Loose Wiring May Cause Fire – 2022 Alliance RV Paradigm, Valor, & Avenue Travel Trailers

“This site contains affiliate links for which OEMDTC may be compensated”

March 23, 2022 NHTSA CAMPAIGN NUMBER: 22V174000

Loose Wiring May Cause Fire

Loose wiring can cause an electrical arc or short, increasing the risk of a fire.

 

NHTSA Campaign Number: 22V174

Manufacturer Alliance RV, LLC

Components ELECTRICAL SYSTEM, EQUIPMENT

Potential Number of Units Affected 293

 

Summary

Alliance RV, LLC (Alliance RV) is recalling certain 2022 Paradigm, Valor, and Avenue travel trailers, equipped with a 50-amp shore power inlet. The power inlet lug bolts may have been manufactured with excessively hard metal, preventing them from being tightened properly and resulting in a loose wiring connection.

 

Remedy

Dealers will inspect and replace the power inlet, as necessary, free of charge. Owner notification letters were mailed April 25, 2022. Owners may contact Alliance RV customer service at 1-574-218-7165.

 

Notes

Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.nhtsa.gov.

 


****Product Safety Notice***

 

March, 14, 2022

We have determined that a potential defect which relates to the safety of the end consumer exists in your unit.

If you are reading this then your manufacturer has already notified you of a potential issue with your unit. Refer to your Original Equipment Manufacturer’s notice for specific vehicle identification number (VIN#) and please follow instructions included below.

 

EPICORD 50A POWER INLET REVIEW PROCEDURE

STEP 1.  Locate the 50A inlet on the side or rear of the RV in question to determine what brand of power inlet is installed.  If the inlet is EPICORD brand and looks like the below picture, proceed to step 2. If the Inlet on your unit looks different than the picture below, a substitution may have been made at the OEM and no further action is needed.

 

STEP 2.  Move to the inside of the RV to locate the load center.  Once the load center is located, turn the 50A main breaker to the OFF position.

 

STEP 3.  After turning the 50A main breaker to the OFF position, remove the four mounting screws located on the face of the inlet and pull the inlet out of the RV wall.

SAVE THESE SCREWS AS THEY WILL BE NEEDED TO REINSTALL THE INLET.  

 

STEP 4. After pulling the inlet out of the RV wall, remove the two screws on the inside of the inlet. This will allow you to remove the housing from the back side of the inlet.

 

STEP 5. Unscrew the strain relief on the back of the housing to allow room for the wires to move.

 

STEP 6.  First make a visual inspection of wires. Make sure they are seated properly within the lugs so that there is no sheathing or wire jacket under the lugs preventing proper securement. Once visual inspection looks correct, check EACH lug for proper torque setting of 20 in/lb. If torque specification is met, on EACH lug then skip to steps 13-16 for reinstallation.

 

****WARNING****

If torque specification cannot be met, the part is defective and needs replaced. This will be evident by the torque screwdriver slipping off of the lug prior to reaching the specified 20in/lbs.

If the Inlet is deemed defective, please proceed to step 7 for replacement instructions.

 

STEP 7. Loosen each of the lugs which are securing the four wires into the body of the device. Pull the wires out of the device and through the strain relief located on the back side of the device.

 

STEP 8. Cut the 6/3 wire so that you are starting with fresh wire leads.

 

STEP 9.  Strip back 1 1/2” of exterior sheathing detail (A) for ease of wire hook up. Inspect each wire for any signs of bare copper around sheathing. If any signs of bare copper make sure to cut out bad wire and start process over again. Straighten out the individual wires to orient them roughly in a straight line.   Strip back conductor jacket back 3/4” in detail (B) from wire for proper application.

 

STEP 10.   After all four wires have been properly prepared, loosen the strain relief before running wires through the back side of the housing utilizing the round hole in the back body of the inlet.  * DO NOT TIGHTEN CONNECTOR ONTO THE WIRE YET. *

 

STEP 11.   Insert each individual wire into its appropriate connection.

a. Black wire goes into the hole marked black.

b. White wire goes into the hole marked white.

c. Red wire goes into the hole marked red.

d. Bare copper wire (ground) goes into the hole marked green.

 

STEP 12.   Insert each wire completely into its appropriate lug and screw it down making sure there is no sheathing or conductor jacket under the lugs. Torque each connection lug to the manufacturer’s recommended setting of 20 inch pounds.

 

STEP 13.  Slide the back body of the device down the wire and align properly with the back of inlet.

 

STEP 14.  Reinstall the 2 screws to secure housing to inlet and tighten the rear strain relief.

 

STEP 15. Re-insert the EPICORD 50A inlet back into the wall of the RV and secure using the four screws removed in step 4 above.  Please be sure to clear away any old caulking and reseal as per manufacturers standard operating procedure.

 

STEP 16. Proceed inside the unit and turn the 50A main breaker located in the load center to the ON position.  You have now completed the reinstallation of your 50A EPICORD inlet.

 


Chronology :

Alliance RV was notified on 3/22/22 via email from our vendor Patrick Industries of the component issue. At that point, all RVs on site that fell in scope were checked and appropriate action taken. After turning the 50A main breaker to the OFF position, remove the four mounting screws located on the face of the inlet and pull the inlet out of the RV wall.

SAVE THESE SCREWS AS THEY WILL BE NEEDED TO REINSTALL THE INLET. After pulling the inlet out of the RV wall, remove the two screws on the inside of the inlet. This will allow you to remove the housing from the back side of the inlet. Unscrew the strain relief on the back of the housing to allow room for the wires to move.

 


22E023 – Loose Wiring May Cause Fire – ZH Brothers Epicord 50-amp Shore Power Inlets

 

22E023 – Loose Wiring May Cause Fire – ZH Brothers Epicord 50-amp Shore Power Inlets

 


3 Affected Products

Vehicles

MAKE MODEL YEAR
ALLIANCE RV AVENUE 2022
ALLIANCE RV PARADIGM 2022
ALLIANCE RV VALOR 2022

 


9 Associated Documents

Recall 573 Report – 3/24/2022

RCLRPT-22V174-6260.PDF 214.621KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [209.59 KB]

 


Defect Notice 573 Report

RCLRPT-22V174-3693.PDF 214.611KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [209.58 KB]

 


Remedy Instructions and TSB

RCRIT-22V174-2844.pdf 678.029KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [662.14 KB]

 


Recall Acknowledgement

RCAK-22V174-2723.pdf 645.865KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [630.73 KB]

 


Recall 573 Report – 6/27/2022

RCLRPT-22V174-7839.PDF 214.605KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [209.58 KB]

 


Recall Quarterly Report #1, 2022-2

RCLQRT-22V174-1641.PDF 211.135KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [206.19 KB]

 


Recall Quarterly Report #2, 2022-3

RCLQRT-22V174-1689.PDF 211.236KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [206.29 KB]

 


Recall Quarterly Report #3, 2022-4

RCLQRT-22V174-7348.PDF 211.321KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [206.37 KB]

 


Owner Notification Letter(Part 577)

RCONL-22V174-9762.pdf 204.306KB

Loader Loading...
EAD Logo Taking too long?

Reload Reload document
| Open Open in new tab

Download [199.52 KB]

 


Latest Recalls Documents

For the Latest and Most Recent Recalls Information Visit the link below…

https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=22V174&docType=RCL

 


 

“This site contains affiliate links for which OEMDTC may be compensated”
SaleBestseller No. 1
PAULINN 15 Amp 125V AC Power Inlet Port Plug W/Integrated Dual 18" Extension Cord, NEMA 5-15 RV Flanged Inlet Y Splitter Cable with Waterproof & Back Cover, 2 Pole 3-Wire Shore Power Plug for Boat
  • 15 Amp, 125 Volts, 2-pole, 3-wire weatherproof flanged inlet with covers. Wiring Gauge 12-18 AWG, Cord Grip for use with No. 12-3 through No. 18-3 cords
  • Premium nickel coated copper and tough black nylon resist damage of uv, impact and abrasion. Rugged and durable for outdoor use.
  • Wire up as you wish. 2” hole size needed; see-thru wiring block & color-coded positive crimp lock wire clamps make it easy to install.
  • ETL approved. Integrated cover to protect contacts from the rain storm, snows, dust and even works well in Western Colorado winters while plug is not in use
  • Designed to be hardwired directly to charger. Widely used in trailer, camper, RV, car, boat, marine, block heater, home, bumper, recessed outlet box, etc
SaleBestseller No. 2
Furrion F30INS-BS-AM Black Square 30 Amp RV Inlet with Stainless Steel Plate and Power Smart LED
  • Power smart LED
  • Stainless steel plate
  • Stay open cap
  • Heavy duty marine grade materials
Bestseller No. 3
Veepeak 30 Amp Shore Power Inlet NEMA L5-30P 125V Twist Locking Plug for Boat RV Trailer Camper Van, ETL Listed
  • NEMA L5-30P power inlet suitable for building or replacing worn electric power connections on boats, RVs or trailers.
  • ETL Listed, features heavy-duty construction and weather & corrosion-resistant material, plus watertight cap for reliable performance in tough environments.
  • Specs: 125 Volt, 30 Amp, 3750 Watt, 3-wire locking. 3.7"L X 3 .3"W X 3.2"H - Cutout 2.7", with 4 x 8 Pan Head Stainless Steel Screws.
  • Comes with clear and easy to follow instructions and easy to lock system for quick installation and use.
  • WHAT YOU'LL GET: 1 x 30 Amp Power Inlet with installation instructions, plus Veepeak one-year hassle-free replacement warranty and friendly customer service.
SaleBestseller No. 4
NOCO GCP1 15A AC Port Plug, 125V Power Inlet Socket, and Waterproof Electrical Outlet Receptacle Box with 16-Inch Integrated Outdoor Extension Cord
  • AC Port Plug - A 125-volt power inlet socket with an integrated 16-inch outdoor extension cord for a car, boat, marine, truck, trailer, pickup, RV, industrial and electrical applications.
  • Waterproof - A rugged, waterproof ac electrical power inlet receptacle featuring a pressure fit rubberized cover rated for outdoor use and protects against the elements.
  • Peak Performance - Rated at 15-amps with heavy-duty 14 AWG copper wiring to maximum power flow and full-sized AC port prongs for maximum conductivity.
  • Plug-N-Play - A simple flush mount flanged power inlet that's easy to install, requiring zero cable modification or hand wiring, and mounts into a 2-inch hole size.
  • Multiple Uses - An outdoor extension cord designed for various uses, including onboard battery chargers, bumpers for engine block heaters, outdoor electrical outlets, and more.
Bestseller No. 5
Nilight 30AMP RV Power Inlet Outlet Shore Power Kit w/Boot Cord Protector ETL Listed 125V NEMA L5-30P L5-30R Twist Lock Male Female Connector Plug for RV Camper Caravan Trailer Van, 2 Years Warranty
  • 30AMP RV Power Plug Kit: NEMA L5-30P Male Plug and NEMA L5-30R Female Connector. Weather-proof boot cord protector with locking ring. Rated for 30AMP 125V, this RV Plug Kit is widely used in RVs, campers, trailers, boats, caravans, motorhomes, and vans. With a lock ring sleeve, the connector is waterproof and dustproof.
  • Superior Quality: Constructed with heavy duty ABS material housing, it is resistant to high temperatures and flame. No oxidation for the Nickel coated copper pole on the plug, made of premium copper and durable plastic to avoid the damage of UV degradation and chemicals. The weatherproof cover boot is made of quality PVC material, which is high temperature resistance and protect the connector better.
  • ETL Certified: Our RV Power Inlet has been tested at an ETL laboratory and found to meet all applicable Standards for Safety published by relevant NRTLs. ETL certification follows the same safety standards as Underwriter Laboratories or UL.
  • Easy Installation: Colored-terminals provide an easy and convenient installation. Green terminal connects to Ground wire, black terminal connects to hot wire, white terminal connects to neutral wire. Terminals accept for #10-8 AWG wires.
  • Package includes: 30 Amp RV Power Inlet Box, 30 Amp Connector, weatherproof cover boot with locking ring, installation guidance. 2 Year Warranty by Nilight.
SaleBestseller No. 6
PAULINN 15 Amp 125V AC Power Inlet Port Plug with Integrated 18" Extension Cord, NEMA 5-15 RV Flanged Inlet w/Waterproof & Back Cover, 2 Pole 3-Wire Shore Power Plug for RV, Truck, Boat, Generator
  • 15 Amp, 125 Volts, 2-pole, 3-wire weatherproof flanged inlet with covers. Wiring Gauge 12-18 AWG, Cord Grip for use with No. 12-3 through No. 18-3 cords
  • Premium nickel coated copper and tough black nylon resist damage of uv, impact and abrasion. Rugged and durable for outdoor use.
  • Wire up as you wish. 2” hole size needed; see-thru wiring block & color-coded positive crimp lock wire clamps make it easy to install.
  • ETL approved. Integrated cover to protect contacts from the rain storm, snows, dust and even works well in Western Colorado winters while plug is not in use
  • Designed to be hardwired directly to charger. Widely used in trailer, camper, RV, car, boat, marine, block heater, home, bumper, recessed outlet box, etc
SaleBestseller No. 7
WELLUCK 15 Amp Flanged Inlet 125V, NEMA 5-15 RV Shore Power Inlet Plug w/Waterproof and Back Cover, 2 Pole 3-Wire AC Port Plug, Generator Male Receptacle for Marine Boat RV Shed Electrical Extension
  • 【15 Amp Flanged Inlet】: No oxidation for the Nickel coated copper pole on the plug, made of premium copper and Nylon plastic to avoid the damage of UV degradation and chemicals, rugged and durable for indoor and outdoor.
  • 【Easy Reliable Installation】: 2" Hole size required, clear see-thru wiring block (Black-Hot, Green-Ground, Silver-Neutral), and 4 long Stainless Steel screws will fix straight blade flanged inlet on the hole or wall more tightly. No gap on the edge!
  • 【 Weatherproof Cover】: ETL approved, and the flanged power inlet cap and back cover will protect it from the rain storm, snows, dust and even works well in Western Colorado winters, without crack and leak.
  • Wire Up As You Wish】 : Define the Length and Diameter of the cord based on actual need. Flanged electrical inlet receptacle accommodates 12-18 AWG gauge wires, suitable for No. 12-3 through No. 18-3 cords grip.
  • 【Widely Compatible】: As a generator or battery charger plug to energize your electrical devices. Widely used in trailer, camper, RV, car, boat, marine, block heater,home, bumper, recessed outlet box, etc
SaleBestseller No. 8
Leviton 5278-CWP Straight Blade Flanged Male Power Inlet Receptacle, 15 A, 125 V, Nylon Face, Body and Strap, Gray
  • Super Tough Nylon Body Resists Damage From Severe Impact, Abrasion and Chemicals
  • NEMA and Non-NEMA Configurations Available
  • Positive Crimp Lock Wire Clamps
  • Model number: 5278-CWP
SaleBestseller No. 9
WELLUCK 15 Amp 125V AC Power Inlet Port Plug with Integrated Dual 18" Extension Cord, NEMA 5-15 RV Flanged Inlet with Waterproof Back Cover Y Splitter Cable, Shore Power Inlet Plug for RV Car Boat
  • 【15 Amp Flanged Inlet】: No oxidation for the Nickel coated copper pole on the plug, made of premium copper and Nylon plastic to avoid the damage of UV degradation and chemicals, rugged and durable for indoor and outdoor.
  • 【Easy Reliable Installation】: 2" Hole size required, 4 long Stainless Steel screws will fix straight blade flanged inlet on the hole or wall more tightly. No gap on the edge!
  • 【 Weatherproof Cover】: ETL approved, and the rv electrical outlet cap and back cover will protect it from the rain storm, snows, dust and even works well in Western Colorado winters, without crack and leak.
  • 【No Need to Wire Up】 : The male receptacle is already wired up by 2 x 14AWG 18 inch extension cable with NEMA5-15R. Just plug in to connect the power.
  • 【Widely Compatible】: As a generator or battery charger plug to energize your electrical devices. Widely used in trailer, camper, RV, car, boat, marine, block heater,home, bumper, recessed outlet box, etc
Bestseller No. 10
True Mods 30A Inlet Shore Power Supply Receptacle for RV Camper Boat [NEMA L5-30P 125V] [Twist-Lock] [Low-Profile] [LED Indicator] [Dust/Waterproof] [3/14AWG Compatible] [ETL Approved] [UV Resistant]
  • ASCEND BOUNDARIES - 30 and 50 amps pack a punch, but when you add this NEMA L5-30P or SS2-50P power inlet to your RV or boat for extra juice on power-hungry appliances, you just may reach the stars.
  • ELECTRIC BEAUTY - Whoever said, "looks don't matter" was lying; it isn't shallow to appreciate the beauty of this 1.25" low profile inlet power kit with LED indicator as it provides shore power or campsite energy.
  • COMBAT CONTAMINATION - Water and dust are electrical systems' worst enemy, so help the inlet fight back by using the solid and stylish cover lid to keep out gunk!
  • ASSEMBLED BY YOU - Why should the installation be a pain and only achievable by skilled mechanics? Show your worth and install this kit all better than any mechanic with the self-supplied 10/3AWG and 6/3+8/1AWG power wire cords.
  • BE SMART, STAY SAFE - Trust the premium quality from us to power your equipment; True Mods' inlet provides energy safely for the family due to its trusted ETL certification and twist-lock design.

Last update on 2024-04-13 / Affiliate links / Images from Amazon Product Advertising API

This product presentation was made with AAWP plugin.

 


Leave a Comment

Share to...