall Schedule : Description of Recall Schedule : NR Planned Dealer Notification Date : MAY 17, 2022 – MAY 24, 2022 Planned Owner Notification Date : MAY 17, 2022 – MAY 24, 2022 * NR – Not Reported
**************************************************************************************************************
OMB Control No.: 2127-0004 Part 573 Safety Recall Report 22V-336 The information contained in this report was submitted pursuant to 49 CFR §573 Manufacturer Name : Kuntry Kustom RV, LLC Submission Date : MAY 13, 2022 NHTSA Recall No. : 22V-336 Manufacturer Recall No. : NR Manufacturer Information : Manufacturer Name : Kuntry Kustom RV, LLC Address : 423 S. Main St. Topeka, IN 46571 Company phone : 593-2208 Population : Number of potentially involved : 172 Estimated percentage with defect : 1 % Vehicle Information : Vehicle 1 : 2017-2020 Rich Specialty Trailers Sanitation, Movie, Office, Bunk House Vehicle Type : TRAILERS Body Style : OTHER Power Train : NR Descriptive Information : Supplier provided component with possibly defective. Supplier provided dates and serial codes of affected parts. Supplier provided total number of purchased components that could have been installed in the products. 172 possible defective regulators used in LP gas systems in trailers. Production Dates : JAN 01, 2017 – JUN 30, 2020 VIN Range 1 : Begin : 1k9bu2429h1236065 End : 1k9bu2025l1236238 Not sequential Description of Defect : Description of the Defect : LP regulator may fail. FMVSS 1 : NR FMVSS 2 : NR Description of the Safety Risk : Failure of the LP regulator may cause an excessive flame in LP appliance and in certain conditions may ignite adjacent materials resulting in a fire. Description of the Cause : Failure of installed component Winntec model 6020 two stage propane regulators. Identification of Any Warning that can Occur : NR Involved Components : Part 573 Safety Recall Report 22V-336 Page 2 The information contained in this report was submitted pursuant to 49 CFR §573 Component Name 1 : Winntec model 6020 regulator Component Description : LP regulator Component Part Number : 6020 Regulator Supplier Identification : Component Manufacturer Name : UFP Distribution Address : 2701 ADA Dr Elkhart Indiana 46514 Country : United States Chronology : Notified by NHTSA of possible safety defect. Description of Remedy : Description of Remedy Program : Identify, confirm, and replace possible defective part and reimburse labor costs for replacement. How Remedy Component Differs from Recalled Component : Possible defective part will be replaced with new LP regulator from a different component manufacturer. Identify How/When Recall Condition was Corrected in Production : Stopped use of this defective component approximately two years ago. Recall Schedule : Description of Recall Schedule : NR Planned Dealer Notification Date : MAY 17, 2022 – MAY 24, 2022 Planned Owner Notification Date : MAY 17, 2022 – MAY 24, 2022 * NR – Not Reported
SEOCONTENT-END