“This site contains affiliate links for which OEMDTC may be compensated” |
April 9, 2018 NHTSA CAMPAIGN NUMBER: 18V223000
If the left taillight does not work, the coach would have reduced visibility to other drivers, increasing the risk of a crash.
NHTSA Campaign Number: 18V223
Manufacturer Motor Coach Industries
Components ELECTRICAL SYSTEM, EXTERIOR LIGHTING
Potential Number of Units Affected 197
Summary
Motor Coach Industries (MCI) is recalling certain 2018 J4500 vehicles. The left rear taillight harness branch of the engine compartment wiring may contact the engine coolant tank causing a loss of power to the left taillight. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, “Lamps, Reflective Devices, and Associated Equipment.”
Remedy
MCI will notify owners, and dealers will inspect the left taillight wiring harness, re-routing and repairing it as necessary, free of charge. The recall began on April 23, 2018. Owners may contact MCI customer service at 1-800-241-2947. MCI’s number for this recall is SB 461.
Notes
Owners may also contact the National Highway Traffic Safety Administration Vehicle Safety Hotline at 1-888-327-4236 (TTY 1-800-424-9153), or go to www.safercar.gov.
April 23, 2018
IMPORTANT SAFETY RECALL
This notice applies to your vehicle(s) [«UNIT»]
«CUST_NAME»
ATTENTION: TECH SERVICE DEPT/MAINT
«ADDRESS_1»
«CITY», «STATE» «ZIP»
SUBJECT: | SAFETY RECALL: LEFT TAIL LAMP WIRING HARNESS |
Ref.: | NHTSA # 18V-223 Transport Canada # 2018-170 MCI Service Bulletin 461 |
Attention Owner:
This notice is sent to you in accordance with the National Traffic and Motor Vehicle Safety Act and the Canadian Motor Vehicle Safety Act.
Motor Coach Industries, Inc. has become aware that on certain model year 2018 MCI J4500 coaches, the left hand tail lamp harness branch of the engine compartment wiring harness may chafe against the engine coolant tank. If this occurs, the chafing could damage the wires and cause a loss of power to the left tail lamp lights, resulting in a noncompliance with FMVSS 108. Failure of the left hand tail lamp lighting could result in vehicles following the affected coach to experience reduced indication of the coach turning or stopping. At night, the loss of the left hand tail lamp will reduce the rear visibility of the coach. Reduced visibility of the coach during turning, stopping, and at night could result in a crash and cause personal injury.
MCI is conducting a recall to repair the affected vehicles. The recall work will be provided at no cost to you, and is estimated to take a half hour to complete. Please see the enclosed MCI Service Bulletin 461 for further information.
MCI records indicate that you are the owner or operator of the following vehicle(s) included in this recall:
«UNIT»
MCI strongly urges you to have the recall work performed on your vehicle(s) as quickly as possible.
You may contact the MCI Customer Service Line at 1-800-241-2947 if you have any questions about this recall campaign or wish to make arrangements to have your vehicle(s) repaired at an authorized MCI service center. Submittal of MCI Warranty Claim Forms may be completed on MCI’s website at https://fleetsupportiw.mcicoach.com/iwarranty/signon (click on Customer Care System), or a photocopy of the Warranty Claim Form found in the Warranty Manual can be mailed / faxed to the MCI Warranty Department. Please refer to Service Bulletin 461, and your OWNER LIMITED WARRANTY MANUAL, for more detailed information.
After contacting MCI Customer Service, if you are still unable to have the safety defect remedied without charge and within a reasonable time, you may submit a complaint:
For US customers:
You may submit a written complaint to the Administrator, National Highway Traffic Safety Administration, 1200 New Jersey Avenue, SE, Washington, DC 20590, or call 888 327-4236 (TTY: 800-424-9153), or go to https://www.safercar.gov if remedy difficulties exist.
For Canadian customers:
Please contact our customer service at 1-800-241-2947, or for additional information about the recall, you can contact Transport Canada at 1-800-333-0510.
If you are the lessor of the vehicle(s) identified above, Federal law requires that you forward this notice by first class mail to the most recent lessee(s) known to you, within ten days of your receipt of this notice.
If you have sold or otherwise transferred the vehicle(s) identified above, please contact the MCI Customer Service Line at 1-800-241-2947 with all of the information you have regarding the current owner/operator of the vehicle(s).
If you had your vehicle repaired for this condition prior to receipt of this notice and incurred any costs, you may be eligible for reimbursement. Please contact the MCI Customer Service Line at 1-800-241-2947 for further information in that regard.
We regret the inconvenience this may cause you, but urge you to implement the recall procedures with respect to your vehicle(s) as soon as possible for your added safety and satisfaction.
Sincerely,
Motor Coach Industries
Warranty Department
Enclosure: MCI Service Bulletin 461
1 Affected Product
Vehicle
MAKE | MODEL | YEAR |
MCI | J4500 | 2018 |
9 Associated Documents
Remedy Instructions and TSB
RCRIT-18V223-8205.pdf 187.618KB
Recall Acknowledgement
Non-Compliance Notice 573 Report/FMVSS 108
RCLRPT-18V223-6568.pdf 215.642KB
Recall 573 Report- Amendment 3
RCLRPT-18V223-8547.PDF 215.641KB
Recall Quarterly Report #2, 2018-3
RCLQRT-18V223-5178.PDF 211.225KB
Owner Notification Letter(Part 577)
RCONL-18V223-0821.pdf 31.091KB
Remedy Instructions and TSB
RCRIT-18V223-4773.pdf 182.565KB
Recall Quarterly Report #4, 2019-1
RCLQRT-18V223-6475.PDF 211.421KB
Recall Quarterly Report #3, 2018-4
RCLQRT-18V223-8785.PDF 211.314KB
Latest Recalls Documents
For the Latest and Most Recent Recalls Information Visit the link below…
https://www-odi.nhtsa.dot.gov/acms/cs/documentList.xhtml?docId=18V223&docType=RCL
“This site contains affiliate links for which OEMDTC may be compensated” |
- PRIMARY ELECTRICAL INSULATION for all wire and cable splices rated up to 600 volts
- PROTECTIVE JACKETING for high-voltage cable splices and repairs
- BUNDLE & REPAIR; harness wires and cables
- INDOOR AND OUTDOOR USE; above- or below-ground applications
- HIGH ADHESION in wide range of temperatures: 0°C (32°F)–80°C (176°F)
- 6-pack of black vinyl electrical tape rolls; 3/4 inch width x 60 foot length
- Flexible, stretchable construction ideal for electronic repairs, cord and cable bundling, and more
- Strong adhesive bonds to a wide variety of surfaces and materials; ideal for use in homes, RVs/trailers, boats, and commercial properties
- Abrasion-resistant backing for durability; protective insulation defends against corrosion, liquid damage, and more
- Can be cut by hand or used with compatible dispensers
- 7 mil vinyl tape
- Flame retardant and weather-resistant
- Rated for use up to 600-Volt and between 14-Degree F and 176-Degree F
- Excellent stretch, adhesion and conformability
- Pack of 3 rolls
- Tapewell Professional grade Electrical Tape is made from an extremely high-quality PVC vinyl. Ideal for outdoor repairs and insulating pipes and trusted by electricians for work and home improvement projects
- Primary electrical insulation for all wire and cable splices rated up to 600 volts bus applications and provides and protective jacketing for high- and low-voltage bus.
- Tapewell Electrical Tape offers excellent abrasion resistance and protection in critical applications: for electrical, U/V-rays, water, oils, acids, alkalis and other corrosive materials, and of course wrapping the extension cord your dog chewed at home.
- Suitable for use in All-Weather situations. Tapewell Electrical Tape works in temperatures as high as 176°F (80°C) and down to 0°F (-18°C).
- Our 3-pack heavy duty rolls are cut to industry standard 7-mil thick material in 66’-long rolls. Unlike others we cut ours to a full 19mm wide (a real ¾”).
- 1 ) 10 rolls value pack, 7 mil thickness black vinyl electrical tape 3/4 in. x 66 ft. x 10 rolls
- 2 ) UL and CSA listed, industrial grade & premium quality, superior adhesion while insulating and protecting
- 3 ) 10 individually wrapped rolls store easily
- 4 ) Ideal for contractors professional and industrial applications as well as DIYers hobbyists and home use, flame retardant and lead free, resistant to sun water oil acids alkalies and corrosive chemicals
- 5 ) If you aren't satisfied with your purchase, contact us through our email at any time you want, and we'll issue you a refund, to ensure you have a nice shopping experience in our store.
- PROFESSIONAL TAPE GRADE: Designed for above/below grade, indoor/outdoor, low and high voltage application and for harnessing cables. Primary insulation for splices up to 600V
- FLAME RETARDANT: Tape withstands a temperature range of 0 to 221F and inhibits the corrosion of electrical conductors
- HIGHLY CONFORMABLE: Super stretchy in all weather applications. Resists UV rays, abrasion, corrosion, alkalies and acids in all weather applications; resists UV rays, abrasion, corrosion, alkalies and acids
- COMPATIBLE: With solid dielectric cable insulation, synthetic cable insulation, jackets and splicing compounds
- SPECIFICATIONS MET: CSA Certified, IEC 60454-3-1-7/F-PVC P/90, UL Listed, VDE Marks License
- INSULATES AND PROTECTS against abrasion and moisture
- PROTECTIVE JACKETING up to 600V splice insulation
- PRESSURE-SENSITIVE RUBBER-RESIN ADHESIVE and PVC backing for electrical and mechanical protection
- INDOOR AND OUTDOOR USE
- HIGH ADHESION in extreme temperatures: 0F-221F
- 1) 10 rolls value packs, 7 mil thickness colored vinyl electrical tape 3/4 in. x 66 ft. x 10 rolls.
- 2) UL and CSA listed, industrial grade and premium quality, superior adhesion while insulating and protecting.
- 3) 10 individually wrapped rolls store easily. 10 Colored Masking Tape come in yellow, purple, black, white, gray, orange, dark green, red, dark blue, and brown.
- 4) Ideal for contractors professional and industrial applications as well as DIYers hobbyists and home use, flame retardant and lead free, resistant to sun water oil acids alkalies and corrosive chemicals.
- 5) If you aren't satisfied with your purchase, contact us through our email at any time you want, and we'll issue you a refund to ensure you have a nice shopping experience in our store.
Last update on 2024-03-23 / Affiliate links / Images from Amazon Product Advertising API
This product presentation was made with AAWP plugin.